DIN EN 13753-2009 Products used for treatment of water intended for human consumption - Granular activated alumina English version of DIN EN 13753 2009-07《饮用水处理用产品 粒状活性氧化鋁 英文版本DIN .pdf

《DIN EN 13753-2009 Products used for treatment of water intended for human consumption - Granular activated alumina English version of DIN EN 13753 2009-07《饮用水处理用产品 粒状活性氧化鋁 英文版本DIN .pdf》由会员分享，可在线阅读，更多相关《DIN EN 13753-2009 Products used for treatment of water intended for human consumption - Granular activated alumina English version of DIN EN 13753 2009-07《饮用水处理用产品 粒状活性氧化鋁 英文版本DIN .pdf（14页珍藏版）》请在麦多课文档分享上搜索。

1、July 2009DEUTSCHE NORM English price group 9No part of this standard may be reproduced without prior permission ofDIN Deutsches Institut fr Normung e. V., Berlin. Beuth Verlag GmbH, 10772 Berlin, Germany,has the exclusive right of sale for German Standards (DIN-Normen).ICS 71.100.80!$Xla“1537362www.

2、din.deDDIN EN 13753Products used for treatment of water intended for human consumption Granular activated aluminaEnglish version of DIN EN 13753:2009-07Produkte zur Aufbereitung von Wasser fr den menschlichen Gebrauch Granuliertes aktiviertes AluminiumoxidEnglische Fassung DIN EN 13753:2009-07Supers

3、edesDIN EN 13753:2003-04www.beuth.deDocument comprises pages14 DIN EN 13753:2009-07 National foreword This standard has been prepared by Technical Committee CEN/TC 164 “Water supply” (Secretariat: AFNOR, France). The responsible German body involved in its preparation was the Normenausschuss Wasserw

4、esen (Water Practice Standards Committee), Technical Committee NA 119-04-02 AA Wasseraufbereitung. Users of this standard are advised of the reservations stated in the Introduction of the European Standard and should note that national regulations exist in Germany dealing with water for human consum

5、ption, in particular the Trinkwasserverordnung (TrinkwV2001) (German Drinking Water Ordinance). The DIN Standards corresponding to the International Standards referred to in this document are as follows: ISO 9277 DIN ISO 9277 Amendments This standard differs from DIN EN 13753:2003-04 as follows: a)

6、Information on purity criteria has been included. b) A NOTE on the classification of dangerous substances has been included. Previous editions DIN EN 13753: 2003-04 National Annex NA (informative) Bibliography DIN ISO 9277, Determination of the specific surface area of solids by gas adsorption using

7、 the BET method Verordnung zur Novellierung der Trinkwasserverordnung (German Regulation amending the German Drinking Water Regulation), as of 21 May 2001, BGBl. (German Federal Law Gazette) I (2001), No. 24, pp. 959-9801)1)Registered in the DITR database of DIN Software GmbH, obtainable from: Beuth

8、 Verlag GmbH, 10772 Berlin. 2 EUROPEAN STANDARDNORME EUROPENNEEUROPISCHE NORMEN 13753March 2009ICS 71.100.80 Supersedes EN 13753:2002 English VersionProducts used for treatment of water intended for humanconsumption - Granular activated aluminaProduits utiliss pour le traitement de leau destine laco

9、nsommation humaine - Alumine active en grainsProdukte zur Aufbereitung von Wasser fr denmenchlichen Gebrauch - Granuliertes aktiviertesAluminiumoxidThis European Standard was approved by CEN on 1 February 2009.CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate

10、the conditions for giving this EuropeanStandard the status of a national standard without any alteration. Up-to-date lists and bibliographical references concerning such nationalstandards may be obtained on application to the CEN Management Centre or to any CEN member.This European Standard exists i

11、n three official versions (English, French, German). A version in any other language made by translationunder the responsibility of a CEN member into its own language and notified to the CEN Management Centre has the same status as theofficial versions.CEN members are the national standards bodies o

12、f Austria, Belgium, Bulgaria, Cyprus, Czech Republic, Denmark, Estonia, Finland,France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal,Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland and United Kingdom.EUROPEAN C

13、OMMITTEE FOR STANDARDIZATIONCOMIT EUROPEN DE NORMALISATIONEUROPISCHES KOMITEE FR NORMUNGManagement Centre: Avenue Marnix 17, B-1000 Brussels 2009 CEN All rights of exploitation in any form and by any means reservedworldwide for CEN national Members.Ref. No. EN 13753:2009: EEN 13753:2009 (E) 2 Conten

14、ts page Foreword 3 Introduction . 4 1 Scope 5 2 Normative references 5 3 Terms, definitions and symbols . 5 4 Description . 5 4.1 Identification . 5 4.2 Commercial form . 6 5 Physical properties 6 5.1 Appearance 6 5.2 Particle size distribution . 6 5.3 Bulk density packed 6 6 Chemical properties 6 7

15、 Specific properties. 7 8 Test methods 7 8.1 Sampling . 7 8.2 Analysis 7 9 Labelling, transportation and storage . 7 9.1 Means of delivery . 7 9.2 Risk and safety labelling according to the EU Directives 7 9.3 Transportation regulations and labelling 7 9.4 Marking . 8 9.5 Storage 8 Annex A (informat

16、ive) General information on granular activated alumina . 9 Bibliography 12 DIN EN 13753:2009-07 EN 13753:2009 (E) 3 Foreword This document (EN 13753:2009) has been prepared by Technical Committee CEN/TC 164 “Water supply”, the secretariat of which is held by AFNOR. This European Standard shall be gi

17、ven the status of a national standard, either by publication of an identical text or by endorsement, at the latest by September 2009, and conflicting national standards shall be withdrawn at the latest by September 2009. Attention is drawn to the possibility that some of the elements of this documen

18、t may be the subject of patent rights. CEN and/or CENELEC shall not be held responsible for identifying any or all such patent rights. This document supersedes EN 13753:2002. Differences between this edition and EN 13753:2002 are editorial to harmonize the text with other standards in this series. A

19、nnex A is informative. According to the CEN/CENELEC Internal Regulations, the national standards organizations of the following countries are bound to implement this European Standard: Austria, Belgium, Bulgaria, Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Ic

20、eland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland and the United Kingdom. DIN EN 13753:2009-07 EN 13753:2009 (E) 4 Introduction In respect of potential adverse effects on the quality of water in

21、tended for human consumption caused by the product covered by this standard: a) this standard provides no information as to whether the product may be used without restriction in any of the Member States of the EU or EFTA; b) it should be noted that, while awaiting the adoption of verifiable Europea

22、n criteria, existing national regulations concerning the use and/or the characteristics of this product remain in force. NOTE Conformity with this standard does not confer or imply acceptance or approval of the product in any of the Member States of the EU or EFTA. The use of the product covered by

23、this European Standard is subject to regulation or control by National Authorities. DIN EN 13753:2009-07 EN 13753:2009 (E) 5 1 Scope This European Standard is applicable to granular activated alumina used for treatment of water intended for human consumption. It describes the characteristics of gran

24、ular activated alumina and specifies the requirements and the corresponding test methods for granular activated alumina. It gives information on its use in water treatment. 2 Normative references The following referenced documents are indispensable for the application of this document. For dated ref

25、erences, only the edition cited applies. For undated references, the latest edition of the referenced document (including any amendments) applies. EN 12901:1999, Products used for treatment of water intended for human consumption Inorganic supporting and filtering materials Definitions EN 12902, Pro

26、ducts used for treatment of water intended for human consumption Inorganic supporting and filtering materials - Methods of test ISO 9277, Determination of the specific surface area of solids by gas adsorption using the BET method 3 Terms, definitions and symbols For the purposes of this document, th

27、e terms, definitions and symbols given in EN 12901:1999 and the following apply. 3.1 activated alumina virgin alumina that has not been used and has not been regenerated 4 Description 4.1 Identification 4.1.1 Chemical name Aluminium oxide (partially hydroxylated). 4.1.2 Synonym or common names Trans

28、ition alumina; gamma alumina; alumina; aluminium oxide; activated alumina. 4.1.3 Chemical formula Al2O(3-x)(OH)2xx varies from approximately 0 to 0,80. 4.1.4 CAS Registry number 1)1344-28-1. 1) Chemical Abstracts Service Registry Number. DIN EN 13753:2009-07 EN 13753:2009 (E) 6 4.1.5 EINECS referenc

29、e 2)215-691-6. 4.2 Commercial form Activated alumina recommended for use in drinking water treatment is a granular product consisting of irregularly shaped (non-moulded) particles; the product is available in different particle sizes. 5 Physical properties 5.1 Appearance The product consists of whit

30、e particles of irregular shape. The product shall be generally homogeneous and shall be visibly free of extraneous matter. 5.2 Particle size distribution The particle size distribution shall be described by either: a) effective size (d10) with a limit deviation of 5 %; uniformity coefficient (U) les

31、s than 1,5; minimum size (d1) with a limit deviation of 5 %; NOTE 1 The particle size can decrease during transportation and handling. b) or by particle size range and agreed mass of oversize and undersize particles; see A.2.2.1. The proportion of oversize plus undersize particles shall not exceed a

32、 mass fraction of 15 % and not more than a mass fraction of 5 % shall be undersized. NOTE 2 Other values can be necessary for certain applications. 5.3 Bulk density packed The bulk density (packed) shall be greater than 600 kg/m3.6 Chemical properties NOTE 1 After filling, washing and commissioning

33、of a filter system producing drinking water, activated alumina should not increase the concentrations of chemical parameters above the regulated values (see 1). NOTE 2 Water extractable substances, determined in accordance with the method for granular materials given in EN 12902, can be used to esti

34、mate the leaching of the chemicals specified in EN 12902. NOTE 3 Users of this product should check the national regulations in order to clarify whether it is of appropriate purity for treatment of water intended for human consumption, taking into account raw water quality, contents of other impurit

35、ies and additives used in the products not stated in the product standard. 2) European Inventory of Existing Commercial Chemical Substances. DIN EN 13753:2009-07 EN 13753:2009 (E) 7 7 Specific properties The surface area shall not be less than 200 m2/g. 8 Test methods 8.1 Sampling Prepare the labora

36、tory sample(s) required by the relevant procedures described in EN 12902. 8.2 Analysis 8.2.1 Particle size distribution The particle size distribution shall be determined on samples taken at the point of manufacture using the method of test given in EN 12902. 8.2.2 Bulk density packed The bulk densi

37、ty packed shall be determined in accordance with EN 12902. 8.2.3 Surface area The surface area shall be determined by the BET method, degassing at a maximum of 200 C, in accordance with ISO 9277. 9 Labelling, transportation and storage 9.1 Means of delivery Granular activated alumina shall be delive

38、red in bulk (dry or wet product), in semi-bulk containers or in drums of cardboard, plastics or steel or suitable bags of various sizes. In order that the purity of the product is not affected, the means of delivery shall not have been used previously for any different product or it shall have been

39、specially cleaned and prepared before use. 9.2 Risk and safety labelling according to the EU Directives 3)At the date of publication of this European Standard, activated alumina was not listed as a dangerous substance. NOTE Annex I of the Directive 67/548/EEC on Classification, packaging and labelli

40、ng of dangerous substances and its amendments and adaptations in the European Union contains a list of substances classified by the EU. Substances not in this Annex I should be classified on the basis of their intrinsic properties according to the criteria in the Directive by the person responsible

41、for the marketing of the substance. 9.3 Transportation regulations and labelling At the date of publication of this European Standard, activated alumina was not classified as dangerous for transportation by road, rail, sea or air. Activated alumina is not listed under a UN number 4). 3) See 2. 4) Un

42、ited Nations number. DIN EN 13753:2009-07 EN 13753:2009 (E) 8 9.4 Marking The marking shall include the following: the name “Activated Alumina”, trade name and grade; the net mass; the name and the address of the supplier and/or manufacturer; the statement “this product conforms to EN 13753“. 9.5 St

43、orage 9.5.1 Long term chemical stability The product is stable but hygroscopic. It can be stored for at least two years if kept dry and sealed from the atmosphere. 9.5.2 Storage incompatibilities Keep away from moisture, strong acids or strong alkalis, solvents and odorous products. DIN EN 13753:200

44、9-07 EN 13753:2009 (E) 9 Annex A (informative) General information on granular activated alumina A.1 Origin A.1.1 Raw materials Granular activated alumina is produced from aluminium hydroxide. A.1.2 Manufacturing process Activated alumina is prepared by the calcination of aluminium hydroxide. Granul

45、ar activated alumina can be prepared by granulation of activated alumina powder or calcination of aluminium hydroxide granules. A.2 Typical properties A.2.1 Chemical composition Activated alumina is a partially calcined aluminium trihydroxide with a combined water content of between a mass fraction

46、of 5 % and a mass fraction of 6 %. The crystal structure is predominantly gamma or chi alumina; small amounts of other forms can be present. The crystal structure can be determined by X-ray diffraction. The chemical composition depends on the origin of the raw material. Typical maximum limits are gi

47、ven in Table A.1, the remainder being Al2O3. Table A.1 Chemical composition of activated alumina Parameter Limit as a mass fraction of the product (typical) in % Water (loss on ignition) 5,5 to 6 Na2O 0,5 Fe2O30,015 SiO20,02 TiO20,002 A.2.2 Physical properties A.2.2.1 Particle size range Examples of

48、 particle size ranges include 1,4 mm to 2,0 mm and 2,0 mm to 4,74 mm. A.2.2.2 Density The absolute density of activated alumina is 3,2 g/cm3; the bulk density can vary with the particle size range. DIN EN 13753:2009-07 EN 13753:2009 (E) 10 A.2.2.3 Adsorption properties Granular activated alumina rem

49、oves contaminants from water by adsorption. A number of indices are used as surrogates for or measures of the adsorptive capacity of granular activated alumina under specific conditions, including specific surface area (BET isotherm). Specifications for such properties can be the subject of agreement between the customer and the manufacturer/supplier and the latter should make the test methods available, if requested. A.3 Hydraulic characteristics A.3.1 Head loss in filtration Head loss depends on size, shape and roughness of particles,