ASTM D6240 D6240M-2012 red 2390 Standard Tables of Body Measurements for Mature Men ages 35 and older Sizes Thirty-Four to Fifty-Two (34 to 52) Short Regular and Tall《对用于年龄为35岁及以上 .pdf

《ASTM D6240 D6240M-2012 red 2390 Standard Tables of Body Measurements for Mature Men ages 35 and older Sizes Thirty-Four to Fifty-Two (34 to 52) Short Regular and Tall《对用于年龄为35岁及以上 .pdf》由会员分享，可在线阅读，更多相关《ASTM D6240 D6240M-2012 red 2390 Standard Tables of Body Measurements for Mature Men ages 35 and older Sizes Thirty-Four to Fifty-Two (34 to 52) Short Regular and Tall《对用于年龄为35岁及以上 .pdf（20页珍藏版）》请在麦多课文档分享上搜索。

1、Designation:D624098 (Reapproved 2006) Designation: D6240/D6240M 12Standard Tables ofBody Measurements for Men Sizes Thirty-Four to Sixty (34to 60) RegularBody Measurements for Mature Men, ages 35and older, Sizes Thirty-Four to Fifty-Two (34 to 52) Short,Regular, and Tall1This standard is issued unde

2、r the fixed designation D6240; the number immediately following the designation indicates the year oforiginal adoption or, in the case of revision, the year of last revision. A number in parentheses indicates the year of last reapproval. Asuperscript epsilon () indicates an editorial change since th

3、e last revision or reapproval.This standard is issued under the fixed designation D6240/D6240M; the number immediately following the designation indicates theyear of original adoption or, in the case of revision, the year of last revision. A number in parentheses indicates the year of lastreapproval

4、. A superscript epsilon () indicates an editorial change since the last revision or reapproval.INTRODUCTIONThese body measurement tables were developed from evaluation of data currently used in theapparel industry. These tables were developed from data published by the U.S. Department ofCommerce,2Ca

5、esar Study,3Size USA Study,4Current USA industry and Studies, Scans anddocumentation from Alvanon Inc.5This standard takes into consideration Mature Men at a standardheight of Short 5 ft 7 in., Regular 5 ft 10 in., and Tall 6 ft 2 in. (65 % of average USA population)taking into account the decrease

6、and increase in body weight that shift a person from one size toanother, while this person does not gain in height. Major review and evaluation was done. Theincremental growth at different key body points has been addressed and defined, which resulted inidentifying increases and decreases at differe

7、nt rates in specific areas; chest, waist, high hip andhip/seat. Additionally to better serve the industry, incremental movement between sizes was reviewedensuring smooth transition between sizes. To verify the proposed body measurements, a three-dimensional Avatar was created in the Mens Short, Regu

8、lar and Tall size range 34 through 52 byAlvanon Inc. for a visual reference and is also attached in the documentation.1. Scope1.1These standard tables cover the body measurements of men from size thirty-four to sixty. Although these are bodymeasurements, they can be used in designing apparel for men

9、 in this size range when such factors as fabric type, ease of bodymovement, styling, and fit are taken into account.1.2The values stated in either acceptable metric units or in other units shall be regarded separately as standard. The values statedin each system may not be exact equivalents; therefo

10、re, each system must be used independently of the other, without combiningvalues in any way.1.1 These tables list body measurements of mature male figure type, age 35 and older, sizes 34 through 52 in Short, Regular,and Tall. Although these are body measurements, they can be used as a baseline in de

11、signing apparel for Mature Men in this sizerange when considering such factors as fabric type, ease for body movement, styling, and fit.1.2 The values stated in either SI units or inch-pound units are to be regarded separately as standard. The values stated in eachsystem may not be exact equivalents

12、; therefore, each system shall be used independently of the other. Combining values from the1These tables are under the jurisdiction of ASTM Committee D13 on Textiles and is the direct responsibility of Subcommittee D13.55 on Body Measurement for ApparelSizing.Current edition approved Jan.Feb. 1, 20

13、06.2012. Published February 2006.March 2012. Originally approved in 1998. Last previous edition approved in 19982006 asD624098(2006). DOI: 10.1520/D6240-98R06.10.1520/D6240_D6240M-12.2For referenced ASTM standards, visit the ASTM website, www.astm.org, or contact ASTM Customer Service at serviceastm

14、.org. For Annual Book of ASTM Standardsvolume information, refer to the standards Document Summary page on the ASTM website.2U.S. Department of Commerce, Voluntary Product Standard: Body Measurements for the Sizing of Childrens Apparel, NIST Publication No. PS 54-172, Washington,DC.3Available from A

15、merican National Standards Institute, 11 W. 42nd St., 13th Floor, New York, NY 10036.3Caesar: Summary Statistics for the Adult population (Ages 18-65) of the United States of America, June 2002.4Available from: http:/ Inc., 145 W. 30th Street, Suite 1000, New York, NY 10001.1This document is not an

16、ASTM standard and is intended only to provide the user of an ASTM standard an indication of what changes have been made to the previous version. Becauseit may not be technically possible to adequately depict all changes accurately, ASTM recommends that users consult prior editions as appropriate. In

17、 all cases only the current versionof the standard as published by ASTM is to be considered the official document.Copyright ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.two systems may result in non-conformance with the standard.1.3 This sta

18、ndard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibilityof the user of this standard to establish appropriate safety and health practices and determine the applicability of regulatorylimitations prior to use.2. Referenced Documents2.1 AS

19、TM Standards:6D123 Terminology Relating to TextilesD5219 Terminology Relating to Body Dimensions for Apparel Sizing2.2 ISO Standard:7ISO 3635 Size Designation of Clothes, Definitions, and Body Measurement Procedures Apparel Sizes3. Terminology3.1 Definitions:3.1.1 For definitions relating to body di

20、mensions, refer to Terminology D5219.3.1.2 For definitions of other textile terms used in these tables, refer to Terminology D123.4. Significance and Use4.1 The use of the body measurement information in Tables 1-4 will assist manufacturers in the development of patterns andgarments that are consist

21、ent with the current anthropometric characteristics of the population of interest. These standard tables inturn should reduce or minimize consumer confusion and dissatisfaction related to apparel sizing. (Also refer to ISO 3635.) Tables1 and 2 will assist manufacturers in developing patterns and gar

22、ments that are consistent with the current anthropometriccharacteristics of the population of interest. This practice should in turn reduce or minimize consumer confusion and dissatisfactionrelated to apparel sizing. (Also refer to ISO 3635 Size Designation Procedures.)4.2 Three-dimensional avatars

23、depicting each of the mature mens sizes in short, regular and tall, were created by Alvanon, Inc.and included in this standard to assist manufacturers in visualizing the posture, shape, and proportions generated by themeasurements charts in the accompanying Tables. (Avatar 1-6) See Figs. 1-3.5. Appa

24、ratus5.1 Tape Measure, (dimensionally stable and approximately 1.5 cm (1/2 in.)12 in. wide and graduated accurately in cm (1/16in.). 116 in.).5.2 Plastic Goniometer, to measure the radian (degree) of shoulder slope.5.3 Scale, standard, calibrated, body weight type.5.4 Metal Ruler.6. Procedure6.1 Gen

25、eral ProcedureGeneral:6.1.1For all vertical and most horizontal measurements, subject is to be standing erect without shoes and with feet approximately15 cm (6 in.) apart.6.1.2Take measurements over basic undergarments normally worn.6.1.3Take all measurements except torso circumferences, height, and

26、 weight from the same side of the body for consistency.6.1.1 For all vertical and most horizontal measurements, subject is to be standing erect without shoes and with feetapproximately 15 cm 6 in. apart. (For Infant special cases) For all vertical and most horizontal measurements, subject is to bely

27、ing down flat with legs extended and foot positioned at 1.57 rad (90) to the leg.6.1.2 Take measurements over undergarments normally worn.6.1.3 Take all measurements from the same side of the body for consistency.6.1.4 Refer to Terminology D5219 for the location of all points to be measured.6.2 Body

28、 Measurements:6.2.1 Body weightWeigh the subject. Body WeightWeight as measured on a calibrated scale taken with the subject inundergarments.6.2.2 ChestMeasure the circumference of the body parallel to the floor, under the arms, and over the fullest part of the chest.Head GirthMeasure the maximum ho

29、rizontal circumference of the head above the ears.6.2.3 WaistMeasure horizontally around the body at waist height. Neck Base GirthMeasure the circumference of the neck,taken over the cervicale at the back and the top of the collarbone at the front.6For referenced ASTM standards, visit the ASTM websi

30、te, www.astm.org, or contact ASTM Customer Service at serviceastm.org. For Annual Book of ASTM Standardsvolume information, refer to the standards Document Summary page on the ASTM website.7Available from American National Standards Institute (ANSI), 25 W. 43rd St., 4th Floor, New York, NY 10036, ht

31、tp:/www.ansi.org.D6240/D6240M 122TABLE 1 New ASTBody M Mens Measurement Tables, Inch-Pound UnitsSizes: 34 35 36 37 38 39 40 41 42 43 44 45 46 48 50 52Small(34-37),lbMedium(38-41)N/A Large(42-45)N/A X-Large(46-49)N/AN/A N/A N/A N/A N/A N/AN/AN/AN/ABodyWeight(Mean),lbMedium(38-41)N/A Large(42-45)N/A N

32、/A N/A N/A N/A N/A N/A N/AN/AN/AN/AWeight(Approximatekilograms)58.06 59.42 62.60 65.77 69.40 74.84 81.65 83.92 88.45 90.72 95.26 97.52 104.33 106.60 111.13N/A N/ABodyWeight(Range),lbN/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/AGirthMeasurements,inchesGirthMeasurements(cm)3435 36 37

33、 38 39 40 41 42 43 44 45 46 48 50 52GirthMeasurements,inches34 35 36 37 38 39 40 41 42 43 44 45 46 48 50 52Sizes 2158 2178 22 2214 2238 2258 2234 23 2318 2338 2312 2334 2378 2414 2458 25HeadGirth2158 2178 22 2214 2238 2258 2234 23 2318 2338 2312 2334 2378 2414 2458 25NeckBaseGirth1518 1538 1558 1578

34、 1618 1638 1658 1678 1718 1738 1758 1778 1818 1858 1918 1958Mid-NeckGirth1414 1412 1434 15 1514 1512 1534 16 1614 1612 1634 17 1714 1734 1814 1834ShoulderGirth4238 43 4358 4414 4478 4512 4618 47 4778 4834 4958 5012 5138 5318 5478 5658Chest/BustGirth34 35 36 37 38 39 40 41 42 43 44 45 46 47 50 52Ches

35、t/BustGirth34 35 36 37 38 39 40 41 42 43 44 45 46 48 50 52Under-BustGirthN/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/AUpper-ChestGirthN/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/AWaistGirth2812 2912 3012 3112 3212 3312 3412 3512 3612 3712 3812 3934 41 4312 46 4812

36、Chest 86.36 88.90 91.44 93.98 96.52 99.06 101.6034 104.14 106.6834 109.2258 111.76 114.30 116.84 119.38121.924612 4812High-HipGirth3034 3134 3234 3334 3434 3534 3634 3734 3834 3958 4012 4112 4212 4412 4612 4812Waist 71.12 73.66 76.20 78.74 81.28 83.8212 86.36 88.9012 91.44 93.98 96.52 99.70 102.87 1

37、06.05 104712 49.22Hip/SeatGirth3312 3412 3512 3612 3712 3812 3912 4012 4112 4214 43 4334 4412 46 4712 49Seat(hip)86.36 88.9012 91.44 93.98 96.52 99.06 101.60 104.14 106.68 109.22 111.76 114.30 116.84 119.38 121.97 2ThighGirth20 2012 21 2112 22 2212 23 2312 24 2438 2434 2518 2512 2614 27 2734Headcirc

38、umference54.93 55.40 55.88 56.36 56.83 57.31 57.79 58.26 58.74 59.21 59.69 60.17 60.64 61.12 61.602478 2534Mid-ThighGirth1858 1918 1958 20 2038 2034 2118 2112 2178 2214 2258 23 2338 2418 2478 2534Neckbase35.56 36.20 36.83 37.4734 38.10 38.74 39.37 40.01 40.64 41.28 41.91 42.55 43.18 43.82 44.4518 18

39、12KneeGirth14 1414 1412 1434 15 1514 1512 1534 16 1614 1612 1634 17 1712 18 1812Shouldercircumference101.60 104.14 106.68 109.22 111.76 114.3034 116.84 119.38 121.92 124.46 127.00 129.54 132.08 134.62 137.12 16Calf Girth 1312 1334 14 1414 1412 1434 15 1514 1512 1534 16 1614 1612 17 1712 18Armscye 41

40、.5934 42.55 43.18 44.13 45.0914 46.0438 46.99 47.94 48.9034 49.85 50.80 51.75 52.71 53.66 54.61134 12AnkleGirth934 978 10 1018 1014 1038 1012 1058 1034 1078 11 1118 1114 1112 1134 12Upperarm29.21 29.8512 30.48 31.12 32.39 33.02 33.66 34.93 34.29 34.93 35.56 36.20 36.8378 37.47 38.10D6240/D6240M 1236

41、.2.4 Seat (hip)Measure horizontally around the body at hip height. Mid Neck GirthMeasure the horizontal circumferenceTABLE 1 ContinuedSizes: 34 35 36 37 38 39 40 41 42 43 44 45 46 48 50 52ArmscyeGirth -Short1514 1512 1534 1618 1612 1678 1714 1712 1734 18 1838 1858 1878 1938 20 2058Elbow 27.62 28.10

42、28.58 29.05 29.53 30.00 30.48 30.96 31.43 31.91 32.39 32.86 33.34 33.81 34.29038 21ArmscyeGirth -Regular1558 1578 1618 1612 1678 1714 1758 1778 1818 1838 1834 19 1914 1934 2038 21Wrist 17.15 17.4614 17.78 18.10 18.42 18.7358 19.05 19.37 19.69 20.00 20.32 20.64 20.9658 21.27 2034 21.5938ArmscyeGirth

43、-Tall16 1614 1612 1678 1714 1758 18 1814 1812 1834 1918 1938 1958 2018 2034 2138Thigh 52.71 54.29 55.88 57.47 59.06 60.64 62.2314 63.8212 65.41 66.99 68.58 70.17 71.76 73.34 74.931534 1614Upper-Arm Girth1134 12 1214 1212 1234 13 1314 1312 1334 14 1414 1412 1434 1514 1534 1614Knee 36.83 37.47 38.10 3

44、8.74 39.37 40.01 40.64 41.2814 41.91 42.5558 43.18 43.82 44.45 45.09 1378 145.7214ElbowGirth1078 1118 1114 1112 1158 1178 12 1214 1238 1258 1234 13 1318 1312 1378 1414Calf 34.29 34.93 35.56 36.20 36.83 37.4738 38.10 38.7412 39.3758 40.01 40.64 41.28 41.91 42.55 43.1814WristGirth718 718 714 714 738 7

45、38 712 712 758 758 734 778 8 818 814 838Ankle 21.59 22.23 22.86 23.50 24.13 24.77 25.40 26.04 26.67 27.31 27.94 28.58 29.21 29.85 30.48N/A N/AHandGirthN/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/ATrunk(totaltrunk,torso)150.5012 153.3534 156.2118 158.75 161.2978 163.8318 166.3712 16

46、8.12 169.86 171.61 173.36 174.94 176.69 178.4418 186914 70.0212TrunkLength(totalverticalgirth) -Short6112 6134 6218 6212 6278 6318 6312 6418 6434 6538 6578 6612 67 6818 6914 7012Totalcrotch62.2312 63.8234 65.4118 66.99 68.58 69.8518 71.12 72.39 73.6634 74.9338 76.20 77.47 78.74 80.0118 81.14 2812Tru

47、nkLength(totalverticalgirth) -Regular6312 6334 6418 6412 6478 6518 6512 6618 6634 6738 6778 6812 69 7018 7114 7212TrunkLength(totalverticalgirth) -TallVerticalMeasurements(cm)67186738 6734 6818 6812 6834 6918 6934 7038 71 7112 7218 7258 7334 7478 7618TrunkLength(totalverticalgirth) -Tall6718 6738 67

48、34 6818 6812 6834 6918 6934 7038 71 7112 7218 7258 7334 7478 7618Sizes 34 35 36 37 38 39 40 41 42 43 44 45 46 47 4850 52VerticalMeasurements,inches34 35 36 37 38 39 40 41 42 43 44 45 46 48 50 52Stature 172.09 173.04 173.99 175.42 176.21 177.32 178.44 178.91 179.55 180.02 180.66 180.98 181.29 181.61 181.7 7Height -Short67 67 67 67 67 67 67 67 67 67 67 67 67 67 67 67Cervicaleheight148.27 149.07 149.86 151.13 151.77 152.72 153.67 154.15 154.62 155.10 155