ASTM D1631-2010 Standard Test Method for Water in Phenol and Related Materials by the Iodine Reagent Method《碘试剂法测定苯酚和相关材料中的水的标准试验方法》.pdf
《ASTM D1631-2010 Standard Test Method for Water in Phenol and Related Materials by the Iodine Reagent Method《碘试剂法测定苯酚和相关材料中的水的标准试验方法》.pdf》由会员分享,可在线阅读,更多相关《ASTM D1631-2010 Standard Test Method for Water in Phenol and Related Materials by the Iodine Reagent Method《碘试剂法测定苯酚和相关材料中的水的标准试验方法》.pdf(4页珍藏版)》请在麦多课文档分享上搜索。
1、Designation: D1631 10Standard Test Method forWater in Phenol and Related Materials by the IodineReagent Method1This standard is issued under the fixed designation D1631; the number immediately following the designation indicates the year oforiginal adoption or, in the case of revision, the year of l
2、ast revision. A number in parentheses indicates the year of last reapproval. Asuperscript epsilon () indicates an editorial change since the last revision or reapproval.This standard has been approved for use by agencies of the Department of Defense.1. Scope*1.1 This test method covers the determina
3、tion of water inphenol and related materials such as cresols, xylenols, naph-thalene, pyridine, and quinoline.1.2 This test method has been found applicable to a varietyof materials varying in water content from 100 mg/kg tosolutions containing a relatively high percent of water.1.3 In determining t
4、he conformance of the test results usingthis method to applicable specifications, results shall berounded off in accordance with the rounding-off method ofPractice E29.1.4 The values stated in SI units are to be regarded asstandard. No other units of measurement are included in thisstandard.1.5 This
5、 standard does not purport to address all of thesafety concerns, if any, associated with its use. It is theresponsibility of the user of this standard to establish appro-priate safety and health practices and determine the applica-bility of regulatory limitations prior to use. For specific hazardsta
6、tements, see Section 9.2. Referenced Documents2.1 ASTM Standards:2D1364 Test Method for Water in Volatile Solvents (KarlFischer Reagent Titration Method)D3437 Practice for Sampling and Handling Liquid CyclicProductsD3852 Practice for Sampling and Handling Phenol,Cresols, and Cresylic AcidD4790 Termi
7、nology ofAromatic Hydrocarbons and RelatedChemicalsD6809 Guide for Quality Control and Quality AssuranceProcedures for Aromatic Hydrocarbons and Related Ma-terialsE29 Practice for Using Significant Digits in Test Data toDetermine Conformance with Specifications2.2 Other Document:3OSHA Regulations, 2
8、9 CFR paragraphs 1910.1000 and1910.12003. Terminology3.1 See Terminology D4790 for definition of terms used inthis test method.4. Summary of Test Method4.1 When solutions of iodine in methanol and of sulfurdioxide in pyridine are mixed in the presence of water, thefollowing reaction occurs:I21 SO21
9、H2O2HI 1 SO3(1)4.1.1 Sufficient pyridine is present in the reagent to consumethe hydriodic acid and sulfur trioxide:4.1.2 The pyridine sulfur trioxide salt reacts with the metha-nol, this preventing a second mole of water from beingconsumed:4.2 When the pyridine solution contains water and the sulfu
10、rdioxide is titrated with iodine in methanol solution, the1This test method is under the jurisdiction of ASTM Committee D16 onAromatic Hydrocarbons and Related Chemicals and is the direct responsibility ofSubcommittee D16.02 on Oxygenated Aromatics.Current edition approved Jan. 1, 2010. Published Ja
11、nuary 2010. Originallyapproved in 1959. Last previous edition approved in 2004 as D1631 99 (2004).DOI: 10.1520/D1631-10.2For referenced ASTM standards, visit the ASTM website, www.astm.org, orcontact ASTM Customer Service at serviceastm.org. For Annual Book of ASTMStandards volume information, refer
12、 to the standards Document Summary page onthe ASTM website.3Available from U.S. Government Printing Office Superintendent of Documents,732 N. Capitol St., NW, Mail Stop: SDE, Washington, DC 20401.1*A Summary of Changes section appears at the end of this standard.Copyright ASTM International, 100 Bar
13、r Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.platinum electrodes remain polarized until all the water reacts.A slight excess of iodine depolarizes the electrodes, allowingcurrent to flow through the microammeter which indicates theend point.5. Significance and Use5.1
14、This test method is particularly useful for determiningsmall amounts of water in hygroscopic materials. This testmethod is suitable for setting specifications on materialsreferenced in the scope. It may also be used as an internalquality control tool and in development or research work.6. Interferen
15、ces6.1 This test method is not applicable in the presence ofmercaptans, peroxides, or appreciable quantities of aldehydesor amines.6.2 If ketones are present in the sample, interference fromthem can be avoided by employing the glycol-pyridine samplesolvent specified in Test Method D1364.7. Apparatus
16、7.1 The apparatus shall be assembled as shown in Fig. 1.Any suitable modification permitting equal facility and accu-racy may be used. Automatic titration equipment is commer-cially available and may be used.8. Reagents8.1 Reagent grade chemicals shall be used in all tests.Unless otherwise indicated
17、, it is intended that all reagents shallconform to the specifications of the Committee on AnalyticalReagents of the American Chemical Society, where suchspecifications are available.4Other grades may be used, pro-vided it is first ascertained that the reagent is of sufficientlyhigh purity to permit
18、its use without lessening the accuracy ofthe determination.8.2 Iodine SolutionDissolve 150 g of iodine (I2) crystalsin 3 L of anhydrous methanol. Place the solution in the reagentbottle connected to the buret as shown in Fig. 1.8.3 Methanol, anhydrous, containing less than 0.05 % wa-ter.8.4 Pyridine
19、 SolutionPlace 4000 mL of refined gradepyridine in a 5000-mL distilling flask. Distill over and discard400 mL of forecut at atmospheric pressure. Distill off 3400 mLof center cut and transfer to a suitable glass bottle fitted with atwo-hole stopper. Through one hole of the stopper insert apiece of g
20、lass tubing that extends almost to the bottom of thebottle; through the other hole insert a short piece of glasstubing to serve as a vent. Through the long tube add 400 g ofrefrigerant-grade sulfur dioxide (SO2) dried through concen-trated sulfuric acid (H2SO4sp gr 1.84), and allow the solutionto co
21、ol. Fit the vent tube with a drying tube and an aspiratorbulb; connect the long tube with an adapter suitable forintroducing the reagent into the titration flask. For conveniencein measuring, a suitable reservoir may be placed in the system.NOTE 1In place of the divided reagents described in 8.2, 8.
22、3, and 8.4it is permissible to employ the single solution reagent specified in TestMethod D1364 or commercial Karl Fischer reagents. Pyridine-free re-agents are available from various laboratory suppliers and may be used ifsuitable for the material being tested.8.5 When handling Karl Fischer reagent
23、 refer to PracticeD3437.9. Hazards9.1 Consult current OSHA regulations suppliers MaterialSafety Data Sheets and local regulations for all materials usedin this test method.9.2 Phenol, pyridine, and related materials are extremelytoxic when ingested and corrosive to the skin. Appropriateprecaution mu
24、st be exercised when handling them.10. Sampling10.1 Sample in accordance with Practice D3852 for propersampling and handling of phenol and related materials ana-lyzed by this test method (see 9.1 and 9.2.).10.2 Precautions must be taken in sampling to preclude anypossibility of contamination with at
- 1.请仔细阅读文档,确保文档完整性,对于不预览、不比对内容而直接下载带来的问题本站不予受理。
- 2.下载的文档,不会出现我们的网址水印。
- 3、该文档所得收入(下载+内容+预览)归上传者、原创作者;如果您是本文档原作者,请点此认领!既往收益都归您。
下载文档到电脑,查找使用更方便
10000 积分 0人已下载
下载 | 加入VIP,交流精品资源 |
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- ASTMD16312010STANDARDTESTMETHODFORWATERINPHENOLANDRELATEDMATERIALSBYTHEIODINEREAGENTMETHOD 试剂 测定 苯酚 相关

链接地址:http://www.mydoc123.com/p-510184.html