DLA A-A-55082-1992 INSECT NET HAT SUN HOT WEATHER《热天昆虫网防晒帽》.pdf

《DLA A-A-55082-1992 INSECT NET HAT SUN HOT WEATHER《热天昆虫网防晒帽》.pdf》由会员分享，可在线阅读，更多相关《DLA A-A-55082-1992 INSECT NET HAT SUN HOT WEATHER《热天昆虫网防晒帽》.pdf（5页珍藏版）》请在麦多课文档分享上搜索。

1、A-A-55082 m 9999974 OLL95L8 735 m I INCH-POUND 1 A-A-5508 2 24 November 1992 COMMERCIAL ITEM DESCRIPTION INSECT NET, HAT, SUN, HOT WEATHER The General Services Administration has authorized the use of this Commercial Item Description in preference to MIL-1-43746. Abstract. This commercial item descr

2、iption covers an insect net made of nylon tricot netting of one type and size, for use in tropical and semi-tropical areas. Salient Characteristics. The insect net shall be made of one piece of netting with a center back seam and elastic braid inserted in the top and bottom hems. Two loops made of e

3、lastic braid shall extend from the bottom hem (attached from inside of hem). The loops shall be spaced 6 inches apart and centered at front of insect net. The thread for all stitching shall be polyester. Material. The material for the insect net shall be nylon tricot weighing a minimum of 0.3 ounces

4、 per square yard and a maximum of 0.7 ounces per square yard. The color of the material shall be Dark Green 323. The fabric shall be resin treated. Beneficial comments (recommendations, additions, deletions) and any pertinent data which may be of use in improving this document should be addressed to

5、: Defense Personnel Support Center, Clothing and Textiles Directorate, Attn: DPSC-FSSD, 2800 South 20th Street, Philadelphia, PA 19101-8419, by using the Standardization Document Improvement Proposal (DD Form 1426) appearing at the end of this document or by letter. AMSC N/A FSC 8415 DISTRIBUTION ST

6、ATEMENT A. Approved for public release; distribution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55082 9999974 OLL95L9 b7L A-A-5508 2 Characteristic The insect net shall show fastness to the following: Test Method AATCC 61 - Col

7、orfastness to Laundering, Home, and Commercial: Accelerated AATCC 15 - Colorfastness to Perspiration Laundering Perspiration Crocking Light Thread. The thre d AATCC 8 - Colorfastness to Crocking: AATCC Crockmeter Method AATCC 16 - Colorfastness to Light hall be polyester, general purpose, Tex s,ze 3

8、5, 2 or 3 ply and shall have a breaking strength of 2.0. Braid. flat, using 210 denier nylon, and dyed Olive Green 106. The nylon elastic braid shall be 3/16 2 1/32 inch wide, Label. mildew-resistant and sufficiently sized to indicate the inscription as follows: A commercial type label is acceptable

9、 provided that it is Item description Contract number National stock number Fur, Wool or Fiber Products Act information Contractors name (bottom of label) Patterns. The government shall furnish a single size pattern. Commercial patterns may be used in lieu of the government furnished pattern provide

10、d they conform to the cited design and finished measurements. Sizes and measurements. The finished insect net shall conform to the measurements below. Table I. Finished measurements (inches) Length 1/2 top 1 / 2 bot tom (relaxed) L/ (elastic relaxed) 2/ (elastic relaxed) 31 16-1/2 + 1/2 10 + 1/2 9-1

11、/4 + 1/2 - i/ - 2/ - 3/ Measure from top to bottom along the joining seams. Measure across the top edge from folded edge to folded edge. Measure across bottom edge from folded edge to folded edge. 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A

12、-55082 m 9999974 o119520 393 m A-A-5508 2 Workmanship. After completion, the finished insect net shall be thoroughly cleaned, and all loose thread, lint, and foreign matter removed. Product Demonstration Model. When required, offerers shall submit samples of their intended production. The Product De

13、monstration Model will consist of units independently developed. Product Demonstration Models will be analyzed and evaluated by the government. Evaluation criteria and basis for award are contained in the solicitation. Product Demonstration Models will be retained by the government. One (1) Product

14、Demonstration Model approved by DPSC under the resultant contract will serve as a manufacturing standard for the corresponding production items delivered under this contract. Offerers are advised that the Product Demonstration Model does not relieve the successful offerer of his responsibility to pe

15、rform in accordance with the Commercial Item Description specified above. Qualitv Assurance Certification. The contractor shall certify that the product offered meets the salient characteristics of this description and that the product conforms to the producer.s own drawings, specifications, standar

16、ds and quality assurance practices. The government reserves the right to require proof of such conformance prior to the first delivery and thereafter as may be otherwise provided for, under the provisions of the contract. Reliance on contractor QA systems shall not relieve the contractor of the resp

17、onsibility of ensuring that all products or supplies submitted to the government for acceptance comply with all requirements of the contract. Examination. Insect net lots shall be inspected in accordance with “Sampling Procedures and Tables for Inspection by Attributes“, ANSI/ASQC 21.4, published by

18、 the American Society for Quality Control. Visual Examination. The insect nets shall be examined for the defects listed below. The lot size shall be expressed in units of insect nets. The sample unit is one insect net. The inspection level shall be II and the acceptable quality level (AQL), expresse

19、d in terms of defects per hundred units, shall be 1.0. Defects. The insect net shall be examined for the following defects: any cut, tear or hole not specified; any cut or abraided area; any incorrect seam or stitch type; any loose or excessive tension; incorrect number of stitches per inch; ends no

20、t secured as specified; thread breaks, skipped or run-off stitches; loose or missing button tacks; any loose or missing elastic braid loops; not clean; label missing, incorrect, or illegible; measurement of item not as specified. Provided by IHSNot for ResaleNo reproduction or networking permitted w

21、ithout license from IHS-,-,-A-A-55082 9999974 OL1952L 22T A-A-5508 2 Dimensional Examination. The finished insect nets shall conform to the dimensions specified. Any dimension that is not within the established tolerance shall be classified as a defect. The sample unit shall be one insect net; the i

22、nspection level shall be S-3 and the AQL, expressed in terms of defects per hundred units, shall be 1.5. Packaqinq Examination. The fully packaged shipping containers shall be examined in accordance with defects listed below. The lot size shall be the number of shipping containers in the inspection

23、lot. The inspection level shall be S-2 and AQL, expressed in terms of defects per hundred units, shall be 1.0. EXAMINE DEFECT Marking Omitted; incorrect; illegible; (exterior and interior) of improper size, location, or method of application Ma ter ia 1 s Workmanship Content Palletization Any compon

24、ent missing, damaged, or not as specified Inadequate application of components, such as: incomplete closure of container flaps, loose strapping, improper taping, or inadequate stapling Number of items in container is more or less than required NSN shown on one or more items not as specified on shipp

25、ing container Length, width, or height exceeds specified maximum requirements Pallet type not as specified Load not bonded as specified Remlatory Reauirements. The offeror/contractor is encouraged to use recovered materials in accordance with Public Law 94-580 to the maximum extent practicable. 4 Pr

26、ovided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55082 = 999997q OLL9522 Lbb A-A-5508 2 Preservation, Packinu, and Markinq. The preservation, packing, and marking shall be as specified in the contract or order. Source of Government Documents. Copies

27、 of Military and Federal documents are available from: Standardization Documents Order Desk Bldg. 4D 700 Robbins Avenue Philadelphia, PA 19111-5094 Sources of Nongovernment Documents. ANSI/ASQC 21.4 - Sampling Procedures and Tables For Inspection By Attributes (Applications for copies should be addr

28、essed to American National Standards Institute, 1430 Broadway, New York, NY 10018- 3308. ) AATCC Test Methods (Applications for copies should be addressed to American Association of Textile Chemists and Colorists (AATCC), P.O. Box 12215, Triangle Park, NC 27709-2215) Custodians: Army - GL Air Force - 99 Review Activities: Civil Agency Coordinating Activity: GSA - FSS Preparing Activity: DLA - CT Army - MD Air Force - 82 Project No. 8415-0869 User Activity: Air Force - 45 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-