ARMY MIL-T-70431-1982 TEST SET ELECTRONIC SYSTEM M137《M137型电子系统测试装置》.pdf

《ARMY MIL-T-70431-1982 TEST SET ELECTRONIC SYSTEM M137《M137型电子系统测试装置》.pdf》由会员分享，可在线阅读，更多相关《ARMY MIL-T-70431-1982 TEST SET ELECTRONIC SYSTEM M137《M137型电子系统测试装置》.pdf（39页珍藏版）》请在麦多课文档分享上搜索。

1、in the solicitation. form extent specified hekein. O SPE C IF1 CAT IONS MILITARY MIL-T-28800 MIL-W-6 3 150 MIL -ST D- 1 O 5 MIL -ST D- 2 8 O MIL-T-70431 (AR) 15 December 1982 MILITARY SPECIFICATION TEST SET, ELECTRONIC SYSTEM: M137 This specification is approved for use by the U.S. Army Armament, Mu

2、nitions and Chemical Command and is available for use by all Departments and Agencies of the Department of Defense. 1. SCOPE 1.1 Scope. This specification covers requirements, quality assurance provisions, and preparation for delivery for Test Set, Electronics System: M137. 2. APPLICABLE DOCUMENTS 2

3、.1 Government documents. 2.1.1 Specifications, standards and handbooks. Unless otherwise specified (see 6.2), the following specifications and standards of the issue listed in that issue of the Department of Defense Index of Specifications and Standards (DoDISS) specified a part of this specificatio

4、n t the - Test Equipment for Use With Electronic Equipment, General Specification for. - Weapons and S uppor t Material, Standard Quality Assurance Provision for. - Sampling Procedures and Tables for Inspection by A ttr ibu tes, - Definitions of Item Levels, Item Exchangeability, Models and Related

5、Terms. FSC i2 Beneficial comments (recommendations, additions, deletions) and any pertinent data which may be of use in improving this document should be addressed to: Commander, US Arm Armament Research and Development Center, Attn. DRSMC-QA, Dover, New ?key M8f by using the self-addressed Standard

6、ization Dacument Improvement Proposal (DD Form 1426) appearing at the end of this document or by letter. I THIS gQuF“4EpiT COB5dTABPdS 3 F%A!3* -_- - 1 + I10 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-T-70431 (AR) STANDARDS MILITARY MIL-STD-

7、1235 - Single and Multi-Level Con ti nuous Sampling P rocedu res and Tables for Inspection by Attributes. 2.1.2 Other Government documents, drawings, and publications. The following other Government documents, drawings and publications form a part of this specification to the extent spec if i ed he

8、re in : DRAW IN GS US ARMY ARMAMENT RESEARCH AND DEVELOPMENT COMMAND PRODUCT 11831041 - Test Set, Electronics System. PACKAGING Pl1831041 - Test Set, Electronics System. PUB LI: CATIONS HEADQUARTERS, DEPARTMENT OF THE ARMY Technical Manual TM 9-4933-244-13 the other case contains all the interconnec

9、ting cabling necessary to interface the test set to the armament subsystem components as well as the self-test cable and the firing simulator assembly. The test set shall provide the operator with the ability to perform a functional checkout of the armament sybsystem and fault diagnosis to a defecti

10、ve line replaceable unit (LRU) and further fault isolation of that LRU to a shop replaceable unit (SRU). Additionally, the test set provides adjustment and alignment capability of system components. 3.1.1 Government furnished property list. Each test set shall inclue a government furnished technical

11、 manual, TM9-4933-224-13 however, a few light scratches not exposing base material may be permitted. All required markings and stamping shall be neat and sharply defined. Required packaging shall be dry. Threads shall be full and undamaged for the entire minimum length or depth as required on the ap

12、plicable drawing. Cable assemblies and wires shall be dressed in such a manner as to prevent pinching or chafing the wire insulation. Ends of wires shall be free from burrs, sharp edges or points. 4. QUALITY ASSURANCE PROVISIONS 4.1 Responsibility for insgection and standard quality assurance provis

13、ions. Unless otherwise specified herein or in the contract, the provisions of MIL-W-63150 shall apply and are hereby made a part of this detail specification. 4.2 Certification of provisions. The certification provisions of MIL-W-63150 shall apply. 4.3 Classification of inspection. The following typ

14、es of inspection shall b e conducted on this item. 23 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- -_- _- MIL-T-70433 L3 = 777770b 0354307 b W a. First Article Inspection. b. Quality Conformance Inspection. 4.4 First article inspection. 3. 4.4.1

15、Submission. The contractor shall submit a first article sample as designated by the Contracting Officer for evaluation in accordance with provisions of 4.4.2. The first article sample shall consist of the following items in sample quantities as indicated. Part Description Drawing . Quantity Test Set

16、 Electronic Systems, M137 Case Assembly F ir i ng S imula tor As sembly Case, Cable Test Set Assembly Panne1 Assembly Front Case Assembly Circuit Card Assembly, programmable Memory (A) Circuit Card Assembly, programmable Memory (B) 11831041 1183 10 46 11830648 11830714 11830999 1183 107 2 1183 100 1

17、 11831008 1183 1007 5 5 4.4.2 Inspections to be performed. First article assemblies components and test specimens may be subjected by the Government to all of the examinations and tests specified in the item detail specification and to any requirements of the applicable drawings. See Table X specifi

18、ed herein. 4.4.3 Rejection. If any assembly, component, or test specimen fails to comply with any applicable requirements, the first article sample shall be rejected. The Government reserves the right to terminate its inspection upon any failure of any assembly, component, or test specimen in the sa

19、mple that fails to comply with any of the stated requirements. 24 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-. C O ci al rl u ad *; ci rn u .d E x w n m d n p: 4 rl m * O fi I B I U H c r c r Y ci 8 ul d Y W Z O v) 3 la c 3 “0 c I Provided by IH

20、SNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- MIL-T-70431 33 9979906 0354332 T li Li I c h rl P E aJ m 2 8 ci m rl .ri VI m c .ri u 4 Er cv CJ In * e . . - li m m c 2 rlrlrlrlrld rl 2 rl rlrl mrdmmrrfm m (d m mm 553353 5 5 5 55 mmmmmul to m o rom dpdpdpdpdpdp d

21、p dp InInInInInIn In In dp dpdp WWWWWW W W In Inm 000000 o o rl rlrl e. . . 0 e. 5 aJ c .ri rCI aJ 5 al c 8 O c .d m o .d E ci 5 C 8 3 a, u u m al u ma 3rn ruo u0 wrl 5: k rl (61 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-I E.i I c H r c r !i? n 8 v) d um Y Z O F -0 aJ v) aJ U rd aJ L rn a3 .I- .I- F a 4 n O W s-4 EL O LL n “. 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-