DLA MIL-PRF-24236 13 J-2012 SWITCHES THERMOSTATIC (BIMETALLIC) TYPE I HERMETICALLY SEALED SINGLE POLE SINGLE THROW (SPST) 1 AMPERE AND LOW LEVEL.pdf

《DLA MIL-PRF-24236 13 J-2012 SWITCHES THERMOSTATIC (BIMETALLIC) TYPE I HERMETICALLY SEALED SINGLE POLE SINGLE THROW (SPST) 1 AMPERE AND LOW LEVEL.pdf》由会员分享，可在线阅读，更多相关《DLA MIL-PRF-24236 13 J-2012 SWITCHES THERMOSTATIC (BIMETALLIC) TYPE I HERMETICALLY SEALED SINGLE POLE SINGLE THROW (SPST) 1 AMPERE AND LOW LEVEL.pdf（8页珍藏版）》请在麦多课文档分享上搜索。

1、AMSC N/A FSC 5930 INCH-POUND MIL-PRF-24236/13J 25 October 2012 SUPERSEDING MIL-PRF-24236/13H 3 May 2010 PERFORMANCE SPECIFICATION SHEET SWITCHES, THERMOSTATIC, (BIMETALLIC), TYPE I, HERMETICALLY SEALED, SINGLE POLE, SINGLE THROW (SPST), 1 AMPERE AND LOW LEVEL This specification is approved for use b

2、y all Departments and Agencies of the Department of Defense. The requirements for acquiring the switches described herein shall consist of this specification sheet and MIL-PRF-24236. FIGURE 1. Switches. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,

3、-MIL-PRF-24236/13J 2 FIGURE 1. Switches - Continued. 22 AWG WIRE-LEAD TERMINAL IN ACCORDANCE WITH SAE-AS22759/11 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-24236/13J 3 Inches mm .003 .08 .007 .18 .008 .20 .021 .53 .070 1.78 .080 2.03 .13

4、0 3.30 .213 5.41 .263 6.68 .575 14.60 12.000 304.80 NOTES: 1. Dimensions are in inches. 2. Metric equivalents are given for general information only. 3. Unless otherwise specified, tolerance is .015 (0.38 mm). FIGURE 1. Switches - Continued. Provided by IHSNot for ResaleNo reproduction or networking

5、 permitted without license from IHS-,-,-MIL-PRF-24236/13J 4 REQUIREMENTS: Dimensions and configuration: See figure 1 and table I. High temperature setting: -30F to +365F (see tables II and III). High temperature setting tolerance: 8F. Low temperature setting (differential): 30F 8F below applicable h

6、igh temperature setting. Class: 4, except vibration 10 to 2,000 Hz, 30 G. Notes: 1. Devices with open on temperature rise should not be subjected to vibration while at temperatures of 75F or more below the opening temperature. 2. Devices with close on temperature rise should not be subjected to vibr

7、ation while at temperatures of 75F or more above the opening temperature. Mounting: See figure 1. Weight: 0.3 gram maximum. Dielectric withstanding voltage: Sea level - 500 V ac for 5 seconds or 400 V ac for 1 minute. 70,000 feet - 250 V ac. Electrical ratings: 1.0 ampere resistive at 115 V ac, 60 H

8、z. 1.0 ampere resistive at 28 V dc. 10 milliamperes resistive at 30 millivolts dc or 30 millivolts peak ac (when specified, see PIN information). Endurance: 10,000 cycles. Salt spray (corrosion): In accordance with MIL-PRF-24236, except switches shall be subjected to and pass the seal test after und

9、ergoing salt spray. NOTE: Destructive corrosion shall be construed as any type of corrosion which in any way interferes with the mechanical or electrical performance of the switch, or corrosion which causes seal failure. Marking: Identification marking shall be placed on the unit package label or ta

10、g. Low level: When specified, see PIN information. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-24236/13J 5 Part or Identifying Number (PIN): PIN shall be assigned as illustrated below: M24236/13- A H C L | | | | | . | | | | | | | | | | |

11、| | | | Specification Configuration and Course Fine Add the sheet number contact action temperature temperature letter “L“ (see table I) setting to setting to when low level within 20F within 5F is required (see table II) (see table III) PIN M24236/13-AHCL identifies a thermostatic switch that opens

12、 on increasing temperature at 120F 8F with a temperature differential of 30F 8F with low level capabilities. Qualification: Group submission: See table IV. Substitutability: See table V. TABLE I. Configuration and contact action. Configuration Contact action 1 2 3 Code - - - - - - - - - - - - - - Co

13、de - - - - - - - - - - - - - - Code - - - - - - - - - - - - - - Code - - - - - - - - - - - - - - A B A B C D C D E F E F Open on increasing temperature Close on increasing temperature Close on decreasing temperature Open on decreasing temperature TABLE II. Course high temperature setting to within 2

14、0F. Code Temperature Code Temperature A - - - - - - - - - - B - - - - - - - - - - C - - - - - - - - - D - - - - - - - - - E - - - - - - - - - - F - - - - - - - - - - G- - - - - - - - - - H- - - - - - - - - - J - - - - - - - - - - K - - - - - - - - - - L - - - - - - - - - - (F) -30 -10 +10 +30 +50 +7

15、0 +90 +110 +130 +150 +170 M- - - - - - - - - - N- - - - - - - - - - P - - - - - - - - - - Q - - - - - - - - - R- - - - - - - - - - S - - - - - - - - - - T - - - - - - - - - - U- - - - - - - - - - V - - - - - - - - - - W - - - - - - - - - (F) +190 +210 +230 +250 +270 +290 +310 +330 +350 +365 Provided

16、 by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-24236/13J 6 TABLE III. Fine high temperature setting to within 5F. Code Temperature A - - - - - - - - - B - - - - - - - - - C - - - - - - - - - D - - - - - - - - - (F) 0 +5 +10 +15 TABLE IV. Extent of q

17、ualification. Configuration Number of samples required Tests Qualifies 1 All in accordance with qualification table of MIL-PRF-24236 Complete in accordance with qualification inspection of MIL-PRF-24236 All 2 3 2 each 2 each Visual and mechanical examination, terminal strength, shock and vibration T

18、ABLE V. Supersession data. Superseded Military PIN M24236/13- Superseding Military PIN M24236/13- Superseded Military PIN M24236/13- Superseding Military PIN M24236/13- 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 BLB BLD BMB BMC BNC BPA BPC BQB BRB ABC ABD ACA ACB ACC ACD AD

19、A ADB ADC ADD AEA AEB AEC AED 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 AFA AFB AFC AFD AGA AGB AGC AGD AHA AHB AHC AHD AJA AJB AJC AJD AKA AKB AKC AKD ALA ALB ALC Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-242

20、36/13J 7 TABLE V. Supersession data - Continued. Superseded Military PIN M24236/13- Superseding Military PIN M24236/13- Superseded Military PIN M24236/13- Superseding Military PIN M24236/13- 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 ALD AMA

21、 AMB AMC AMD ANA ANB ANC AND APA APB APC APD AQA AQB AQC AQD ARA ARB ARC ARD ASA ASB ASC ASD ATA ATB ATC ATD AUA AUB AUC AUD AVA 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 BBC BBD BCA BCB BCC BCD BDA BDB BDC BDD BEA BEB BEC BE

22、D BFA BFB BFC BFD BGA BGB BGC BGD BHA BHB BHC BHD BJA BJB BJC BJD BKA BKB BKC BKD 115 116 117 118 119 120 121 122 123 124 125 126 127 128 BLA BLC BMA BMD BNA BNB BND BPB BPD BQA BQC BQD BRA BRC 129 130 131 132 133 134 135 136 137 138 139 140 141 142 BRD BSA BSB BSC BSD BTA BTB BTC BTD BUA BUB BUC BU

23、D BVA Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-24236/13J 8 Referenced documents: MIL-PRF-24236 SAE-AS22759/11 The margins of this specification are marked with vertical lines to indicate where modifications from this revision were made

24、. This was done as a convenience only and the Government assumes no liability whatsoever for any inaccuracies in these notations. Bidders and contractors are cautioned to evaluate the requirements of this document based on the entire content irrespective of the marginal notations. Custodians: Prepar

25、ing activity: Army - CR DLA - CC Navy - EC Air Force - 85 (Project 5930-2012-039) DLA - CC Review activities: Army - AR, AT, AV, MI Navy - AS, MC, OS Air Force 99 NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.dla.mil. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-