书签分享收藏举报版权申诉 / 8

立即下载加入VIP,交流精品资源

当前位置：首页 > 标准规范 > 国际标准 > 其他 > DLA MIL-PRF-39003 2 J-2012 CAPACITOR FIXED ELECTROLYTIC (SOLID ELECTROLYTE) TANTALUM (POLARIZED SINTERED SLUG) ESTABLISHED RELIABILITY STYLE CSR09.pdf

DLA MIL-PRF-39003 2 J-2012 CAPACITOR FIXED ELECTROLYTIC (SOLID ELECTROLYTE) TANTALUM (POLARIZED SINTERED SLUG) ESTABLISHED RELIABILITY STYLE CSR09.pdf

上传人：hopesteam270

文档编号：692848

上传时间：2018-12-30

格式：PDF

页数：8

大小：76.43KB

《DLA MIL-PRF-39003 2 J-2012 CAPACITOR FIXED ELECTROLYTIC (SOLID ELECTROLYTE) TANTALUM (POLARIZED SINTERED SLUG) ESTABLISHED RELIABILITY STYLE CSR09.pdf》由会员分享，可在线阅读，更多相关《DLA MIL-PRF-39003 2 J-2012 CAPACITOR FIXED ELECTROLYTIC (SOLID ELECTROLYTE) TANTALUM (POLARIZED SINTERED SLUG) ESTABLISHED RELIABILITY STYLE CSR09.pdf（8页珍藏版）》请在麦多课文档分享上搜索。

1、AMSC N/A FSC 5910 INCH-POUND MIL-PRF-39003/2J 23 August 2012 SUPERSEDING MIL-PRF-39003/2H 3 December 2009 PERFORMANCE SPECIFICATION SHEET CAPACITOR, FIXED, ELECTROLYTIC (SOLID ELECTROLYTE), TANTALUM (POLARIZED, SINTERED SLUG), ESTABLISHED RELIABILITY, STYLE CSR09 This specification is approved for u

2、se by all Departments and Agencies of the Department of Defense. The requirements for acquiring the product described herein shall consist of this specification sheet and MIL-PRF-39003. FIGURE 1. Dimensions and configuration. FAILURE RATE LEVELS “M”, “P”, AND “R” ARE INACTIVE FOR NEW DESIGN AFTER 2

3、FEBRUARY 1984. FAILURE RATE LEVEL “S” IS INACTIVE FOR NEW DESIGN AFTER 15 AUGUST 1984. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-39003/2J 2 Case size Dimensions L D Min Nom Max Min Nom Max A1 B1 .235 (5.97) .375 (9.52) .250 (6.35) .390

4、(9.91) .281 (7.14) .405 (10.29) .081 (2.06) .128 (3.25) .090 (2.29) .138 (3.51) .099 (2.51) .148 (3.76) NOTES: 1. Dimensions are in inches. 2. Metric equivalents are in parentheses and are given for general information only. 3. These capacitors are not intended to be mounted by their leads. 4. The c

5、ase insulation shall extend .015 (0.38 mm) minimum beyond each end. However, when a shrink-fitted insulation is used, it shall lap over the ends of the capacitor body. 5. Lead length may be a minimum of 1 inch long for use in tape and reel automatic insertion equipment, when specified. FIGURE 1. Dim

6、ensions and configuration Continued. REQUIREMENTS Requirements: Requirements shall be in accordance with MIL-PRF-39003, and as specified herein. Design and construction: Capacitors shall be of the design, construction, and physical dimensions specified on figure 1. Case type: Tubular, insulated. Mat

7、erial: Metal (alloy unspecified). Type of seal: Hermetic. Leads (gold-plated leads optional; see MIL-PRF-39003 acquisition requirements): Anode lead: Nickel-iron-alloy. Cathode lead: Nickel-iron-alloy or nickel. DC rated voltage: See table I. Above 85C voltage derating is required (see MIL-PRF-39003

8、). DC leakage (DCL): See table I. Capacitance (Cap.) (nom): See table I. Cap. tolerance: 5 or 10 percent, see table I. Dissipation factor (DF): See table I. Operating temperature: -55C to +125C. Failure rate level: See table I. Provided by IHSNot for ResaleNo reproduction or networking permitted wit

9、hout license from IHS-,-,-TABLE I. Style CSR09 characteristics and dash numbers. DC rated volt- age Capaci- tance (nom) CapacI- tance tolerance DC leakage at Dissipation factor at Case size Dash number M39003/02- 1/ Failure rate level for percent per 1000 hours +25C +85C +125C -55C +25C +85C +125C V

10、olts F Percent A A A % % % M (1.0) P (0.1) R (0.01) S (0.001) G (1.0) B (0.1) C (0.01) D (0.001) 6 6 6 6 2.7 2.7 18 18 5 10 5 10 0.6 0.6 1.4 1.4 6 6 21.6 21.6 8 8 36.7 36.7 8 8 8 8 6 6 6 6 6 6 6 6 A1 A1 B1 B1 1001- 0001- 1002- 0002- 1061- 0061- 1062- 0062- 1121- 0121- 1122- 0122- 1181- 0181- 1182- 0

11、182- 5001- 5002-5003- 5004- 2001- 2002- 2003- 2004- 3001- 3002- 3003- 3004- 4001- 4002- 4003- 4004- 10 10 10 10 10 10 10 10 10 10 1.8 1.8 2.2 2.2 10 10 12 12 15 15 5 10 5 10 5 10 5 10 5 10 0.6 0.6 0.6 0.6 2.5 2.5 2.5 2.5 2.5 2.5 6 6 6 6 20 20 24 24 30 30 8 8 8 8 34 34 40.8 40.8 51 51 8 8 8 8 8 8 8 8

12、 8 8 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 A1 A1 A1 A1 B1 B1 B1 B1 B1 B1 1007- 0007- 1008- 0008- 1009- 0009- 1010- 0010- 1011- 0011- 1067- 0067- 1068- 0068- 1069- 0069- 1070- 0070- 1071- 0071- 1127- 0127- 1128- 0128- 1129- 0129- 1130- 0130- 1131- 0131- 1187- 0187- 1188- 0188- 1189- 0189- 1190- 019

13、0- 1191- 0191- 5005- 5006- 5007- 5008- 5009- 5010- 5011- 5012- 5013- 5014- 2005- 2006- 2007- 2008- 2009- 2010- 2011- 2012- 2013- 2014- 3005- 3006- 3007- 3008- 3009- 3010- 3011- 3012- 3013- 3014- 4005- 4006- 4007- 4008- 4009- 4010- 4011- 4012- 4013- 4014- 15 15 15 15 15 15 15 15 1 1 1.2 1.2 1.5 1.5 8

14、.2 8.2 5 10 5 10 5 10 5 10 0.6 0.6 0.6 0.6 0.6 0.6 1.8 1.8 6 6 6 6 6 6 24.6 24.6 8 8 8 8 8 8 42 42 8 8 8 8 8 8 8 8 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 A1 A1 A1 A1 A1 A1 B1 B1 1012- 0012- 1013- 0013- 1014- 0014- 1015- 0015- 1072- 0072- 1073- 0073- 1074- 0074- 1075- 0075- 1132- 0132- 1133- 0133- 1134- 013

15、4- 1135- 0135- 1192- 0192- 1193- 0193- 1194- 0194- 1195- 0195- 5015- 5016- 5017- 5018- 5019- 5020- 5021- 5022- 2015- 2016- 2017- 2018- 2019- 2020- 2021- 2022- 3015- 3016- 3017- 3018- 3019- 3020- 3021- 3022- 4015- 4016- 4017- 4018- 4019- 4020- 4021- 4022- 20 20 20 20 20 20 20 20 20 20 0.56 0.56 0.68

16、0.68 0.82 0.82 1 1 3.3 3.3 5 10 5 10 5 10 5 10 5 10 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 1 1 6 6 6 6 6 6 6 6 13.2 13.2 8 8 8 8 8 8 8 8 22.4 22.4 4 4 4 4 4 4 4 4 4 4 3 3 3 3 3 3 3 3 3 3 4 4 4 4 4 4 4 4 4 4 A1 A1 A1 A1 A1 A1 A1 A1 B1 B1 1016- 0016- 1017- 0017- 1018- 0018- 1019- 0019- 1020- 0020- 1076- 0076

17、- 1077- 0077- 1078- 0078- 1079- 0079- 1080- 0080- 1136- 0136- 1137- 0137- 1138- 0138- 1139- 0139- 1140- 0140- 1196- 0196- 1197- 0197- 1198- 0198- 1199- 0199- 1200- 0200- 5023- 5024- 5025- 5026- 5027- 5028- 5029- 5030- 5031- 5032- 2023- 2024- 2025- 2026- 2027- 2028- 2029- 2030- 2031- 2032- 3023- 3024

18、- 3025- 3026- 3027- 3028- 3029- 3030- 3031- 3032- 4023- 4024- 4025- 4026- 4027- 4028- 4029- 4030- 4031- 4032- See footnote at end of table. MIL-PRF-39003/2J3Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-TABLE I. Style CSR09 characteristics and dash

19、 numbers Continued DC rated volt- age Capaci- tance (nom) Capacitance tolerance DC leakage at Dissipation factor at Case size Dash number M39003/02- 1/ Failure rate level for percent per 1000 hours +25C +85C +125C -55C +25C +85C +125C Volts F Percent A A A % % % M (1.0) P (0.1) R (0.01) S (0.001) G

20、(1.0) B (0.1) C (0.01) D (0.001) 20 20 20 20 20 20 20 20 3.9 3.9 4.7 4.7 5.6 5.6 6.8 6.8 5 10 5 10 5 10 5 10 2 2 2 2 2 2 2 2 15.6 15.6 18.8 18.8 22.4 22.4 27.2 27.2 26.5 26.5 32 32 38.1 38.1 46.2 46.2 4 4 4 4 4 4 4 4 3 3 3 3 3 3 3 3 4 4 4 4 4 4 4 4 B1 B1 B1 B1 B1 B1 B1 B1 1021- 0021- 1022- 0022- 102

21、3- 0023- 1024- 0024- 1081- 0081- 1082- 0082- 1083- 0083- 1084- 0084- 1141- 0141- 1142- 0142- 1143- 0143- 1144- 0144- 1201- 0201- 1202- 0202- 1203- 0203- 1204- 0204- 5033- 5034- 5035- 5036- 5037- 5038- 5039- 5040- 2033- 2034- 2035- 2036- 2037- 2038- 2039- 2040- 3033- 3034- 3035- 3036- 3037- 3038- 303

22、9- 3040- 4033- 4034- 4035- 4036- 4037- 4038- 4039- 4040- 35 35 35 35 35 35 35 35 35 35 0.33 0.33 0.39 0.39 0.47 0.47 2.2 2.2 2.7 2.7 5 10 5 10 5 10 5 10 5 10 0.6 0.6 0.6 0.6 0.6 0.6 1.4 1.4 1.4 1.4 6 6 6 6 6 6 15.4 15.4 18.9 18.9 8 8 8 8 8 8 26.2 26.2 32.1 32.1 4 4 4 4 4 4 4 4 4 4 3 3 3 3 3 3 3 3 3

23、3 4 4 4 4 4 4 4 4 4 4 A1 A1 A1 A1 A1 A1 B1 B1 B1 B1 1025- 0025- 1026- 0026- 1027- 0027- 1028- 0028- 1029- 0029- 1085- 0085- 1086- 0086- 1087- 0087- 1088- 0088- 1089- 0089- 1145- 0145- 1146- 0146- 1147- 0147- 1148- 0148- 1149- 0149- 1205- 0205- 1206- 0206- 1207- 0207- 1208- 0208- 1209- 0209- 5041- 50

24、42- 5043- 5044- 5045- 5046- 5047- 5048- 5049- 5050- 2041- 2042- 2043- 2044- 2045- 2046- 2047- 2048- 2049- 2050- 3041- 3042- 3043- 3044- 3045- 3046- 3047- 3048- 3049- 3050- 4041- 4042- 4043- 4044- 4045- 4046- 4047- 4048- 4049- 4050- 50 50 50 50 50 50 50 50 0.22 0.22 0.27 0.27 1.5 1.5 1.8 1.8 5 10 5 1

25、0 5 10 5 10 0.6 0.6 0.6 0.6 1.4 1.4 1.4 1.4 6 6 6 6 15 15 18 18 8 8 8 8 25.5 25.5 30.6 30.6 4 4 4 4 4 4 4 4 3 3 3 3 3 3 3 3 4 4 4 4 4 4 4 4 A1 A1 A1 A1 B1 B1 B1 B1 1030- 0030- 1031- 0031- 1032- 0032- 1033- 0033- 1090- 0090- 1091- 0091- 1092- 0092- 1093- 0093- 1150- 0150- 1151- 0151- 1152- 0152- 1153

26、- 0153- 1210- 0210- 1211- 0211- 1212- 0212- 1213- 0213- 5051- 5052- 5053- 5054- 5055- 5056- 5057- 5058- 2051- 2052- 2053- 2054- 2055- 2056- 2057- 2058- 3051- 3052- 3053- 3054- 3055- 3056- 3057- 3058- 4051- 4052- 4053- 4054- 4055- 4056- 4057- 4058- 75 75 75 75 75 75 0.047 0.047 0.056 0.056 0.068 0.06

27、8 5 10 5 10 5 10 0.6 0.6 0.6 0.6 0.6 0.6 6 6 6 6 6 6 8 8 8 8 8 8 4 4 4 4 4 4 3 3 3 3 3 3 4 4 4 4 4 4 A1 A1 A1 A1 A1 A1 1034- 0034- 1035- 0035- 1036- 0036- 1094- 0094- 1095- 0095- 1096- 0096- 1154- 0154- 1155- 0155- 1156- 0156- 1214- 0214- 1215- 0215- 1216- 0216- 5059- 5060- 5061- 5062- 5063- 5064- 2

28、059- 2060- 2061- 2062- 2063- 2064- 3059- 3060- 3061- 3062- 3063- 3064- 4059- 4060- 4061- 4062- 4063- 4064- See footnote at end of table. MIL-PRF-39003/2J4Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-TABLE I. Style CSR09 characteristics and dash nu

29、mbers Continued DC rated volt- age Capaci- tance (nom) Capacitance tolerance DC leakage at Dissipation factor at Case size Dash number M39003/02- 1/ Failure rate level for percent per 1000 hours +25C +85C +125C -55C +25C +85C +125C Volts F Percent A A A % % % M (1.0) P (0.1) R (0.01) S (0.001) G (1.

30、0) B (0.1) C (0.01) D (0.001) 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 75 0.082 0.082 0.1 0.1 0.12 0.12 0.15 0.15 0.18 0.18 0.22 0.22 0.27 0.27 0.33 0.33 0.39 0.39 0.47 0.47 0.56 0.56 0.68 0.68 0.82 0.82 1 1 1.2 1.2 5 10 5 10 5 10 5 10 5 10 5 10 5 10 5 1

31、0 5 10 5 10 5 10 5 10 5 10 5 10 5 10 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.6 0.7 0.7 0.9 0.9 0.9 0.9 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 7 7 8.4 8.4 10.2 10.2 12.3 12.3 15 15 18 18 8 8 8 8 8 8 8 8 8 8 8 8 8 8 8.4 8.4 9.9 9.9 12 12 14.3 14.3 17.

32、3 17.3 20.9 20.9 25.5 25.5 30.6 30.6 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 A1 A1 A1 A1 A1 A1 A1 A1 A1 A1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1 B1

33、 B1 B1 1037- 0037- 1038- 0038- 1039- 0039- 1040- 0040- 1041- 0041- 1042- 0042- 1043- 0043- 1044- 0044- 1045- 0045- 1046- 0046- 1047- 0047- 1048- 0048- 1049- 0049- 1050- 0050- 1051- 0051- 1097- 0097- 1098- 0098- 1099- 0099- 1100- 0100- 1101- 0101- 1102- 0102- 1103- 0103- 1104- 0104- 1105- 0105- 1106-

34、 0106- 1107- 0107- 1108- 0108- 1109- 0109- 1110- 0110- 1111- 0111- 1157- 0157- 1158- 0158- 1159- 0159- 1160- 0160- 1161- 0161- 1162- 0162- 1163- 0163- 1164- 0164- 1165- 0165- 1166- 0166- 1167- 0167- 1168- 0168- 1169- 0169- 1170- 0170- 1171- 0171- 1217- 0217- 1218- 0218- 1219- 0219- 1220- 0220- 1221-

35、 0221- 1222- 0222- 1223- 0223- 1224- 0224- 1225- 0225- 1226- 0226- 1227- 0227- 1228- 0228- 1229- 0229- 1230- 0230- 1231- 0231- 5065- 5066- 5067- 5068- 5069- 5070- 5071- 5072- 5073- 5074- 5075- 5076- 5077- 5078- 5079- 5080- 5081- 5082- 5083- 5084- 5085- 5086- 5087- 5088- 5089- 5090- 5091- 5092- 5093-

36、 5094- 2065- 2066- 2067- 2068- 2069- 2070- 2071- 2072- 2073- 2074- 2075- 2076- 2077- 2078- 2079- 2080- 2081- 2082- 2083- 2084- 2085- 2086- 2087- 2088- 2089- 2090- 2091- 2092- 2093- 2094- 3065- 3066- 3067- 3068- 3069- 3070- 3071- 3072- 3073- 3074- 3075- 3076- 3077- 3078- 3079- 3080- 3081- 3082- 3083-

37、 3084- 3085- 3086- 3087- 3088- 3089- 3090- 3091- 3092- 3093- 3094- 4065- 4066- 4067- 4068- 4069- 4070- 4071- 4072- 4073- 4074- 4075- 4076- 4077- 4078- 4079- 4080- 4081- 4082- 4083- 4084- 4085- 4086- 4087- 4088- 4089- 4090- 4091- 4092- 4093- 4094- 1/ Dash number shall include a letter that indicates

38、user preference for surge current/high temperature solder or the dash will be deleted. MIL-PRF-39003/2J5Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-39003/2J 6 REQUIREMENTS Continued: Stability at low and high temperatures: In accordance w

39、ith MIL-PRF-39003. Step 1 (+25C): DCL: See table I. Capacitance: Within tolerance of table I value. DF: See table I. Step 2 (-55C): Capacitance: Shall not change more than 8 percent of step 1 measured value. DF: See table I. Step 3 (+25C): DCL: See table I. Capacitance: Shall not change more than 2

40、percent of step 1 measured value. DF: See table I. Step 4 (+85C): DCL: See table I. Capacitance: Shall not change more than 8 percent of step 1 measured value (6, 10, and 15 volt units). Capacitance: Shall not change more than 6 percent of step 1 measured value (20 volts and higher). DF: See table I

41、. Step 5 (+125C): DCL: See table I. Capacitance: Shall not change more than 12 percent of step 1 measured value. DF: See table I. Step 6 (+25C): DCL: See table I. Capacitance: Shall not change more than 2 percent of step 1 measured value. DF: See table I. Provided by IHSNot for ResaleNo reproduction

42、 or networking permitted without license from IHS-,-,-MIL-PRF-39003/2J 7 Surge voltage: In accordance with MIL-PRF-39003. DCL: See table I. Capacitance: Shall not change more than 2 percent from initial measured value. DF: See table I. Life: Method 108 of MIL-STD-202. 240, 1,000, and 2,000 hours. At

43、 25C (as applicable). DCL: See table I. Capacitance: Not greater than 5 percent of initial measured value. DF: See table I. At 85C: DCL: See table I. At 125C: DCL: See table I. 4,000, 6,000, 8,000, and 10,000 hours (exponential only): At +25C (as applicable): DCL: 200 percent of initial limit. Capac

44、itance: Not greater than 10 percent of initial measured value. DF: See table I. At +85C: DCL: 200 percent of initial limit. At +125C: DCL: 200 percent of initial limit. Marking: In accordance with MIL-PRF-39003. Part or Identifying Number (PIN): M39003/02-(dash number from table I). Substitutability

45、 data: Substitutability for failure rate levels and capacitance tolerances shall be in accordance with MIL-PRF-39003. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-39003/2J 8 Reference documents. In addition to MIL-PRF-39003, this specifica

46、tion sheet references the following documents. MIL-STD-202 Changes from previous issue. The margins of this specification are marked with vertical lines to indicate where modifications from this revision were made. This was done as a convenience only and the Government assumes no liability whatsoeve

47、r for any inaccuracies in these notations. Bidders and contractors are cautioned to evaluate the requirements of this document based on the entire content irrespective of the marginal notations. Custodians: Preparing activity Army - CR DLA - CC Navy - EC Air Force - 85 (Project 5910-2012-010) DLA -

48、CC Review activities Navy - AS, MC, OS, SH Air Force - 19, 99 NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.dla.mil . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-

下载提示：本站仅提供存储空间/不修改/不编辑

1.请仔细阅读文档，确保文档完整性，对于不预览、不比对内容而直接下载带来的问题本站不予受理。
2.下载的文档，不会出现我们的网址水印。
3、该文档所得收入（下载+内容+预览）归上传者、原创作者；如果您是本文档原作者，请点此认领！既往收益都归您。

同意并开始全文预览

文档包含非法信息？点此举报后获取现金奖励！

文档加载中……请稍候！
如果长时间未打开，您也可以点击刷新试试。

下载文档到电脑，查找使用更方便

10000 积分 0人已下载

下载	加入VIP,交流精品资源

版权申诉 word格式文档无特别注明外均可编辑修改；预览文档经过压缩，下载后原文更清晰！ 立即下载

配套讲稿：: 如PPT文件的首页显示word图标，表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
特殊限制：: 部分文档作品中含有的国旗、国徽等图片，仅作为作品整体效果示例展示，禁止商用。设计者仅对作品中独创性部分享有著作权。
关键词：: DLAMILPRF390032J2012CAPACITORFIXEDELECTROLYTICSOLIDELECTROLYTETANTALUMPOLARIZEDSINTEREDSLUGESTABLISHEDRELIABILITYSTYLECSR09PDF

麦多课文档分享所有资源均是用户自行上传分享，仅供网友学习交流，未经上传用户书面授权，请勿作他用。

关于本文

本文标题：DLA MIL-PRF-39003 2 J-2012 CAPACITOR FIXED ELECTROLYTIC (SOLID ELECTROLYTE) TANTALUM (POLARIZED SINTERED SLUG) ESTABLISHED RELIABILITY STYLE CSR09.pdf
链接地址：http://www.mydoc123.com/p-692848.html