AIR FORCE MIL-T-83385 A-1984 TROUSERS FLYERS' EXTREME COLD WEATHER CWU-18 P《CWU- 18 P型长裤极端寒冷天气飞行员用》.pdf

《AIR FORCE MIL-T-83385 A-1984 TROUSERS FLYERS' EXTREME COLD WEATHER CWU-18 P《CWU- 18 P型长裤极端寒冷天气飞行员用》.pdf》由会员分享，可在线阅读，更多相关《AIR FORCE MIL-T-83385 A-1984 TROUSERS FLYERS' EXTREME COLD WEATHER CWU-18 P《CWU- 18 P型长裤极端寒冷天气飞行员用》.pdf（48页珍藏版）》请在麦多课文档分享上搜索。

1、051 - - MIL-T-83385A 89 9999906 090BB8 O MIL-T-8 33 85A *Beneficial comnents (recomnendations additions, deletions) and any perti- Tient data which may be of use in improving this document should be addressed to: the Engineering Division, San Antonio Air Logistics Center, Kelly AFB, TX 78241 by usin

2、g the self-addressed Standardization Document Improvement Proposal (DD Form 1426) appearing at the end of this document or by letter. d T-T-881 Twine, Cotton, Seine V-B-87 1 Button, Sewing Hole, And Button, Staple V-F-106 Fastener, Slide, Interlocking DDDL-20 Label; For Clothing, Equipage, And Tenta

3、ge, PPP-B- 636 Boxes, Shipping, Fiberboard PPP- T-45 Tape, Gummed, Paper, Reinforced And Plain, For (Piast ic) (General Use) Sealing And Securing MIL ITA RY MIL-B-543 Buckles, Tongueless And Web Strap MIL-(2-3735 Cuffs, Knit, Wrist And Ankle, And Cloth,Knitted 13 March 84 SUPERSE DING MIL-T-8 3385 1

4、 September 1972 MILITARY SPECIFICA TION TROUSERS, FLYERS, EXTREME COLD EATHER, CWV-lS/P This specification is approved for use by the Department of the Air Force, and is available for use by all Depart- ments and Agencies of the Department of Defense. .= 1. SCOPE 1.1 Scope. This specification covers

5、 one type of flight trousers designated CWU-iS/P and furnished in the following sizes as specified (see 6.2) : 28 32 36 40 44 30 34 38 42 46. 2, APPLICABLE DOCUMENTS *2.1 Government documents. *2.1.1 Specifications and standards, Unless otherwise specified (see 6.21, the following specifications and

6、 standards of the issue listed in that issue of the Department of Defense Index of Specifications and Standards (DoDISS) specified in the solicitation, form a part of this specification to the extent specified herein. SPECIFICATIONS FEDERAL Provided by IHSNot for ResaleNo reproduction or networking

7、permitted without license from IHS-,-,-_- - _ _I_ MIL-T-83385A BY m 9999906 0408809 2 m MIL-T-8 33 85A M IL ITA RY MIL-W-4088 MIL-C-5040 MIL- S-67 9 O MIL-F- 10884 MIL-G-16491 *MIL-T-44100 MIL-B-8 1813 MIL-C-8 1814 STANDARDS Webb ing , Text i le, Woven Ny lon Cord, Nylon Suspenders, Trousers (Suspen

8、ders, Flying Suit) Fasteners, Snap Gromet, Met all ic Thread, Para-Aramid, Spun, Immediate Modulus Batting, Aramid Or Novoloid Fiber, Quilted Cloth, Twill, Aromatic Polyamide, High Temp er at Ure Res is tant FEDERAL FED-STD-191 Textile Test Methods FED-STD-75 1 Stitches, Seams, And Stitchings MILITA

9、RY MIL - ST D- 1 O 5 M IL-STD- 12 9 Marking For Shipment And Storage MS27980 Clamp Type) Sampling Procedures And Tables For Inspection By Attributes Fasteners, Snap, Style 2 (Regular Wire Spring * (Copies of specifications and standards required by manufacturers in connection with specific acquisiti

10、on functions should be obtained from the contracting activity or as directed by the contracting officer.) *2.1.2 Other Government documents, drawings, and publications. The following other Government documents form a part of this specification to the extent specified herein. D RA WINGS Air Force 701

11、09 70110 70111 70112 70113 70114 70115 70116 70117 Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Pat

12、terns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Patterns, Trousers, Flying, Extreme Cold Weather, CWU-iS/P Miscellaneous, All Sizes Weather, CWU-l8/P, Size 28 Weather, CWU-l8/P, Size 30 Weather, CWU-lS/P, Size 32 Weather, CWU-lS/P, Sike 34 Weather, CWU-l8/P, Size 36 We

13、ather, CWU-i8/P, Size 38 Weather, GWU-l8/P, Size 40 Weather, CWU-lS/P, Size 42 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-70118 70119 MIL-T-83385A BLJ 777970b 0408810 7 MIL-T-83385A Patterns, Trousers, Plying, Extreme Cold Patterns, Trousers,

14、Plying, Extreme Cod1 Weather, CiW-lS/P, Size 44 Weather, CrW-lS/P, Size 46 2.2 Other publications. specification to the extent specified herein. The following document(s) form a part of this “he issues of the documents which are indicated as DoD adopted shall be the issue listed in the current DoDIS

15、S and the supplement thereto, if applicable. AESERICAN SOCIETY FOR TECTING AND MATERIALS (ASTM) * ASDl D 3951 - Standard Practice for Commercial Packaging (Application for copies should be addressed to the American Society for Testing and Materials, 1916 Race Street, Philadelphia, PA 19103.) Departm

16、ent of Defense (DOD) Standard Shades for Buttons 1966. (Copies of this publication may be obtained from The Color Association of the United States, Inc., 200 tfadison Avenue, New York, New York 10016.) (Technical society and technical association specifications and standards are generally available

17、for reference from libraries and are also distributed among technical groups and using federal agencies. ) *2.3 Order of precedence. In the event of a conflict between the text of this specification and the references cited herein, the text of this specification shall take precedence. 3. REQUIRBEIEN

18、TS 3.1 Materials. 3.1.1 Basic fabric. The material for the outer shell; the protective flies of the leg and the side pass-through openings; the facing of the pockets, the leg openings, and the side pass-through openings; the lining of the fly and the pocket flaps; the hanger; the adjustment straps;

19、the knee and the seat reinforcement patches; the belt loops; the pocketing including the flaps and the welts; and the reinforcements of the snap fasteners shall conform to MIL-C-81814 and shall be USAF color shade No, 1565 (see 6.3). 3.1.2 Quilted lining. Size T-35 o MIL-T-44100 except that the colo

20、r shall be sage green, conforming to USAF color shade No. 1565 (see 6.3). The material for the quilted lining shall conform to gt3.1.3 Thread. The thread for all sewing operations shall conform to size T-35 of MIL-T-44100, 3.1.4 Anklets. The material for the anklets shall conform to type I, class 3

21、of MIL-C-3735. The anklets shall be USAF color shade No. 1525 (see 6.3). 3.1.5 Buttons. The buttons shall confrom to type II, class D, style 4, size 27 lines of V-B-871. The color of the buttons shall be DOD Button Shade Green AD, Cable No. 62012 (see DoD Standard Shades for Buttons 1966). 3 Provide

22、d by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-T-83385A 3.1.6 Snap fasteners. of MIL-F-10884 and MS27980-1B (button), MS27908-6B (socket), MS27908-7B (stud) , and MS27980-8B (eyelet). The snap fasteners shall conform to style 2, finish 2 3.1.7 Slider.

23、1 or 3, size 1 inch of MIL-B-543. The slider (buckle) shall conform to type II, style 4, class 3.1.8 Slide fasteners. of V-F-106 and to table I herein. The chain and any other metal components except the latch and the spring of the automatic lock shall be brass with a black chemical finish. The slid

24、e fastener tapes shall be high temperature resistant polyamide and shall approximately match the color of the basic fabric. The slide fastener shall be heat set to obtain dimensional stability so that the tapes will not shrink more than 2 percent in the warp direction. The slide fastener for the fro

25、nt opening shall have a thong made of the basic fabric. The slide fasteners shall conform to the requirements 3.1.9 Grommet. class 3 size No. O of MIL-G-16491. The grommet for the knife pocket shall conform to type I, 3.1.10 Cord beading. covers shall conform to type I, size (commerical number) 18 o

26、f T-T-881. 3.1.11 Cord for lanyard. pocket shall be natural color and shall conform to type A of MIL-C-5040. The cord shall be 60 inches (plus or minus 1 inch) long. The cord beading in the edges of the slide fastener The cord for the lanyard attached to the knife 3.1.12 Binding. bias-cut, 1-1/8 inc

27、hes wide from the basic fabric. The binding for the edges of the knife pocket shall be 3.1.13 Reinforcement on knife pocket. The webbing for the reinforcement on the knife pocket shall conform to type XII of MIL-W-4088 and may be natural white. 3.1.14 Suspenders. except that the colorfastness to wet

28、 crocking of the leather components The suspenders shall conform to type I of MIL-S-6790 shall be fair and the identification marking shall not be required. suspenders shall be sage green approximating the shade of the basic fabric. 3.2 Design. on the seat and the knees, cuffs, (anklets), and a quil

29、ted lining made of high temperature resistant, aromatic polyamide material. with a snap fastener closure shall be located on the left thigh of the trousers. A lanyard shall be attached to the knife pocket. The trousers shall have two hip pockets and two thigh pockets. Each hip pocket and each thigh

30、pocket shall have a flap and snap fastener closure, Each side of the trousers shall have a covered pass-through opening. Each leg opening and each side pass-through opening shall have a slide fastener closure with a protective flap under the slide fastener. Each slide fastener for the leg opening sh

31、all be positioned on the outer side of the leg, running from the terminal to a point below the knee of the trousers. A two-bar, friction- type slider and takeup straps for adjusting the waist shall be positioned on the back of the trousers, The trousers shall have belt loops as well as buttons with

32、suspenders. The The trousers shall have an outer shell, reinforcement patches A knife pocket Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-T-83385A 84 M 979770b OLiOL2 2 MIL-T-8 33 858 TABLE I. Slide fasteners ,pplication iize 28 Pass-through o

33、penings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly openin

34、g Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings Pass-through openings Fly opening Leg openings iize 30 iize 32 ize 34 size 36 Size 38 Size 40 3ize 42 Size 44 Size 46 Speci Type I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I .c

35、atior Sty le 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 7 3 3 J-F- 106 size i/ M M M M Ei M M M M EI Ei l“1 M M M M M M M M M M M M M M El M M M Length in Inches (Pius or minus 1/21 10-1/2 8-3/4 10-1/2 15-1/2 9 15-1/2 10-1/2 9-1/4 15-1/2 10-1/2 15-1/2 10-1/2 9-3/4 10-1/2 9-1/2 15-1/2 10 1

36、5-1/2 10-1/2 10-1/4 15-1/2 10-1/2 10-1/2 15-1/2 10-1/2 10-3/4 15-1/2 10-1/2 11 15-1/2 - 1/ The width of the tape shall be 3/4 inch (plus 3/32 or minus 1/32 inch). 3,3 Construction. The trousers shall be constructed as specified in table 1; havever. the manufacturer is not required to follow the exac

37、t sequence at operations as listed therein. 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-I _ .MIL-T-m 7 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-roc OH 2s m bl al O w O ro al 00 a al c .Pl

38、 bo c .rl a m al P u r al H $ z u *rl r ual CAP Z NIL-T-83385A 8L( 9 777770b Oi.108815 8 1. MIL-T-83385A ei d CJ 4 4 I (0 Fri W n n mu P ? ? v 6, 6, rn rn VJ CA d O m 4 4 4 O m O 0 Om 3 O r al P 1 d a m c 5 m a* mal rbo ua roo) CO ar u roc ou -7 0 a .rl m D al4 e Ud u .rl UEI ew 4 a cbo ma al u GI 4

39、 m 4 in D 8 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-T-83385A 84 777770b 04088Lb T Ei IL-T- 8 3 3 8 5A N m rl N N 4 N I m m cn N I a cn 4 ;“o m U 4 O m t; rl O m P d O m n a c *A U U 4 c; U I H H w i2 u (o al C al .A aNnW u au 0 O IA U m w

40、 al a O u O 8 *A U a *d Ll o (o al Fi c (os UEU umc rl al -A sa 02 .A d mi -A (II Gal5 s .A auc c o mau Li .A H u4-I O 9 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-c O ,FI u m b o? U O c O rl U a rl t; fn a, a O Z MIL-T-83385A 8q 777770b 0408817

41、 L - MIL-T-8 3385A n n P o o I I a, a, cn rn cn cn W w 4 4 4 4 O O O O o o W W a J a, c u ?u o0 ao u c.rl a, m rngo muu c a, a, 5 O k 3 ?u ril .iI LI . I rnm m e 10 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-T-83385A 84 7939706 0408818 3 M I

42、L-T-8 3 3 8 5A n a al 1 C .rl U E O V W H H w A F9 3 .rl u m I4 al a O u4 O c O .rl U a .rl LI u v) al Fi O z e4 4 (I 4 4 I m rn rn e4 I m rn rn n n n W W cv m n nw 4 hl cv I 1 I I m v al al rn m rn rn rn I4 rn cn n P e4 I w rn 1-7 W 4 O *i 4 O m I ala cal uu u a1 CP ma. w .i4 .d al 5 U m al 1 M C O

43、 U a al a m I a C a .d a m c 3 c bo 5 O k 2 8 U .rl 5 m U al z c al 5 u 5W ULr al G MO -u m 5 .rl 3 a 8 I4 O W h al a al P 2 E n M r- W a G m n n w. .u o .rl zc Y c oal al a .rl v) C .rl al 5 e O u 4 al al 3 5 O U v) h J fi I4* OM ue al2 u: .rl uu am mw alo 1 Oh U al e,3 5c“ Em rrl mm c nu 7 *-I -3

44、al rl M C -I v) m -5 .rl 3 m al M a al al a .d (0 al 5 3 al m .n al u m d a cc -rl h 1 MU e .rl a uc am Y U“ ow ac .rl arc su uu .rl au dv) O k% 28 -I4 e mu C c -4 u .-I 3 M CO rl u 11 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A a W 5 C C O U .

45、FI U v v)c au cc VH U -4 k UaJ (Ac4 bo C a *rl muc UP E *d F mu aJm (A cca E O rl U m k aJ a 3 O C O 4 ci a ?I k u v) al 3 u o 7. MIL-T-833SA 4 m 7777906 04OL4 5 m M IL- - 8 3 3 8 5A n n m e N N I I aJ ar (A (A (A (A W W n m N I W rn G! W n P hl I W (A ;I W N I U (A IJ n n m n 4 d O O m m 8 d M .-!.

46、-! d .-! d O O O0 O O O m m m.3. m m m al u U m v) m P u W 3W 3s U mc LI .A CI O03 kl Um aJm c uc U o .A u3 Wv) bobo cc .rl .rl uc mai Ua O ai cc u m 00 mu . . I a. N aa lmm .-!- aJ alk d ka na- P 0-i e m aJ oa u aJa a- c al o md .#-I d v: (u c 42 m O (u aJ c .s c ci U m a C m 3 rn U m a aJ % QI bo

47、C d id v) m k aJ O a, aJM 3 d. u: .: u EE boa, mo i-ib k“ aJ 3s ou C u .4 b4 ma a-i u.-! o) abo ac 5 .rl c eu uu .A 4 3u v) $4-1 u0 U 4 3 u0 cok WaJ v)d *d M mc k -4 v) a cm m c CU b *rl 33 w fib Pm -a n n U acbc u Ud aJ0mv) 12 Provided by IHSNot for ResaleNo reproduction or networking permitted wit

48、hout license from IHS-,-,-MIL-T-3385A 4 = 7979706 OL10820 1 MIL-T-83 3 8 5 5A n a al 1 c .rt u c O u W in 0 O *rl u m rd rn j . H H w cl 4 2 NN cl 44 4 N 4 4 I m rn rn 4 I u rn 4 4 I I 0 m rn rn rn 4 I U rn F4 4 4 4 4 O O O O m m m m 4 O m u I+ .rl c n 3.5 n I al o I um -Cm u a-rl -En ai a 4 l-l 13 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-M a O .rl u m a O w O 8 g t; .rl u a .rl m al 13 MIL-T-83385A 84 a 7979706 OYO21 3 m MIL-T-83385A 4 I m rn rn N I a rn I4 N I a rn I4 d I m rn rn 4 O m ri O m 4 O m 4 O m a m ri w al u