ANSI PAC-1-2015 Portable Air Conditioners.pdf

《ANSI PAC-1-2015 Portable Air Conditioners.pdf》由会员分享，可在线阅读，更多相关《ANSI PAC-1-2015 Portable Air Conditioners.pdf（25页珍藏版）》请在麦多课文档分享上搜索。

1、Portable Air Conditioners ANSI/AHAM PAC-1-2015 p i ANSI/AHAM PAC12015 PREFACE The Association of Home Appliance Manufacturers develops standards in accordance with AHAMs “Policy and Procedures Governing Technical Standards“ which states: “AHAM Standards shall be in the best interest, mutually, of co

2、nsumers who use appliances, the industries which provide and service appliances, and other interested parties. They shall relate to actual use conditions, be technically and scientifically sound.“ Use or observance of AHAM standards is voluntary. AHAM standards are presented to the American National

3、 Standards Institute (ANSI) for recognition as American National Standards. This standard was so recognized on June 19, 2015 and bears the American National Standard designation ANSI/AHAM PAC12015. This standard contains test procedures that may be applied to any brand or model of portable air condi

4、tioner. Results of tests in accordance with this standard may be publicly stated. This standard is equivalent to the Canadian Standards Association (CSA) standard, CSA C370 Cooling Performance Standard for Portable Air Conditioners. Technical development of this standard was jointly completed by AHA

5、M and CSA, and the standard is harmonized with CSA C370 to the greatest extent possible. With regard to safety, AHAM recommends that all appliance products both major and portable manufactured or marketed in the United States be submitted to an appropriate independent laboratory such as Underwriters

6、 Laboratories, Inc., or the American Gas Association Laboratories, Inc., for inspection and listing in conformance with the safety standards and procedures followed by such laboratories. The relevant standards for portable air conditioners are UL 484, Standard for Safety, Room Air Conditioners, and

7、this standard, ANSI/AHAM PAC1, Portable Air Conditioners. AHAM welcomes comments and suggestions regarding this standard. Any standard may be reviewed and improved as needed. All standards must be updated or reconfirmed at least every five years. Any interested party, at any time, may request a chan

8、ge in an AHAM standard. Such request should be addressed to AHAMs President, and should be accompanied by a statement of reason for the request and a suggested alternate proposal. When metric units are not specified, conversion from customary units should be done in accordance with the American Soci

9、ety of Heating, Refrigerating and AirConditioning Engineers, Inc. (ASHRAE) Metric Practice Guide, and the AHAM SI Metric Practice Guide for the Appliance Industry. Copyright 2015 by the Association of Home Appliance Manufacturers (AHAM) All rights reserved. The hard copy print version of this docume

10、nt shall be for individual use only. The electronic file version of this document shall be for storage on one computer for purposes of viewing and/or printing one copy for individual use only. This document shall not be reproduced in whole or in part by any means, and shall not be transmitted electr

11、onically or otherwise to a third person without the prior written permission of AHAM. ANSI/AHAM PAC1PURP1.SCOP2.2.1 2.2 2.3 2.4 REFE3.DEFI4.4.1 4.2 4.3 4.4 4.5 4.6 4.7 4.8 4.9 4.10 4.11 4.12 4.13 4.14 4.15 4.16 GEN5.5.1 5.2 RATI6.6.1 6.2 6.3 6.4 TEST7.7.1 7.2 7.3 MAR8.TABLE 1 MCOOLING CTABLE 2 T2015

12、 OSE .E This StandarThis StandarTerminologyUnits of MeaRENCE PUBLICNITIONS Application RCondenser Cooling coil .Portable Air Dual Duct CoSingle Duct CSpot CoolingWater CooleDual Duct EnSingle Duct ESpot CoolingWater CooleStandard RatStandard RatStandby PowUnit .ERAL REQUIREFor the U.S., For Canada,

13、NGS REQUIREGeneral .Ratings Application RPublished RaS .General .Setup and inStandard RatKING .ULTIPLES FOAPACITY, WAEST CONFIGU.d applies to td does not apsurement ATIONS .ating .Conditioner .oling Capacitooling CapacCapacity .d Condenser ergy Efficiencnergy EfficieEnergy Efficir Condenser ing .ing

14、 Conditioner .MENTS .applicable reapplicable reMENTS .atings .tings .stallation ing Test Con.R REPORTINGTER COOLED CRATIONS .he cooling peply to: .y ity .Capacity y Ratio (DD ncy Ratio (SDency Ratio (SEnergy Efficie.quirements aquirements a.ditions .DUAL DUCT CONDENSER C.CONTENT.rformance o.EER) EER

15、) .C EER) ncy Ratio (W.re found in: .re found in: .OOLING CAPAAPACITY AND.S .f portable air.CC EER) .CITY, SINGLEPOWER INPU.conditioners.DUCT COOLINT RATINGS .G CAPACITY,.p ii . 1 . 1 . 1 . 1 . 1 . 2 . 2 . 3 . 3 . 3 . 3 . 3 . 3 . 3 . 3 . 3 . 4 . 4 . 4 . 4 . 4 . 4 . 4 . 4 . 4 . 4 . 5 . 5 . 5 . 5 . 6

16、. 6 . 6 . 6 . 7 . 7 . 9 SPOT . 10 . 10 p iii ANSI/AHAM PAC12015 TABLE 3 STANDARD RATING CONDITIONS 11 TABLE 4 EXTERNAL STATIC PRESSURE FOR EVAPORATOR AIR QUALITY TESTING 11 FIGURE 1 PORTABLE AIR CONDITIONER EQUIPMENT CONFIGURATIONS . 12 FIGURE 2 VENTING CONFIGURATIONS FOR CONDENSER AIR QUALITY TESTI

17、NG 20 ANSI/AHAM PAC1P1.ThspThinaiAininThpreThppS2.2.12a)bc)d22015 urpose is standard ecified prode standard tended to prr conditionerHAM recognfiltration plafiltration for is standard erformance ovision. e standard reclude the eerformance. cope This Staa ratedof the oNote: Tcapabil.2 This Sttesting

18、andcoil units fcomputer)room air cthe effect)configurat.3 TerminIn AHAuser isexpresto expNotes the puinformNotes as reqestablishes auct charactermethods andovide a meas regarding cizes that for ys a major rthese types oapplies to cf units with methods anxercise of inndard appliecooling capaperating

19、conhe air conditity. andard doesrating of inor separate uor data proconditioners ws of air infions. ology M Standardobliged to s a recommeress an optioaccompanyinrpose of a noative materiato tables anduirements. uniform, reistics of portthe recommns to comparharacteristicsingle duct coole in determf

20、 products aooling perfoheating functd the recomgenuity or ts to the coocity of 19 00figurations dioners descrinot apply todividual assese; essing room ithin the scoiltration on s, “shall” is usatisfy in orndation or thn or that whig clauses dote accompanl. figures are cpeatable proable air condended

21、 levee and evaluas significant tndenser conining the ore not presenrmance only ion. Heatingmended levo prevent imling perform0 W (65 000 escribed in Sbed in this C: mblies, such air conditionepe of CAN/CSportable airsed to expreder to compat which is ach is permissnot includeying a clauseonsidered p

22、acedure or stitioners. ls of performte different o product usfigurations overall energytly accounteand is not iperformancels of perfoprovement ance of portBtu/h) or lesection 4. lause includeas condensiners within theSAC368.1 orconditionerss a requirely with the dvised but nible within the requireme

23、ntis to separart of the tabandard methance, wherebrands and me. f portable aefficiency. d for in this sintended to ce will be conrmance areand innovatable air conds and provideair conditiog units or discope of ANANSI/AHAMs with singlment, i.e., a standard; “sot required; e limits of thts or alternat

24、te from the tle or figure aod for measthey appeaodels of poir conditioneThe effects tandard. cover the hesidered in a fnot intendeion in designitioners thatcooled air iners with herect expansioSI/ASHRAE 1RAC1; andeduct condprovision thahould” is usand “may” ise standard. ive requiremext explanatond

25、may be wp 1 uring r, are rtable rs, air of air ating uture ed to and have n one ating n fan 27; enser t the ed to used ents; ry or ritten ANSI/AHAM PAC12ThinR3.ThtoAMPAPoRARAR15Sa37MEq12MCSBMCCaCRCAPeCACoCAH2015 Annexdefine.4 Units oe values givformation oneference pis Standard the edition NSI/AHAM

26、anufacturerC12009 rtable Air CoC11982 (Room Air CondNSI/ASHRAEefrigerating aand ble from the Ama, Georgia 3032lable from the ww.nfpa.org fficiency Ratby dividingble 3). This ditioner is teEfficiency Raby dividing ble 3). This ditioner is tey Efficiency Rby dividing . This valueoner is testedenser En

27、ergyby dividingsee Table 3)air conditionests performndition ons specifiehen a Portato a power sirect signal fritioner. s shall be desfrigeration saable require1; erican Society 9 or http:/wwwNational Fire Pio (DD EER)the Dual Duvalue is detested to confitio (SD EERthe Single Duvalue is detested to c

28、onfiatio (SC EEthe Spot Coois determinto configuraEfficiency Rthe Water C. This value er is tested toed at standard in Table ble Air Condupply, and com a remoteigned, constfety requiremments are foof Heating, Refr.ashrae.org/purotection Assocct Cooling Carmined at stguration 3 (s) ct Cooling Crmined

29、 at stguration 5 (sER) ling Capacited at standation 1 (see Tatio (WCC ooled Condeis determineconfiguratiod rating cond4 and useditioner is in an be switchdevice. ructed and aents for theund in: rigerating and Ablications/ iation, 1 Batterpacity in Btuandard ratingsee Table 1 anapacity in Btandard ra

30、tingsee Table 1 anty in Btu/hr brd rating conable 1 and TaEER) nser Capacitd at standardn 7 (see Tabitions as shofor compaits lowest poed on by the ssembled soU.S. and/orir Conditioningymarch Park, Q/hr by the pconditions d Table 3). u/hr by the pconditionsd Table 3). y the power ditions wheble 3).

31、y in Btu/hr brating condle 1 and Tablwn in Table 1ring performwer consumuser directlyas to meeCanadian mEngineers, 179uincy, Massachp 4 ower when ower when input n the y the itions e 3). . ance ption y or by t the arket, 1 Tullie usetts ANSI/AHAM PAC15R6.6DCanfrRfo346a)bc)de)a)bc)d3toCO4CCa2015 (iii

32、) UL s.2 For Ca(i) the (ii) CSA(iii) CSAatings Req.1 Generual Duct Cooooled Conded shall incluom the total atings of watr a cooling t.1 W per 100.2 Rating6.2.1Dual Duct Single Duc)Spot CooliWater Coo)Power Inp6.2.2Dual Duct Single Duc)Spot CooliWater Coo)Copies are availllfree 1888ULMM 2000, 141opie

33、s are availnada or http:/tandard 4843nada, applicaCanadian EleB524; and C22.2 No. 11uiremental ling Capacitnser Capacityde the effectpower input ercooled unower fan mo0 W (10 W ps The followi2: Cooling Capat Cooling Capng Capacity; led Condensut. The followiEnergy Efficiet Energy Efficng Energy Effl

34、ed Condensable Online from33503 or 18884 Brook Drive, Dable from the Cwww.csaintl.or. ble requiremctrical Code, 74. s y, Single Duratings shals of the evapto the comprits not equipptor power iner 1000 Btu/ng ratings shcity; acity; er Capacity; ang ratings shncy Ratio (Diency Ratio (iciency Ratioer E

35、nergy EffComm2000 (8533503; by fowners Grove, anadian Standag/onlinestore/ents are fouPart I4; ct Cooling Cl be stated asorator circulaessor(s), fan ed with an iput and circh) cooling caall be reportend all be expressDEER); SDEER); (SCEER); aniciency Ratiohttp:/www.coax 1.630.932.73IL 60515. rds Ass

36、ociation,nd in: apacity, Spototal (sensibtingfan heamotor(s), contegral pumpulating watepacity. d to the neaed to the ned (WCCEER) by email or5060 Spectrumt Cooling Cale and latenat. Input ratinntrol(s), and shall includer pump motrest multiplearest multipl); by phone (Underscomm20Way, Mississapacit

37、y and Wt) cooling capgs shall be depump(s). a total allowor power inpspecified in e of 0.1 Btu/hited States or C; or by uga, Ontario L4p 5 ater acity rived ance ut of Table /W: anada) mail at W 5N6 ANSI/AHAM PAC166WraalT7.7a)bc)de)2015 .3 ApplicRating7 may the tes.4 Publis6.4.1hen tested, tings, exc

38、eptlowance shaests .1 GenerTests requirequipmentdetermina)of ANSI/ASdeterminarecording )reporting o7.1.27.1.3ation Ratingss of temperabe establishets specified ihed Ratings The performcapacity) pshall be deand 8. Pubtype as deSections 6.2capacity. units shall hafor an allowll not result inal shall b

39、e conements: setup: Secttion of roomHRAE 37; tion of poweof data: Sectif test resultsPumps thatRating testthe conden1 hour. Tintervals orIf there areduring a tecycles haveTesting of uair is dischaFor units wFigure 1) wadjacent chdifference ture and air qd as applicatn Section 7.ance ratingublished i

40、n atermined at lished ratingfined in Figuand 6.3. Otve measuredance to cova measuredducted in acions 5.1, 5.3,cooling capar input: Section 9 of ANSI/: Section 10 cycle on ands of units thasate collectehe data acqless and intefewer thanst period of been complenits with a srged into an ith a singledhe

41、re the conamber), a mbetween theuantity condion ratings as (DD EER, manufacturstandard rats shall referere 1 and Taher units, e.gratings equaer testing anrating less thcordance wit5.4, and 5.6 city and Spoton 5.4 of ANSASHRAE 37; of ANSI/ASHRoff t incorporated by the unituisition systgrate the datwo

42、 compleat least one ted. ingleduct coadjacent chauct condensdenser air is eans shall beconditioneditions other nd shall be bSD EER, SCers specificaing conditionce the appble 2 and be., tons, shall l to or betted manufactuan 95% of thth Sections 7of ANSI/ASHCooling CapI/ASHRAE 37and AE 37. pumps that

43、shall be condem shall tata for the entte on/off cyhour, the tendenser confmber er configuradischarged inprovided to space and tthan those sased on data EER, WCC tions, literatns accordancplicable operareported innot be used er than the apring variatioe applicable.2 to 7.3.8 RAE 37; acity: Section; c

44、ycle on anducted over ake data scanire test periocles of the st shall be coiguration whation (configuto an unconensure that the unconditipecified in Sedetermined EER and coure, or advere with Sectiting configuraccordanceto indicate coplicable pubns. Howevepublished raand the follos 7.3, 7.6, and off

45、 to dispoperiod of ats at five sed. condensate ntinued untere the condrations 5 andditioned spache static preioned space ip 6 ction from oling tising ons 7 ation with oling lished r, the ting. wing d 7.7 se of least cond pump il two enser 6 in e (an ssure s less ANSI/AHAM PAC177a)bc)dNde2015 .2 Setu

46、pUnits s.3 Standa7.3.17.3.27.3.37.3.4Units in opUnits in op)with the condenserUnits in opUnits in op)ote: The rescribed in Fi7.3.57.3.6than 0.005discharged temperaturand installahall be positrd Rating TeGeneral All adjustabset at maxiVoltage andTests shall For units wvoltages, obe publisheEquipmentU

47、nits shall equipmentshall also bSetup and Units shall erating confierating conflouver blockeair inlet throerating confierating confiquirements ogure 1. Air and watAir and waTable 3. Evaporator7.3.6.1 Un7.3.6.2 Unat tinches H2Ointo the coe of the air etion ioned level ust Conditionle settings, mum ca

48、pacitfrequencybe performeith dual namr at the lowed. be tested witrecommende in place. installationset up for tesguration 1 origuration 3 ad shall be ugh the ductguration, 5 oguration 7 orf this Sectioer temperatuter temperatarrangemenits shall be teits intended he applicable(1.25 Pa).nditioned snte

49、ring the tnless the mans e.g., louvers,y. d at a unitseplate voltagr of the two vh manufactued by the mting as follow2 shall be tend 4 shall betested using and louver sr 6 shall be te8 shall be ten are summres and exteures and extt sted using a for use with external staAlternativelpace as lonest unit. ufacturers ifan speed,nameplate