DLA MIL-PRF-40039 E-1997 CLOTH WATERPROOF《防水布》.pdf

《DLA MIL-PRF-40039 E-1997 CLOTH WATERPROOF《防水布》.pdf》由会员分享，可在线阅读，更多相关《DLA MIL-PRF-40039 E-1997 CLOTH WATERPROOF《防水布》.pdf（8页珍藏版）》请在麦多课文档分享上搜索。

1、 MIL-PRF-40039E D 977990E 2053853 226 D I INCH-POUND I MIL-PRF-40039E 2 September 1997 SUPERSEDING MIL-C-40039D 20 October 1981 PERFORMANCE SPECIFICATION CLOTH, WATERPROOF This specification is approved for use by all Departments and Agencies of the Department of Defense. 1. SCOPE 1.1 Scope. This sp

2、ecification covers one type of waterproof cloth. 2. APPLICABLE DOCUMENTS 2.1 General. The documents listed in this section are specified in sections 4 and 5 of this standard. This section does not include documents cited in other sections of this standard or recommended for additional information or

3、 as examples. While every effort has been made to ensure the completeness of this list, document users are cautioned that they must meet all specified requirements documents cited in sections 4 and 5 of this standard, whether or not they are listed. 2.2 Government documents. 2.2.1 Specifications, st

4、andards, and handbooks. The following specifications, standards, and handbooks form a part of this document to the extent specified herein. Unless otherwise specified, the issue of these documents are those listed in the issue of the Department of Defense Index of Specifications and Standards (DODIS

5、S) and supplement thereto, cited in the solicitation (see 6.2). STANDARDS FEDERAL FED-STD- 19 1 FED-STD-595 - Textile Test Methods - Colors Used In Government Procurement MILITARY . MIL-STD- 1487 - Glossary of Cloth Coating Imperfections Beneficial comments, recommendations, additions, deletions, cl

6、arifications, etc. and any data which may improve this document should be sent to: Defense Personnel Support Center, Clothing and Textiles Directorate, Attn: DPSC-FNS, 2800 South 20th Street, Philadelphia, PA 19145-5099. AMSC N/A FSC 8305 DISTRIBUTION STATEMENT A. Approved for public release; distri

7、bution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-40037E iq?Ob 20.53852 Lb2 9 MIL-PRF-40039E (Unless otherwise indicated. copies of federal and military specifications, standards, and handbooks are available from the Standa

8、rdization Documents Order Desk. Bldg. 4D, 700 Robbins Avenue, Philadelphia, PA 191 1 1-5094.) 2.2.2 Other Government documents, drawings, and publications. The following other Government documents, drawings, and publications form a part of this document to the extent specified herein. Unless otherwi

9、se specified, the issues are those cited in the solicitation. FEDERAL TRADE COMMISSION Rules and Regulations Under-the Textile Fiber Products Identification Act (Copies are available from the Federal Trade Commission, Pennsylvania Avenue at Sixth Street, N.W., Washington, DC 20580-0001 .) 2.3 Non-Go

10、vernment publications. The following documents form a part of this document to the extent specified herein. Unless otherwise specified, the issues of the documents which are DOD adopted are those listed in the issue of the DODISS specified in the solicitation. Unless otherwise specified, the issues

11、of documents not listed in the DODISS are the issues of the documents cited in the solicitation (see 6.2). AMERICAN SOCIETY FOR TESTING AND MATERIALS (ASTM) (Applications for copies of referenced documents should be addressed to the American Society for Testing and Materials, 100 Barr Harbor Drive,

12、West Conshohocken, PA 19426- 2959.) TECHNICAL ASSOCIATION OF THE PULP AND PAPER INDUSTRY (TAPPI) (Applications for copies of referenced documents should be addressed to TAPPI Press, Technology ParlAtlanta, P.O. Box 105 1 13, Atlanta, GA 30348-5 1 13.) SEARS ROEBUCK AND COMPANY FABRIC DEFECT SCALES (

13、Fabric defect replica kits are available from Sears Roebuck and Company, Department 817, (ATTN: BSC 23-29), Sears Tower, Chicago, IL 60684). 2.4 Order of precedence. In the event of a conflict between the text of this document and the references cited herein, the text of this document takes preceden

14、ce. Nothing in this document, however, supersedes applicable laws and regulations unless a specific exemption has been obtained. 3. REQUIREMENTS 3.1 First article. When specified (see 6.2), a sample shall be subjected to first article inspection in accordance with 4.3. 3.2 Standard sample. The water

15、proof cloth shall match the standard sample for shade and appearance and shall be equal to or better than the sample for colorfastness (see 6.4). 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- MIL-PRF-Vfl03qE R! qOh 2053853 OT MIL-PRF-40039E Char

16、acteristic Weight Odyd2 (max) Breaking Strength, lbs. (min): Warp Filling Tearing Strength, grams (min): warp Filling Initial After water immersion Initial After water immersion Hydrostatic Resistance psi (min): After strength of coating Adhesion of coating, lbs/2 inch width (min) i/ Stiffness, cm (

17、warp only) (max): Blocking scale rating (max) Resistance to: Leakage (min.) 3.3 Performance requirements. The cloth shall conform to the requirements specified in Table I and 3.4 through 3.9. Requirements 7.3 90 80 770 575 40 20 20 6.0 5 .O 8.0 No. 2 No leakage TABLE I. Reauirements 3.4 Abrasion res

18、istance. The cloth shall show no loose fibers of the base cloth exposed in the center one (1) inch of the abraded area. 3.5 Low temDerature resistance. The cloth shall show no indication of the finish (if used) to crack, flake or separate from the base cloth. 3.6 Accelerated weathering resistance. T

19、he cloth shall show no increase in softness, stiffness, tackiness or brittleness when compared with an unexposed specimen of the finished cloth. 3.7 Color. The color of the cloth shall be Camouflage Green 483 conforming to color chip 34094 of FED-STD-595 (see 3.2 and 6.3). 3.7.1 Color matching. The

20、color of the cloth shall match the standard sample when viewed under filtered tungsten lamps that approximate artificial daylight and that have a correlated color temperature of 7500 Section 798.4100- Dermal Sensitization Section 798.4470- Primary Dermal Irritation Section 798.4500- Primary Eye Irri

21、tation Marzulli, F. & H. Maibach, “Contact Allergy: Predictive Testing in Humans“, Advances in Modern Toxicology, Volume 4, pp 353-372, which certifies that the finished product was composed of chemicals or materials which have been safely used commercially where prolonged skin contact has occurred.

22、 1977. b) As an alternative to animal and human testing, the contractor may provide information 4.4.1 1 Mildew resistance, A certificate of compliance shall be submitted for this requirement. 5. PACKAGING 5.1 Packaging. For acquisition purposes, the packaging requirements shall be as specified in th

23、e contract or order (see 6.2). When actual packaging of materiel is to be performed by DoD personnel, these personnel need to contact the responsible packaging activity to ascertain requisite packaging requirements. Packaging requirements are maintained by the Inventory Control Points packaging acti

24、vity within the Military Department System Command. Packaging data retrieval is available from the managing Military Departments or Defense Agencys automated packaging files, CD-ROM products, or by contacting the responsible packaging activity. 7 Provided by IHSNot for ResaleNo reproduction or netwo

25、rking permitted without license from IHS-,-,- NIL-PRF-YO039E R 7777qia 2353858 680 H MIL-PRF-40039E 6. NOTES (This section contains information of a general or explanatory nature that may be helpful, but is not mandatory.) 6.1 Intended use. The waterproof cloth is intended for use in the fabrication

26、 of heavy duty wet weather ponchos. 6.2 Acauisition reauirements. Acquisition documents must specify the following: a. Title, number, and date of this specification. b. Issue of DODISS to be cited in the solicitation, and if required, the specific issue of c. When first article is required (see 3.1

27、and 4.2). d. Width required. e. Levels of preservation and packing (see 5.1). individual documents referenced (see 2.1.1 and 2.2). 6.3 Standard sample. For access to the shade sample (see 3.2) address the contracting activity issuing the invitation for bids. 6.4 Subiect term (key word) listing. Water resistant Poncho Wet weather clothing system Custodians: Army - GL Navy - NU Preparing activity (Project 8305-0626) DLA-CT 4 Review activities: Navy - MC 8 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-