COE EP 1110-1-8 VOL 1-2009 Construction Equipment Ownership and Operating Expense Schedule Region I《施工设备的所有权和运行费用表I》.pdf

《COE EP 1110-1-8 VOL 1-2009 Construction Equipment Ownership and Operating Expense Schedule Region I《施工设备的所有权和运行费用表I》.pdf》由会员分享，可在线阅读，更多相关《COE EP 1110-1-8 VOL 1-2009 Construction Equipment Ownership and Operating Expense Schedule Region I《施工设备的所有权和运行费用表I》.pdf（570页珍藏版）》请在麦多课文档分享上搜索。

1、 EP 1110-1-8 Volume 1 November 2009 Construction Equipment Ownership and Operating Expense Schedule Region I Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS

2、-,-,-DEPARTMENT OF ARMY U.S. Army Corps of Engineers Washington, DC 20314-1000 This pamphlet supersedes EP 1110-1-8, dated 31 July 2007. REPLY TO ATTENTION OF: CECW-EC Pamphlet 30 November 2009 No. 1110-1-8, Vol. 1 CONSTRUCTION EQUIPMENT OWNERSHIP AND OPERATING EXPENSE SCHEDULE 1. Purpose. This pamp

3、hlet is authorized by and established in accordance with Federal Acquisition Regulation (FAR) 31.105 and Engineer Federal Acquisition Regulation (EFAR) SUBPART 31.105. This pamphlet establishes predetermined equipment ownership and operating expense rates for construction equipment. This pamphlet al

4、so establishes a method to calculate equipment ownership and operating expense rates for construction equipment when the predetermined rates are not considered appropriate. The overall intent of this pamphlet is to determine equipment costs that are fair and reasonable. Expense factors for calculati

5、ng dredge plant and marine equipment costs are provided in chapter 4. 2. Applicability. This pamphlet applies to all USACE commands. It is applicable to all solicitations and contracts for construction expected to exceed the Simplified Acquisition Threshold of $100,000 when actual cost data for both

6、 ownership and operating costs cannot be determined. This volume is for use in Region I, which includes the following states: Connecticut Maine Massachusetts New Hampshire New Jersey New York Pennsylvania Rhode Island Vermont 3. References. See APPENDIX A. 4. Distribution Statement. Approved for pub

7、lic release, distribution is unlimited. FOR THE COMMANDER: 12 Appendixes STEPHEN L. HILL (See Table of Contents) Colonel, Corps of Engineers Chief of Staff EP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-This page intentio

8、nally left blankEP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-iCONSTRUCTION EQUIPMENT OWNERSHIP AND OPERATING EXPENSE SCHEDULE Table of Contents CHAPTER 1.0 - INTRODUCTION 1.1 Use 1-1 1.2 Decision Flow Process 1-1 1.3 Ho

9、w to Obtain Assistance 1-1 1.4 How to Obtain CHECKRATE Spreadsheet 1-2 1.5 How to Obtain this Publication. 1-2 CHAPTER 2.0 - METHODOLOGY FOR CONSTRUCTION EQUIPMENT SECTION I. GENERAL.2-1 2.1 Contents 2-1 2.2 Basis for Equipment Rates 2-1 2.3 Total Hourly Rate. 2-1 SECTION II. OPERATING CONDITIONS.2-

10、2 2.4 Average, Difficult, or Severe Conditions 2-2 2.5 Determination of Condition 2-3 SECTION III. EQUIPMENT SELECTION2-3 2.6 General 2-3 2.7 Truck Selection 2-3 2.8 Crawler Tractor Selection 2-3 2.9 Equipment Accessories. 2-4 SECTION IV. EQUIPMENT VALUE .2-4 2.10 List Price and Accessories. 2-4 2.1

11、1 Discount Code (DC) 2-4 2.12 Sales or Import Tax . 2-4 2.13 Freight . 2-4 2.14 Total Equipment Value (TEV) 2-4 SECTION V. LIFE .2-5 2.15 Economic Life (LIFE). 2-5 2.16 Working Hours Per Year (WHPY) 2-5 SECTION VI. SALVAGE VALUE .2-5 2.17 Salvage Value (SLV) . 2-5 2.18 Salvage Value Percentage 2-5 E

12、P 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-iiCONSTRUCTION EQUIPMENT OWNERSHIP AND OPERATING EXPENSE SCHEDULE Table of Contents (Continued) SECTION VII. OWNERSHIP COST2-6 2.19 Ownership Elements . 2-6 2.20 Depreciation

13、2-6 2.21 Facilities Capital Cost of Money (FCCM). 2-7 SECTION VIII. OPERATING COST2-7 2.22 Operating Cost Elements 2-7 2.23 Fuel Cost . 2-8 2.24 Filters, Oil, and Grease (FOG) Cost 2-9 2.25 Repair Cost 2-10 2.26 Tire Wear Cost 2-12 2.27 Tire Repair Cost 2-13 SECTION IX. STANDBY HOURLY RATE2-14 2.28

14、Standby Hourly Rate . 2-14 SECTION X. RATE CALCULATION EXAMPLE2-14 2.29 Computation Example . 2-14 CHAPTER 3.0 - ADJUSTMENTS TO HOURLY RATES SECTION I. GENERAL.3-1 3.1 Contents 3-1 3.2 Basis for Equipment Rates 3-1 3.3 Equipment Rate Adjustment Tables 3-1 3.4 Determination for Use of Equipment Rates

15、 in Tables 2-1 and 2-2.3-1 SECTION II. RATE ADJUSTMENTS3-2 3.5 Rate Adjustments 3-2 3.6 Changes in Operating Conditions 3-2 3.7 Change in Cost of Money Rate (CMR) 3-2 3.8 Actual Work Hours Greater than 40 Hours per Week 3-3 3.9 Changes in Fuel Cost 3-4 3.10 Adjustments to Fuel, Oil, and Grease (FOG)

16、 Cost 3-5 3.11 Equipment of Different Age than Table 2-1 . 3-5 3.12 Rate Adjustment for Overage Equipment 3-6 3.13 Standby Rate Adjustment for Equipment of a Different Age than Table 2-13-7 3.14 Equipment Purchased Used 3-8 3.15 Rate Calculation Examples 3-8 EP 1110-1-8, Vol. 130 Nov 09Provided by I

17、HSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-iiiCONSTRUCTION EQUIPMENT OWNERSHIP AND OPERATING EXPENSE SCHEDULE Table of Contents (Continued) CHAPTER 4.0 - METHODOLOGY FOR DREDGING PLANT AND MARINE EQUIPMENT SECTION I. GENERAL.4-1 4.1 Contents 4-1 4.2 General

18、4-1 SECTION II. ANNUAL USE4-1 4.3 Time Available to Dredge 4-2 SECTION III. LIFE 4-2 4.4 Life. 4-2 4.5 Annual Hours Available . 4-3 SECTION IV. SALVAGE VALUE .4-3 4.6 Salvage Value (SLV) . 4-3 SECTION V. OWNERSHIP COST4-3 4.7 Ownership Cost. 4-3 4.8 Depreciation Factor . 4-4 4.9 The Cost of Money Ra

19、te (CMR) Factor . 4-4 4.10 Other Ownership Elements 4-5 SECTION VI. OPERATING FACTORS 4-5 4.11 Hourly Operating Cost. 4-5 4.12 Prime and Secondary Power. 4-5 4.13 Water, Lube, and Supplies (WLS) . 4-6 4.14 Repairs (RPR) . 4-6 SECTION VII. STANDBY4-7 4.15 Standby Rate. 4-7 SECTION VIII. NEGOTIATED PR

20、OCUREMENT .4-7 4.16 Rates. 4-7 4.17 Allowance for Additional Capital Improvements. 4-8 4.18 Overage Plant 4-8 4.19 Dredging Plant Purchased Used . 4-8 SECTION IX. RATE CALCULATION EXAMPLE .4-8 4.20 Rate Calculation Example . 4-8 EP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproductio

21、n or networking permitted without license from IHS-,-,-ivCONSTRUCTION EQUIPMENT OWNERSHIP AND OPERATING EXPENSE SCHEDULE Table of Contents (Continued) List of Tables Table 2-1. Hourly Equipment Ownership and Operating Expense 2-21 Table 2-2. Hourly Rate Elements.2-253 Table 3-1. Equipment Age Adjust

22、ment Factors .3-9 Table 3-2. Equipment Age Adjustment Factors .3-33 Table 4-1. Dredging Plant Cost Factors 4-9 List of Figures Figure 1-1. Methodology for Developing an Hourly Ownership and Operating Rate for Construction Equipment1-3 Figure 2-1. Equipment Rate Computation Worksheet .2-15 Figure 3-1

23、. Total Hourly Rate Calculation for Overage Equipment3-25 Figure 3-2. Standby Hourly Rate Calculation for Overage Equipment.3-49 Figure 4-1. Months Available by Region4-2 Figure 4-2. Dredging Plant Ownership and Operating Rate Worksheet 4-13 List of Appendixes Appendix A References .A-1 Appendix B A

24、rea Factors .B-1 Appendix C Guide for Selecting Operating Conditions C-1 Appendix D Equipment Hourly Calculation Factors. D-1 Appendix E Economic Indexes for Construction Equipment E-1 Appendix F Tire Description and Tire Cost F-1 Appendix G Tire Life and Tire Wear Factors . G-1 Appendix H Manufactu

25、rer List . H-1 Appendix I Federal Cost-of-Money Rate I-1 Appendix J Equipment Accessories J-1 Appendix K Ground Engaging Component Costs Included in Repairs (RCF)K-1 Appendix L Guide for Estimating Drill Steel and Drill Bit Costs L-1 Glossary.Glossary-1 Index . Index-1 EP 1110-1-8, Vol. 130 Nov 09Pr

26、ovided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-1-1CHAPTER 1.0 - INTRODUCTION 1.1 Use The use of this pamphlet is for rate determination on construction contracts, dredging contracts, and negotiated procurements and relates only to contractor-owned equ

27、ipment. The overall intent of the pamphlet is to determine equipment costs that are fair and reasonable. a. This pamphlet shall be used for determining hourly equipment rates that are contained in the independent government estimate. b. In addition, the use of this pamphlet will be required by contr

28、actors for pricing contractor-owned equipment in negotiated procurements when: (1) Cost or pricing data is not required, as defined in Federal Acquisition Regulation (FAR) Part 15.400, Contract Pricing. (2) Cost or pricing data is required and the actual cost data to support either ownership or oper

29、ating costs for equipment or equipment groups of similar model and series is not available. (3) Cost or pricing data is required and available, but all or part of the data is determined not to be in accordance with the FAR cost principles. 1.2 Decision Flow Process A flow chart (figure 1-1) is provi

30、ded at the end of this chapter to help the user better understand the process for developing an hourly equipment rate. The flow chart shows the decision points that allow the user to decide whether to use the predetermined rate tables or calculate the rate using the method shown in figure 2-1 or usi

31、ng CHECKRATE (also see paragraph 3.4). 1.3 How to Obtain Assistance When assistance is needed in understanding the methodology for calculating equipment rates, contact the Chief, Cost Engineering Branch, Engineering and Construction Division, Walla Walla District, U.S. Army Corps of Engineers, (CENW

32、W-EC-X), 509-527-7511, 509-527-7510, or visit the Web site at http:/www.nww.usace.army.mil/html/offices/ed/c/default.asp. EP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-1-21.4 How to Obtain CHECKRATE Spreadsheet A Microso

33、ft Excelspreadsheet, named “CHECKRATE,” has been developed to calculate equipment rates using the methodology required by this pamphlet. The user must have Microsoft Excelto run the application. The factors needed in the hourly cost calculations are located in the appendixes of this pamphlet. A copy

34、 of the spreadsheet may be obtained by choosing the CHECKRATE link on the following Web site: http:/www.nww.usace.army.mil/html/offices/ed/c/default.asp. 1.5 How to Obtain this Publication Volumes 1-12 of this pamphlet are available in portable document format (PDF) and can be viewed or downloaded a

35、t http:/140.194.76.129/publications/eng-pamphlets. Copies of the pamphlet are also available on CD-ROM (Volumes 1-12) through the Superintendent of Documents or government bookstores (see appendix A). For additional information, telephone 202-512-1800, fax 202-512-2104, toll-free 866-512-1800, or ac

36、cess on the Internet at http:/bookstore.gpo.gov/. EP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-Finished. The methodology in ths pamphlet should not be used for rental or leased equipment.YESYESAVERAGE SEVERENOYESNODIFFI

37、CULTIs the equipment contractor owned ? Is the equipment in Table 2-1?Is there equipment in Table 2-1 that is equivalent in configuration (size, capacity, and horsepower) and value to the equipment for which you are determining a rate? Use the tables in chapter 2 for the actual or equivalent equipme

38、nt.Is the equipment operating in average severe or difficult conditions? (see chapter 2, section II for definition)Calculate a rate based on the step-by-step rate computation method shown in Figure 2-1 or use CHECKRATEUse the equipment rate shown in Table 2-1From Table 2-2 use the arithmetic mean of

39、 the average and severe equipment rates. (Note: if there is no severe rate for the equipment see guidance in chapter 2, section II, paragraph 2-4.)Use severe rate shown in Table 2-2. (Note: if there is no severe rate for the equipment see guidance in chapter 2, section II, paragraph 2-4.)Is the use

40、of this pamphlet required in accordance with Chapter 1, paragraph 1-1?YESNOUse the contractors actual cost and pricing data to determine a rate.NOFigure 1-1. Methodology for Developing an Hourly Ownership and Operating Rate for Construction EquipmentSTARTNext Page Is this land based or marine equipm

41、ent?Land Based Equipment Marine equipmentUse the methodology found in Chapter 4 for determining a rate for Marine Equipment.Is the equipment in Table 2-1 equivalent in configuration (size, capacity, and horsepower) and value to the equipment for which you are determining a rate? YES1-3EP 1110-1-8, V

42、ol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-NOYESNONOFINISHED (except for standby)YESNOEquipment is newerIf equipment is older than in Table 2-1 determine economic life by dividing LIFE by Working Hours Per Year. (see chapter3 secti

43、on II, Paragraph 3-11.a.) Equipment is olderEquipment age does not exceed economic lifeEquipment age exceeds economic lifeIs the Cost of Money Rate (CMR) different from that shown in chapter 2, section VII or Appendix B? The Department of the Treasury adjusts the CMR (Prompt Payment Interest Rate) o

44、n or about 1 January and 1 July each year. For the current Prompt Payment Interest Rate seehttp:/www.publicdebt.treas.gov/opd/opdprmt2.htm. If the cost of money rate shown in chapter 2, section VII, is not the current rate, the FCCM portion of the total hourly rate shall be adjusted. Adjust the Cost

45、 of Money Rate per the instructions in chapter 3, section II, paragraph 3-7.Is the cost of fuel 10% greater than or 10% less than the cost shown in Appendix B?The contractor shall be required to furnish copies of all fuel supply contracts and invoices to the government to support fuel cost adjustmen

46、t. Request for upward adjustment in the rates will be considered only when fuel is supplied by recognized distributors of bulk quantitiesIf the contractor is able to furnish the above information, adjust the fuel cost per the instructions in chapter 3, section II, paragraph 3-9.If fuel costs are adj

47、usted FOG costs also need to be adjusted by applying the same ratio used to adjust the fuel cost.Do the actual hours worked exceed 40 hours per week?Make adjustments to the FCCM per the instructions in chapter 3, section II, paragraph 3-8Is the equipments date of manufacure different from that in Ta

48、ble 2-1 (see chapter 2 section 1, paragraph 2-2)?Adjust the rate using Table 3-1 per the instructions found in chapter3 section II, Paragraph 3-11.c.Adjust the rate using Table 3-1 per the example found in chapter3 section II, Paragraph 3-11.a.Adjust the rate using Table 3-1 per the instructions found in chapter3 section II, Paragraph 3-12.YESFigure 1-1. Methodology for Developing an Hourly Ownership and Operating Rate for Construction EquipmentContinue from previous page1-4EP 1110-1-8, Vol. 130 Nov 09Provided by IHSNot for ResaleNo reproduction or networking