ANSI UL 60335-2-1000-2017 UL Standard for Safety Household and Similar Electrical Appliances Particular Requirements for Electrically Powered Pool Lifts (First Edition).pdf

《ANSI UL 60335-2-1000-2017 UL Standard for Safety Household and Similar Electrical Appliances Particular Requirements for Electrically Powered Pool Lifts (First Edition).pdf》由会员分享，可在线阅读，更多相关《ANSI UL 60335-2-1000-2017 UL Standard for Safety Household and Similar Electrical Appliances Particular Requirements for Electrically Powered Pool Lifts (First Edition).pdf（37页珍藏版）》请在麦多课文档分享上搜索。

1、UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL UL 60335-2-1000 Household and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts STANDARD FOR SAFETYUL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER RE

2、PRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM ULUL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL UL Standard for Safety for Household and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts, UL 6033

3、5-2-1000 First Edition, Dated September 29, 2017 Summary of Topics This First Edition of ANSI/UL 60335-2-1000, the Standard for Safety for Household and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts was issued which includes requirements for the safety of

4、 electrically powered pool lifts intended for persons requiring assistance for safe entry into and out of a pool. The new requirements are substantially in accordance with Proposal(s) on this subject dated June 16, 2017 and August 18, 2017. All rights reserved. No part of this publication may be rep

5、roduced, stored in a retrieval system, or transmitted in any form by any means, electronic, mechanical photocopying, recording, or otherwise without prior permission of UL. UL provides this Standard as is without warranty of any kind, either expressed or implied, including but not limited to, the im

6、plied warranties of merchantability or tness for any purpose. In no event will UL be liable for any special, incidental, consequential, indirect or similar damages, including loss of prots, lost savings, loss of data, or any other damages arising out of the use of or the inability to use this Standa

7、rd, even if UL or an authorized UL representative has been advised of the possibility of such damage. In no event shall ULs liability for any damage ever exceed the price paid for this Standard, regardless of the form of the claim. Users of the electronic versions of ULs Standards for Safety agree t

8、o defend, indemnify, and hold UL harmless from and against any loss, expense, liability, damage, claim, or judgment (including reasonable attorneys fees) resulting from any error or deviation introduced while purchaser is storing an electronic Standard on the purchasers computer system. SEPTEMBER 29

9、, 2017 UL 60335-2-1000 tr1UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL SEPTEMBER 29, 2017 UL 60335-2-1000 tr2 No Text on This PageUL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL S

10、EPTEMBER 29, 2017 1 UL 60335-2-1000 Standard for Household and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts First Edition September 29, 2017 This ANSI/UL Standard for Safety consists of the First Edition including revisions through September 29, 2017. Th

11、e most recent designation of ANSI/UL 60335-2-1000 as an American National Standard (ANSI) occurred on September 29, 2017. ANSI approval for a standard does not include the Cover Page, Transmittal Pages, and Title Page. Any other portions of this ANSI/UL standard that were not processed in accordance

12、 with ANSI/UL requirements are noted at the beginning of the impacted sections. Comments or proposals for revisions on any part of the Standard may be submitted to UL at any time. Proposals should be submitted via a Proposal Request in ULs On-Line Collaborative Standards Development System (CSDS) at

13、 https:/. ULs Standards for Safety are copyrighted by UL. Neither a printed nor electronic copy of a Standard should be altered in any way. All of ULs Standards and all copyrights, ownerships, and rights regarding those Standards shall remain the sole and exclusive property of UL. COPYRIGHT 2017 UND

14、ERWRITERS LABORATORIES INC. ANSI/UL 60335-2-1000-2017UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL SEPTEMBER 29, 2017 UL 60335-2-1000 2 No Text on This PageUL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WIT

15、HOUT PERMISSION FROM UL CONTENTS FOREWORD 6 Preface .7 1 Scope .8 2 Normative References .9 3 Terms and denitions9 4 General requirement .10 5 General conditions for the tests10 6 Classication 10 7 Marking and instruction .11 8 Protection Against Access to Live Parts 13 9 Starting of Motor-Operated

16、Appliances .13 10 Power Input and Current.13 11 Heating 13 12 Void.14 13 Leakage Current and Electric Strength at Operating Temperature 14 14 Transient Overvoltages 14 15 Moisture Resistance 14 16 Leakage Current and Electric Strength 14 17 Overload Protection of Transformers and Associated Circuits

17、 15 18 Endurance .15 19 Abnormal Operation.15 20 Stability and Mechanical Hazards .15 21 Mechanical Strength 16 22 Construction .16 23 Internal Wiring17 24 Components .17 25 Supply Connection and External Flexible Cords 18 26 Terminals for External Conductors 19 27 Provision for Earthing .19 28 Scre

18、ws and Connections 19 29 Clearances, Creepage Distances and Solid Insulation 19 30 Resistance to Heat and Fire .19 31 Resistance to Rusting .20 32 Radiation, Toxicity and Similar Hazards .21 SEPTEMBER 29, 2017 UL 60335-2-1000 3UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRI

19、BUTION WITHOUT PERMISSION FROM UL Annexes Annex B Annex S Annex AA (informative) Bibliography SEPTEMBER 29, 2017 UL 60335-2-1000 4UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL SEPTEMBER 29, 2017 UL 60335-2-1000 5 No Text on This PageUL COP

20、YRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL FOREWORD The Standard for Safety for Household and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts, UL 60335-2-1000 is to be used in conjunction with the si

21、xth edition of the Standard for Safety of Household and Similar Electrical Appliances, Part 1: General Requirements, UL 60335-1. NOTE 1: When “Part 1” is mentioned in this standard, it refers to UL 60335-1. When a particular subclause of Part 1 is not mentioned in this Part 2, that subclause applies

22、 as far as is reasonable. When this standard states “addition”, “modication” or “replacement”, the relevant text of Part 1 is to be adapted accordingly. NOTE 2: The following numbering system is used: subclauses, tables and gures that are numbered starting from 101 are additional to those in Part 1;

23、 unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including those in a replaced clause or subclause; additional Annexes are lettered AA, BB, etc. NOTE 3: in this standard, the following print types are used: requirements: in roman type; test specic

24、ations in: italic type; notes: in smaller roman bold type. Words in SMALL ROMAN CAPS in the text are dened in clause 3. SEPTEMBER 29, 2017 UL 60335-2-1000 6UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL Preface This standard is considered s

25、uitable for use for conformity assessment within the stated scope of the standard. This standard has been approved by the American National Standards Institute (ANSI) as an American National Standard. Application of Standard Where reference is made to a specic number of samples to be tested, the spe

26、cied number is to be considered a minimum quantity. NOTE: Although the intended primary application of this standard is stated in its scope, it is important to note that it remains the responsibility of the users of the standard to judge its suitability for their particular purpose. This UL Standard

27、 is to be used in conjunction with the Standard for Safety of household or Similar Electrical Appliances, Part 1: General Requirements, UL 60335-1. SEPTEMBER 29, 2017 UL 60335-2-1000 7UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL Household

28、 and Similar Electrical Appliances: Particular Requirements for Electrically Powered Pool Lifts 1 Scope This clause of Part 1 is replaced by the following. This Standard deals with the safety of electrically powered pool lifts intended for persons requiring assistance for safe entry into and out of

29、a pool, their RATED VOLTAGE being not more than 150 V between supply phases or one phase and neutral or ground, and intended for installation in accordance with the US National Electrical Code, (NFPA 70) Article 680, Part VIII. NOTE 101: Examples of appliances that are within the scope of this stand

30、ard are: portable and stationary lifts of the chair type stationary lifts of the single wheelchair platform type. As far as is practicable, this standard deals with the common hazards presented by these appliances. However, in general, it does not take into account a) the use of appliances by young

31、children or inrm persons without supervision; b) playing with the appliance by young children. NOTE 102: Attention is drawn to the fact that: Authorities Having Jurisdiction should be consulted on additional installation regulations and requirements for lifts with respect to accessibility, performan

32、ce and the like. NOTE 103: This standard does not apply to: platform type lifts intended for multiple wheelchairs pool lifts for use in medical facilities SEPTEMBER 29, 2017 UL 60335-2-1000 8UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL 2

33、Normative References This clause of Part 1 is applicable except as follows. Addition: ANSI/NEMA WD 6, Standard for Dimensions of Attachment Plugs and Receptacles IEC 62133-2, Secondary cells and batteries containing alkaline or other non-acid electrolytes - Safety requirements for portable sealed se

34、condary lithium cells, and for batteries made from them, for use in portable applications - Part 2: Lithium systems ISO 3864-1:2011, Graphical symbols Safety colours and safety signs Part 1: Design principles for safety signs and safety markings. UL 746C, Polymeric Materials - Use in Electrical Equi

35、pment Evaluations UL 943, Ground-Fault Circuit-Interrupters UL 1703, Flat-Plate Photovoltaic Modules and Panels UL 1741, Inverters, Converters, Controllers and Interconnection System Equipment for Use With Distributed Energy Resources UL 62133, Secondary Cells and Batteries Containing Alkaline or Ot

36、her Non-Acid Electrolytes Safety Requirements for Portable Sealed Secondary Cells, and for Batteries Made From Them, for Use in Portable Applications 3 Terms and denitions This clause of Part 1 is applicable except as follows. 3.1.9 Replacement: NORMAL OPERATION operation of the appliance under the

37、following conditions: A lift is installed in accordance with the manufacturers installation instructions with the maximum recommended weight placed on the seat. A lift is operated through a cycle beginning at- rest on a at surface simulating a pool perimeter deck to the fully extended position with

38、its seat immersed to its maximum depth in water and then back to the at-rest position. 3.1.11 Addition: NOTE to entry: “ghost lift” is not considered a dangerous malfunction. SEPTEMBER 29, 2017 UL 60335-2-1000 9UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT P

39、ERMISSION FROM UL 3.4.3 Replacement: SAFETY ISOLATING TRANSFORMER transformer, the input winding of which is electrically separated from the output winding by an insulation at least equivalent to double insulation or reinforced insulation. NOTE 1 to entry: The denition describes a transformer that c

40、omplies with NFPA 70 680.23(A)(2). 3.101 ELECTRICALLY POWERED POOL LIFT an electrically powered lift that provides accessibility to and from a pool or spa for people with disabilities. NOTE 1 to entry: LIFT and ELECTRICALLY POWERED LIFT are used interchangeably in this standard. 3.102 LOW VOLTAGE CO

41、NTACT LIMIT a voltage not exceeding the following values: a) 15 volts (RMS) for sinusoidal ac b) 21.2 volts peak for non-sinusoidal ac c) 30 volts for continuous dc d) 12.4 volts peak for dc that is interrupted at a rate of 10 to 200 Hz 4 General requirement This clause of Part 1 is applicable. 5 Ge

42、neral conditions for the tests This clause of Part 1 is applicable. 6 Classication This clause of Part 1 is applicable except as follows. 6.1 Modication: LIFTS where the battery is removed for charging at another location and the battery is rated less than or equal to the LOW VOLTAGE CONTACT LIMIT a

43、re not classied. Solar-operated or solar-recharged LIFTS where the solar panel is attached to the LIFT and the battery is rated less than or equal to 24 volts are not classied. LIFTS supplied from a source not exceeding the LOW-VOLTAGE CONTACT LIMIT and supplied by transformers or power supplies tha

44、t comply with NFPA 70 680.23(A)(2) are not classied. STATIONARY LIFTS shall be CLASS I or CLASS III. NOTE: It is assumed that there will be no xed-wiring LIFT installations due to requirements for electrical outlets in the vicinity of pools. SEPTEMBER 29, 2017 UL 60335-2-1000 10UL COPYRIGHTED MATERI

45、AL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL 6.2 Addition: ELECTRICALLY POWERED POOL LIFTS shall be at least IPX5. Unless supplied via a SAFETY ISOLATING TRANSFORMER not exceeding the LOW-VOLTAGE CONTACT LIMIT, parts of ELECTRICALLY POWERED POOL LIFTS that ma

46、y be installed below the nished plane surface of the pool perimeter or that may be immersed in the pool, shall be at least IPX7. 7 Marking and instruction This clause of Part 1 is applicable except as follows. 7.1 Addition: weight capacity. The minimum rating shall be 300 lbs. 7.6 Addition: symbol I

47、SO 7000-0434 SEPTEMBER 29, 2017 UL 60335-2-1000 11UL COPYRIGHTED MATERIAL NOT AUTHORIZED FOR FURTHER REPRODUCTION OR DISTRIBUTION WITHOUT PERMISSION FROM UL 7.12 Addition: The instructions shall provide details for xing the LIFT and include parameters of the pool surround (deck) construction. The in

48、structions shall state IMPORTANT SAFETY INSTRUCTIONS When installing and using this electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING WARNING To reduce the risk of injury, do not permit children to use this product unless t

49、hey are closely supervised at all times. A wire connector is provided on this unit to connect a minimum 8 AWG (8.4 mm 2 ) solid copper conductor between this unit and the means for local equipotential bonding. Check the unit periodically for signs of deterioration Keep all nuts, bolts and screws tight to be sure the lift is in safe working condition. The instructions for Class I LIFTS shall state the substance of the following: GROUND FAULT CIRCUIT INTERRUPTER PROTECTION Th