BS ISO 763-2003 en_4836 Fruit and vegetable products - Determination of ash insoluble in hydrochloric acid《水果和蔬菜制品.盐酸不溶性灰分的测定》.pdf

《BS ISO 763-2003 en_4836 Fruit and vegetable products - Determination of ash insoluble in hydrochloric acid《水果和蔬菜制品.盐酸不溶性灰分的测定》.pdf》由会员分享，可在线阅读，更多相关《BS ISO 763-2003 en_4836 Fruit and vegetable products - Determination of ash insoluble in hydrochloric acid《水果和蔬菜制品.盐酸不溶性灰分的测定》.pdf（12页珍藏版）》请在麦多课文档分享上搜索。

1、BRITISH STANDARD BS ISO 763:2003 Fruit and vegetable products Determination of ash insoluble in hydrochloric acid ICS 67.080.01 BS ISO 763:2003 This British Standard was published under the authority of the Standards Policy and S t r a t e g y C o m m i t t e e o n 1 December 2003 BSI 1 December 200

2、3 ISBN 0 580 42603 3 National foreword This British Standard reproduces verbatim ISO 763:2003 and implements it as the UK national standard. There has been no UK participation in the preparation of this document. Any enquiries on the text should be sent to the Head of Standards International Content

3、. Cross-references The British Standards which implement international publications referred to in this document may be found in the BSI Catalogue under the section entitled “International Standards Correspondence Index”, or by using the “Search” facility of the BSI Electronic Catalogue or of Britis

4、h Standards Online. This publication does not purport to include all the necessary provisions of a contract. Users are responsible for its correct application. Compliance with a British Standard does not of itself confer immunity from legal obligations. Summary of pages This document comprises a fro

5、nt cover, an inside front cover, the ISO title page, pages ii and iii, a blank page, pages 1 to 4, an inside back cover and a back cover. The BSI copyright notice displayed in this document indicates when the document was last issued. Amendments issued since publication Amd. No. Date Comments Refere

6、nce number ISO 763:2003(E)INTERNATIONAL STANDARD ISO 763 Second edition 2003-12-01 Fruit and vegetable products Determination of ash insoluble in hydrochloric acid Produits drivs des fruits et lgumes Dtermination des cendres insolubles dans lacide chlorhydrique BSISO763:2003DPlcsid Fremia ihTs PDF f

7、ile may ctnoian emdebt dedyfepcaes. In ccaocnadrw eith Aebods licensilop gnic,y this file mairp eb ynted iv roweb detu slahl ton ide ebtlnu deess the typefaces whice era hml era deddebicsnede to i dnanstlaled t noeh computfrep reormign tide ehtin.g In wodlnidaot gnhis file, trapise atpecc tiereht ns

8、er ehnopsiiblity fo not infriigngn Aebods licensilop gnic.y ehT ISO tneClar Secrteiraat caceptl on siibality in this .aera Ai ebods a tredamafo kr Aebod SystemI sncotaropr.de teDails fo teh softwacudorp erts sut deo crtaee this PDF file cna f ebi dnuon tlareneG eh Info leratit evo the file; tP ehDc-

9、Frtaeion marapterew setpo erimizde for irpnti.gn Evyre caer neeb sah taken to sneeru that the file is suitlbae fosu re yb ISO memdob rebeis. In tlnu ehikletneve y ttah lborp aem leratit gno it is f,dnuo plsaee inform ttneC ehlar Secrteiraat ta the serddaig sleb nevwo. ISO 3002 All irthgs erse.devr l

10、nUeto sswrehise specified, on trap fo this lbupictaion maeb y cudorperro de tuilizi den yna form ro na ybm ynae,s lecetrinoc ro mecinahcal, inclidung tohpcoiypodna gn micrfoilm, wittuoh repmissii non writign from ietI rehSa Ot tsserdda eh ebolw or ISOs memreb i ydobn the cnuotrfo y ttseuqer ehe.r IS

11、O cirypothg fofice saCe tsopale 65 eneG 1121-HC 02 av leT. 4 + 10 947 22 1 11 xaF0 947 22 14 + 9 74 E-mail coirypthgiso.o gr We bwww.is.o gro Pulbisdehi n Switlrez dnaii BSISO763:2003 iiiForeword ISO (the International Organization for Standardization) is a worldwide federation of national standards

12、 bodies (ISO member bodies). The work of preparing International Standards is normally carried out through ISO technical committees. Each member body interested in a subject for which a technical committee has been established has the right to be represented on that committee. International organiza

13、tions, governmental and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization. International Standards are drafted in accordance with the rules given in t

14、he ISO/IEC Directives, Part 2. The main task of technical committees is to prepare International Standards. Draft International Standards adopted by the technical committees are circulated to the member bodies for voting. Publication as an International Standard requires approval by at least 75 % of

15、 the member bodies casting a vote. Attention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. ISO shall not be held responsible for identifying any or all such patent rights. ISO 763 was prepared by Technical Committee ISO/TC 34, Food produc

16、ts, Subcommittee SC 3, Fruit and vegetable products. This second edition cancels and replaces the first edition (ISO 763:1982), which has been technically revised. BSISO763:2003INTENRATIONAL TSANDADR IS:367 O3002(E)1Fruit and vegetable products Determination of ash insoluble in hydrochloric acid 1 S

17、cope This International Standard specifies a method for the determination of the hydrochloric-acid-insoluble ash yielded by fruit and vegetable products. The method serves for the determination of siliceous impurities, together with the silica endogenous to the plant. NOTE A method for the determina

18、tion of mineral impurities generally originating from the soil is specified in ISO 762 1) . 2 Principle A test portion is incinerated at approximately 525 C and the mineral matter insoluble in dilute hydrochloric acid is separated. 3 Reagents Use only reagents of recognized analytical grade, unless

19、otherwise specified, and distilled or demineralized water or water of equivalent purity. 3.1 Hydrochloric acid, 10 % (by mass) solution. 3.2 Silver nitrate, approximately 17 g/l solution. 4 Apparatus Usual laboratory apparatus and, in particular, the following. 4.1 Blender. 4.2 Muffle furnace, capab

20、le of being maintained at 525 C 25 C. 4.3 Boiling water bath. 4.4 Drying oven, capable of being maintained at 103 C 2 C. 4.5 Desiccator, containing an efficient desiccant. 4.6 Incineration dishes, made of quartz or platinum. 1) ISO 762, Fruit and vegetable products Determination of mineral impuritie

21、s content. BSISO763:20032 4.7 Filter paper, ashless. 4.8 Analytical balance, capable of weighing to the nearest 0,000 2 g. 5 Sampling It is important that the laboratory receive a sample which is truly representative and has not been damaged or changed during transport or storage. 6 Preparation of t

22、est sample Allow frozen or deep-frozen products to thaw in a closed vessel and add the liquid formed during this process to the product before mixing. Before taking the test portion, thoroughly mix the laboratory sample using, if necessary, the blender (4.1). 7 Procedure 7.1 Preparation of first dis

23、h Heat an empty dish (4.6) in the furnace (4.2) set at the incineration temperature. Allow it to cool in the desiccator (4.5) then weigh to the nearest 0,000 2 g. Repeat until a constant mass is achieved. 7.2 Test portion Weigh, to the nearest 0,01 g, in the previously prepared dish (7.1), 4 g to 25

24、 g of the test sample (Clause 6) according to the water content of the product. For liquid products, the test portion may be taken by volume (see 8.2). 7.3 Determination 7.3.1 Drying Place the dish and its contents in the boiling water bath (4.3) and evaporate the water present in the product. Dry i

25、n the oven (4.4) set at 103 C. This drying is not necessary for dry products. 7.3.2 Incineration After drying (if appropriate), carbonize and then completely incinerate the product in the furnace (4.2) set at 525 C; the ash may still be grey after incineration. Pre-incineration at a distinctly lower

26、 temperature before placing in the furnace is sometimes necessary for products with a high sugar content in order to avoid foaming and subsequent loss of foam. For that purpose, slowly heat the dried sample on the hot plate until carbonization of the most of the organic matter. It is recommended to

27、decrease the salt content of products containing more than 2 % of sodium chloride by the following method. Pre-incinerate the sample then wash the carbonaceous residue several times with small amounts of hot distilled water. 7.3.3 Treatment with hydrochloric acid Allow the sample to cool in the desi

28、ccator (4.5). After cooling, add 10 ml to 25 ml of the hydrochloric acid solution (3.1). Cover with a watch-glass and heat in the boiling water bath (4.3) for 15 min 2 min. BSISO763:2003 3Transfer the residue to the ashless filter paper (4.7) placed in a funnel. Rinse the dish with hot water and tra

29、nsfer the contents of the dish to the filter paper. Wash the filter paper and its contents until there is no trace of chloride ions in the liquid flowing from the funnel test with the silver nitrate solution (3.2) . 7.3.4 Preparation of the second dish Prepare a new dish (4.6) as specified in 7.1 or

30、 clean the first dish. Heat it in the muffle furnace (4.2) to the incineration temperature. Allow it to cool in the desiccator then weigh to the nearest 0,000 2 g. Repeat until a constant mass is achieved. 7.3.5 Drying and incineration Place the filter paper and residue in the dish. Dry in the oven

31、(4.4) set at 103 C, then incinerate in the muffle furnace (4.2), set at 525 C, for 30 min 2 min. Cool in the desiccator (4.5), then weigh to the nearest 0,000 2 g. Repeat until a constant mass is achieved. 8 Expression of results 8.1 Method of calculation The ash insoluble in hydrochloric acid, w, e

32、xpressed as a percentage by mass, is given by the formula 23 01 100 % mm w mm = where m 0is the mass, in grams, of the dish and test portion (7.2); m 1is the mass, in grams, of the empty dish (7.1); m 2is the mass, in grams, of the dish and acid-insoluble ash (7.3.5); m 3is the mass, in grams, of th

33、e second empty dish (7.3.4). Report the results to two decimal places. 8.2 Other method of expression For liquid products, it is possible to express the result in grams per 100 ml of product, by taking the test portion (7.2) by volume and by replacing the denominator (m 0 m 1 ) in the equation (see

34、8.1) by V, the volume of the test portion. 9 Repeatability The absolute difference between two independent single test results, obtained using the same method on identical test material in the same laboratory by the same operator using the same equipment within a short interval of time, will in not

35、more than 5 % of cases be greater than 0,01 g of ash insoluble in hydrochloric acid per 100 g of sample. BSISO763:20034 10 Test report The test report shall specify: a) all information necessary for the complete identification of the sample; b) the sampling method used, if known; c) the test method

36、used, with reference to this International Standard; d) all operating details not specified in this International Standard, or regarded as optional, together with details of any incidents which may have influenced the test result(s); e) the test result(s) obtained or, if the repeatability has been c

37、hecked, the final quoted result obtained. BSISO763:2003BS ISO 763:2003 BSI 389 Chiswick High Road London W4 4AL BSI British Standards Institution BSI is the independent national body responsible for preparing British Standards. It presents the UK view on standards in Europe and at the international

38、level. It is incorporated by Royal Charter. Revisions British Standards are updated by amendment or revision. Users of British Standards should make sure that they possess the latest amendments or editions. It is the constant aim of BSI to improve the quality of our products and services. We would b

39、e grateful if anyone finding an inaccuracy or ambiguity while using this British Standard would inform the Secretary of the technical committee responsible, the identity of which can be found on the inside front cover. Tel: +44 (0)20 8996 9000. Fax: +44 (0)20 8996 7400. BSI offers members an individ

40、ual updating service called PLUS which ensures that subscribers automatically receive the latest editions of standards. Buying standards Orders for all BSI, international and foreign standards publications should be addressed to Customer Services. Tel: +44 (0)20 8996 9001. Fax: +44 (0)20 8996 7001.

41、Email: ordersbsi-. Standards are also available from the BSI website at http:/www.bsi-. In response to orders for international standards, it is BSI policy to supply the BSI implementation of those that have been published as British Standards, unless otherwise requested. Information on standards BS

42、I provides a wide range of information on national, European and international standards through its Library and its Technical Help to Exporters Service. Various BSI electronic information services are also available which give details on all its products and services. Contact the Information Centre

43、. Tel: +44 (0)20 8996 7111. Fax: +44 (0)20 8996 7048. Email: infobsi-. Subscribing members of BSI are kept up to date with standards developments and receive substantial discounts on the purchase price of standards. For details of these and other benefits contact Membership Administration. Tel: +44

44、(0)20 8996 7002. Fax: +44 (0)20 8996 7001. Email: membershipbsi-. Information regarding online access to British Standards via British Standards Online can be found at http:/www.bsi- Further information about BSI is available on the BSI website at http:/www.bsi-. Copyright Copyright subsists in all

45、BSI publications. BSI also holds the copyright, in the UK, of the publications of the international standardization bodies. Except as permitted under the Copyright, Designs and Patents Act 1988 no extract may be reproduced, stored in a retrieval system or transmitted in any form or by any means elec

46、tronic, photocopying, recording or otherwise without prior written permission from BSI. This does not preclude the free use, in the course of implementing the standard, of necessary details such as symbols, and size, type or grade designations. If these details are to be used for any other purpose than implementation then the prior written permission of BSI must be obtained. Details and advice can be obtained from the Copyright & Licensing Manager. Tel: +44 (0)20 8996 7070. Fax: +44 (0)20 8996 7553. Email: copyrightbsi-.