IEC TR 61912-1-2007 Low-voltage switchgear and controlgear - Overcurrent protective devices - Part 1 Application of short-circuit ratings《低压开关装置和控制装置.过电流保护装置.第1部分 短路额定值的应用》.pdf

《IEC TR 61912-1-2007 Low-voltage switchgear and controlgear - Overcurrent protective devices - Part 1 Application of short-circuit ratings《低压开关装置和控制装置.过电流保护装置.第1部分 短路额定值的应用》.pdf》由会员分享，可在线阅读，更多相关《IEC TR 61912-1-2007 Low-voltage switchgear and controlgear - Overcurrent protective devices - Part 1 Application of short-circuit ratings《低压开关装置和控制装置.过电流保护装置.第1部分 短路额定值的应用》.pdf（48页珍藏版）》请在麦多课文档分享上搜索。

1、 IEC/TR 61912-1Edition 1.0 2007-08TECHNICAL REPORT RAPPORT TECHNIQUELow-voltage switchgear and controlgear Overcurrent protective devices Part 1: Application of short-circuit ratings Appareillage basse tension Dispositifs de protection contre les surintensits Partie 1: Application des caractristique

2、s de court-circuit IEC/TR61912-1:2007 THIS PUBLICATION IS COPYRIGHT PROTECTED Copyright 2007 IEC, Geneva, Switzerland All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic or mechanical, including photocopyi

3、ng and microfilm, without permission in writing from either IEC or IECs member National Committee in the country of the requester. If you have any questions about IEC copyright or have an enquiry about obtaining additional rights to this publication, please contact the address below or your local IE

4、C member National Committee for further information. Droits de reproduction rservs. Sauf indication contraire, aucune partie de cette publication ne peut tre reproduite ni utilise sous quelque forme que ce soit et par aucun procd, lectronique ou mcanique, y compris la photocopie et les microfilms, s

5、ans laccord crit de la CEI ou du Comit national de la CEI du pays du demandeur. Si vous avez des questions sur le copyright de la CEI ou si vous dsirez obtenir des droits supplmentaires sur cette publication, utilisez les coordonnes ci-aprs ou contactez le Comit national de la CEI de votre pays de r

6、sidence. IEC Central Office 3, rue de Varemb CH-1211 Geneva 20 Switzerland Email: inmailiec.ch Web: www.iec.ch About the IEC The International Electrotechnical Commission (IEC) is the leading global organization that prepares and publishes International Standards for all electrical, electronic and r

7、elated technologies. About IEC publications The technical content of IEC publications is kept under constant review by the IEC. Please make sure that you have the latest edition, a corrigenda or an amendment might have been published. Catalogue of IEC publications: www.iec.ch/searchpub The IEC on-li

8、ne Catalogue enables you to search by a variety of criteria (reference number, text, technical committee,). It also gives information on projects, withdrawn and replaced publications. IEC Just Published: www.iec.ch/online_news/justpub Stay up to date on all new IEC publications. Just Published detai

9、ls twice a month all new publications released. Available on-line and also by email. Electropedia: www.electropedia.org The worlds leading online dictionary of electronic and electrical terms containing more than 20 000 terms and definitions in English and French, with equivalent terms in additional

10、 languages. Also known as the International Electrotechnical Vocabulary online. Customer Service Centre: www.iec.ch/webstore/custserv If you wish to give us your feedback on this publication or need further assistance, please visit the Customer Service Centre FAQ or contact us: Email: csciec.ch Tel.

11、: +41 22 919 02 11 Fax: +41 22 919 03 00 A propos de la CEI La Commission Electrotechnique Internationale (CEI) est la premire organisation mondiale qui labore et publie des normes internationales pour tout ce qui a trait llectricit, llectronique et aux technologies apparentes. A propos des publicat

12、ions CEI Le contenu technique des publications de la CEI est constamment revu. Veuillez vous assurer que vous possdez ldition la plus rcente, un corrigendum ou amendement peut avoir t publi. Catalogue des publications de la CEI: www.iec.ch/searchpub/cur_fut-f.htm Le Catalogue en-ligne de la CEI vous

13、 permet deffectuer des recherches en utilisant diffrents critres (numro de rfrence, texte, comit dtudes,). Il donne aussi des informations sur les projets et les publications retires ou remplaces. Just Published CEI: www.iec.ch/online_news/justpub Restez inform sur les nouvelles publications de la C

14、EI. Just Published dtaille deux fois par mois les nouvelles publications parues. Disponible en-ligne et aussi par email. Electropedia: www.electropedia.org Le premier dictionnaire en ligne au monde de termes lectroniques et lectriques. Il contient plus de 20 000 termes et dfinitions en anglais et en

15、 franais, ainsi que les termes quivalents dans les langues additionnelles. Egalement appel Vocabulaire Electrotechnique International en ligne. Service Clients: www.iec.ch/webstore/custserv/custserv_entry-f.htm Si vous dsirez nous donner des commentaires sur cette publication ou si vous avez des que

16、stions, visitez le FAQ du Service clients ou contactez-nous: Email: csciec.ch Tl.: +41 22 919 02 11 Fax: +41 22 919 03 00 IEC/TR 61912-1Edition 1.0 2007-08TECHNICAL REPORT RAPPORT TECHNIQUELow-voltage switchgear and controlgear Overcurrent protective devices Part 1: Application of short-circuit rati

17、ngs Appareillage basse tension Dispositifs de protection contre les surintensits Partie 1: Application des caractristiques de court-circuit INTERNATIONAL ELECTROTECHNICAL COMMISSION COMMISSION ELECTROTECHNIQUE INTERNATIONALE SICS 29.130 PRICE CODECODE PRIXISBN 2-8318-9273-2 2 TR 61912-1 IEC:2007 CON

18、TENTS FOREWORD.4 INTRODUCTION.6 1 Scope.7 2 Normative references .7 3 Alphabetical list of definitions and characteristics .8 4 Principle of application Installation 9 5 Characteristics Low-voltage assemblies (switchboard, distribution board, etc.)9 6 Characteristics Switching devices10 6.1 General

19、.10 6.2 Switching devices Self-protection against short-circuit10 6.3 Switching devices Application as SCPD11 6.3.1 Fuse-combination units and fuses as SCPD 11 6.3.2 Circuit-breakers to IEC 60947-2 as SCPD .11 6.3.3 Control and protective switching devices (CPS) according to IEC 60947-6-2 as SCPD12

20、6.3.4 Circuit-breakers according to IEC 60898-1 (MCBs) and residual current operated circuit-breaker with integral overcurrent protection (RCBOs) according to IEC 61009-1 as SCPD 12 7 Examples of the practical application of the product characteristics13 7.1 General .13 7.2 Protection of cables.13 7

21、.3 Short-circuit protection for LV assemblies13 7.3.1 Switchgear and controlgear assemblies (switchboard/motor-control centre (MCC)13 7.3.2 Busbar trunking systems (BTS) .13 7.4 Short-circuit protection for contactors and starters 14 7.4.1 General .14 7.4.2 Protected switching device and protected s

22、tarter .14 7.4.3 Control and protective switching device (CPS) according to IEC 60947-6-2 .15 7.5 Short-circuit protection using circuit-breakers for household and similar installations according to IEC 60898-1 (usually known as MCBs) and residual current operated circuit-breakers with integral over

23、current protection (RCBOs) according to IEC 61009-1 .15 Annex A (informative) Interpolation of the suitability of an alternative SCPD for the protection of contactors and starters (substitution)21 Bibliography22 Figure 1 Example of the I2t characteristic of a fuse17 Figure 2 Example of the I2t chara

24、cteristic of a circuit-breaker 17 Figure 3 Example of SCPDs in combination .18 Figure 4 Example of the derivation of a conditional rating from type-test parameters .19 Figure 5a Co-ordination of a motor-starter with a fuse20 TR 61912-1 IEC:2007 3 Figure 5b Co-ordination of a motor-starter with circu

25、it-breaker.20 Figure 5 Illustration of co-ordination between motor-starter and SCPD.20 Table 1 Ratio k between service short-circuit capacity (Ics) and rated short-circuit capacity (Icn) for an MCB according to IEC 60898-1 .16 Table 2 Value of the prospective test current according to the rated oper

26、ational current16 4 TR 61912-1 IEC:2007 INTERNATIONAL ELECTROTECHNICAL COMMISSION _ LOW-VOLTAGE SWITCHGEAR AND CONTROLGEAR OVERCURRENT PROTECTIVE DEVICES Part 1: Application of short-circuit ratings FOREWORD 1) The International Electrotechnical Commission (IEC) is a worldwide organization for stand

27、ardization comprising all national electrotechnical committees (IEC National Committees). The object of IEC is to promote international co-operation on all questions concerning standardization in the electrical and electronic fields. To this end and in addition to other activities, IEC publishes Int

28、ernational Standards, Technical Specifications, Technical Reports, Publicly Available Specifications (PAS) and Guides (hereafter referred to as “IEC Publication(s)”). Their preparation is entrusted to technical committees; any IEC National Committee interested in the subject dealt with may participa

29、te in this preparatory work. International, governmental and non-governmental organizations liaising with the IEC also participate in this preparation. IEC collaborates closely with the International Organization for Standardization (ISO) in accordance with conditions determined by agreement between

30、 the two organizations. 2) The formal decisions or agreements of IEC on technical matters express, as nearly as possible, an international consensus of opinion on the relevant subjects since each technical committee has representation from all interested IEC National Committees. 3) IEC Publications

31、have the form of recommendations for international use and are accepted by IEC National Committees in that sense. While all reasonable efforts are made to ensure that the technical content of IEC Publications is accurate, IEC cannot be held responsible for the way in which they are used or for any m

32、isinterpretation by any end user. 4) In order to promote international uniformity, IEC National Committees undertake to apply IEC Publications transparently to the maximum extent possible in their national and regional publications. Any divergence between any IEC Publication and the corresponding na

33、tional or regional publication shall be clearly indicated in the latter. 5) IEC provides no marking procedure to indicate its approval and cannot be rendered responsible for any equipment declared to be in conformity with an IEC Publication. 6) All users should ensure that they have the latest editi

34、on of this publication. 7) No liability shall attach to IEC or its directors, employees, servants or agents including individual experts and members of its technical committees and IEC National Committees for any personal injury, property damage or other damage of any nature whatsoever, whether dire

35、ct or indirect, or for costs (including legal fees) and expenses arising out of the publication, use of, or reliance upon, this IEC Publication or any other IEC Publications. 8) Attention is drawn to the Normative references cited in this publication. Use of the referenced publications is indispensa

36、ble for the correct application of this publication. 9) Attention is drawn to the possibility that some of the elements of this IEC Publication may be the subject of patent rights. IEC shall not be held responsible for identifying any or all such patent rights. The main task of IEC technical committ

37、ees is to prepare International Standards. However, a technical committee may propose the publication of a technical report when it has collected data of a different kind from that which is normally published as an International Standard, for example “state of the art“. IEC 61912-1, which is a techn

38、ical report, has been prepared by subcommittee 17B: Low-voltage switchgear and controlgear, of IEC technical committee 17: Switchgear and controlgear. This edition cancels and replaces the first edition of IEC 61912, published in 2006, and corrigendum 1 (May 2006). The changes are only editorial. TR

39、 61912-1 IEC:2007 5 The text of this technical report is based on the following documents: Enquiry draft Report on voting 17B/1547/DTR 17B/1564/RVC Full information on the voting for the approval of this technical report can be found in the report on voting indicated in the above table. This publica

40、tion has been drafted in accordance with the ISO/IEC Directives, Part 2. A list of all the parts of the IEC 61912 series, under the general title Low-voltage switchgear and controlgear Overcurrent protective devices, can be found on the IEC website. The committee has decided that the contents of thi

41、s publication will remain unchanged until the maintenance result date indicated on the IEC web site under “http:/webstore.iec.ch“ in the data related to the specific publication. At this date, the publication will be reconfirmed, withdrawn, replaced by a revised edition, or amended. 6 TR 61912-1 IEC

42、:2007 INTRODUCTION Low-voltage equipment standards IEC 60947 and IEC 60439 currently include short-circuit ratings for products and assemblies respectively, defined in terms of the ability of the equipment to operate at a level of peak current, an r.m.s. current for a specified time and/or a level o

43、f current conditional upon a short-circuit protective device in series. In practice the correct application of the various short-circuit ratings needs to be fully understood by the circuit designer to avoid leaving a circuit or equipment with inadequate short-circuit protection. It is also useful to

44、 take full advantage of the capability of devices and systems to avoid over-engineering, with the consequent unnecessary additional cost. TR 61912-1 IEC:2007 7 LOW-VOLTAGE SWITCHGEAR AND CONTROLGEAR OVERCURRENT PROTECTIVE DEVICES Part 1: Application of short-circuit ratings 1 Scope This technical re

45、port, which serves as an application guide for the short-circuit ratings given in IEC standards for low-voltage switchgear and controlgear and assemblies, summarises the definitions of the ratings and provides examples of their application. NOTE This document does not concern itself with household (

46、domestic) installations. 2 Normative references The following referenced documents are indispensable for the application of this document. For dated references, only the edition cited applies. For undated references, the latest edition of the referenced document (including any amendments) applies. I

47、EC 60255 (all parts), Electrical relays IEC 60269-1, Low-voltage fuses Part 1: General requirements IEC 60364 (all parts), Low-voltage electrical installations IEC 60439-1, Low-voltage switchgear and controlgear assemblies Part 1: Type-tested and partially type-tested assemblies IEC 60439-2, Low-vol

48、tage switchgear and controlgear assemblies Part 2: Particular requirements for busbar trunking systems (busways) IEC 60898-1, Electrical accessories Circuit-breakers for overcurrent protection for household and similar installations Part 1: Circuit-breakers for a.c. operation IEC 60947-1, Low-voltag

49、e switchgear and controlgear Part 1: General rules IEC 60947-2, Low-voltage switchgear and controlgear Part 2: Circuit-breakers IEC 60947-3, Low-voltage switchgear and controlgear Part 3: Switches, disconnectors, switch-disconnectors and fuse-combination units IEC 60947-4-1, Low-voltage switchgear and controlgear Part 4-1: Contactors and motor-starters Electromechanical