IEC 60335-2-21-2012 Household and similar electrical appliances - Safety - Part 2-21 Particular requirements for storage water heaters《家用和类似用途电器.安全性.第2-21部分 贮水式热水器的详细要求》.pdf

《IEC 60335-2-21-2012 Household and similar electrical appliances - Safety - Part 2-21 Particular requirements for storage water heaters《家用和类似用途电器.安全性.第2-21部分 贮水式热水器的详细要求》.pdf》由会员分享，可在线阅读，更多相关《IEC 60335-2-21-2012 Household and similar electrical appliances - Safety - Part 2-21 Particular requirements for storage water heaters《家用和类似用途电器.安全性.第2-21部分 贮水式热水器的详细要求》.pdf（58页珍藏版）》请在麦多课文档分享上搜索。

1、 IEC 60335-2-21 Edition 6.0 2012-11 INTERNATIONAL STANDARD NORME INTERNATIONALE Household and similar electrical appliances Safety Part 2-21: Particular requirements for storage water heaters Appareils lectrodomestiques et analogues Scurit Partie 2-21: Rgles particulires pour les chauffe-eau accumul

2、ation IEC60335-2-21:2012 THIS PUBLICATION IS COPYRIGHT PROTECTED Copyright 2012 IEC, Geneva, Switzerland All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic or mechanical, including photocopying and microf

3、ilm, without permission in writing from either IEC or IECs member National Committee in the country of the requester. If you have any questions about IEC copyright or have an enquiry about obtaining additional rights to this publication, please contact the address below or your local IEC member Nati

4、onal Committee for further information. Droits de reproduction rservs. Sauf indication contraire, aucune partie de cette publication ne peut tre reproduite ni utilise sous quelque forme que ce soit et par aucun procd, lectronique ou mcanique, y compris la photocopie et les microfilms, sans laccord c

5、rit de la CEI ou du Comit national de la CEI du pays du demandeur. Si vous avez des questions sur le copyright de la CEI ou si vous dsirez obtenir des droits supplmentaires sur cette publication, utilisez les coordonnes ci-aprs ou contactez le Comit national de la CEI de votre pays de rsidence. IEC

6、Central Office Tel.: +41 22 919 02 11 3, rue de Varemb Fax: +41 22 919 03 00 CH-1211 Geneva 20 infoiec.ch Switzerland www.iec.ch About the IEC The International Electrotechnical Commission (IEC) is the leading global organization that prepares and publishes International Standards for all electrical

7、, electronic and related technologies. About IEC publications The technical content of IEC publications is kept under constant review by the IEC. Please make sure that you have the latest edition, a corrigenda or an amendment might have been published. Useful links: IEC publications search - www.iec

8、.ch/searchpub The advanced search enables you to find IEC publications by a variety of criteria (reference number, text, technical committee,). It also gives information on projects, replaced and withdrawn publications. IEC Just Published - webstore.iec.ch/justpublished Stay up to date on all new IE

9、C publications. Just Published details all new publications released. Available on-line and also once a month by email. Electropedia - www.electropedia.org The worlds leading online dictionary of electronic and electrical terms containing more than 30 000 terms and definitions in English and French,

10、 with equivalent terms in additional languages. Also known as the International Electrotechnical Vocabulary (IEV) on-line. Customer Service Centre - webstore.iec.ch/csc If you wish to give us your feedback on this publication or need further assistance, please contact the Customer Service Centre: cs

11、ciec.ch. A propos de la CEI La Commission Electrotechnique Internationale (CEI) est la premire organisation mondiale qui labore et publie des Normes internationales pour tout ce qui a trait llectricit, llectronique et aux technologies apparentes. A propos des publications CEI Le contenu technique de

12、s publications de la CEI est constamment revu. Veuillez vous assurer que vous possdez ldition la plus rcente, un corrigendum ou amendement peut avoir t publi. Liens utiles: Recherche de publications CEI - www.iec.ch/searchpub La recherche avance vous permet de trouver des publications CEI en utilisa

13、nt diffrents critres (numro de rfrence, texte, comit dtudes,). Elle donne aussi des informations sur les projets et les publications remplaces ou retires. Just Published CEI - webstore.iec.ch/justpublished Restez inform sur les nouvelles publications de la CEI. Just Published dtaille les nouvelles p

14、ublications parues. Disponible en ligne et aussi une fois par mois par email. Electropedia - www.electropedia.org Le premier dictionnaire en ligne au monde de termes lectroniques et lectriques. Il contient plus de 30 000 termes et dfinitions en anglais et en franais, ainsi que les termes quivalents

15、dans les langues additionnelles. Egalement appel Vocabulaire Electrotechnique International (VEI) en ligne. Service Clients - webstore.iec.ch/csc Si vous dsirez nous donner des commentaires sur cette publication ou si vous avez des questions contactez-nous: csciec.ch. IEC 60335-2-21 Edition 6.0 2012

16、-11 INTERNATIONAL STANDARD NORME INTERNATIONALE Household and similar electrical appliances Safety Part 2-21: Particular requirements for storage water heaters Appareils lectrodomestiques et analogues Scurit Partie 2-21: Rgles particulires pour les chauffe-eau accumulation INTERNATIONAL ELECTROTECHN

17、ICAL COMMISSION COMMISSION ELECTROTECHNIQUE INTERNATIONALE U ICS 13.120; 91.140.65 PRICE CODE CODE PRIX ISBN 978-2-83220-452-8 Registered trademark of the International Electrotechnical Commission Marque dpose de la Commission Electrotechnique Internationale Warning! Make sure that you obtained this

18、 publication from an authorized distributor. Attention! Veuillez vous assurer que vous avez obtenu cette publication via un distributeur agr. 2 60335-2-21 IEC:2012 CONTENTS FOREWORD . 4 INTRODUCTION . 7 1 Scope . 8 2 Normative references . 9 3 Terms and definitions . 9 4 General requirement . 10 5 G

19、eneral conditions for the tests 10 6 Classification 10 7 Marking and instructions . 10 8 Protection against access to live parts 12 9 Starting of motor-operated appliances 12 10 Power input and current 12 11 Heating. 12 12 Void 12 13 Leakage current and electric strength at operating temperature 12

20、14 Transient overvoltages . 12 15 Moisture resistance 12 16 Leakage current and electric strength . 12 17 Overload protection of transformers and associated circuits . 13 18 Endurance 13 19 Abnormal operation 13 20 Stability and mechanical hazards 14 21 Mechanical strength . 14 22 Construction . 14

21、23 Internal wiring . 16 24 Components . 16 25 Supply connection and external flexible cords 18 26 Terminals for external conductors . 18 27 Provision for earthing . 18 28 Screws and connections . 18 29 Clearances, creepage distances and solid insulation 18 30 Resistance to heat and fire . 18 31 Resi

22、stance to rusting 19 32 Radiation, toxicity and similar hazards 19 Annexes . 22 Annex A (informative) Routine tests . 22 Annex R (normative) Software evaluation 23 Annex AA (normative) Additional requirement for immersion heater units intended for the installation in heat exchange closed water heate

23、rs 24 Bibliography 27 60335-2-21 IEC:2012 3 Figure 101 Examples of types of storage water heaters . 20 Figure 102 Example of positions of the thermocouples . 21 4 60335-2-21 IEC:2012 INTERNATIONAL ELECTROTECHNICAL COMMISSION _ HOUSEHOLD AND SIMILAR ELECTRICAL APPLIANCES SAFETY Part 2-21: Particular

24、requirements for storage water heaters FOREWORD 1) The International Electrotechnical Commission (IEC) is a worldwide organization for standardization comprising all national electrotechnical committees (IEC National Committees). The object of IEC is to promote international co-operation on all ques

25、tions concerning standardization in the electrical and electronic fields. To this end and in addition to other activities, IEC publishes International Standards, Technical Specifications, Technical Reports, Publicly Available Specifications (PAS) and Guides (hereafter referred to as “IEC Publication

26、(s)”). Their preparation is entrusted to technical committees; any IEC National Committee interested in the subject dealt with may participate in this preparatory work. International, governmental and non-governmental organizations liaising with the IEC also participate in this preparation. IEC coll

27、aborates closely with the International Organization for Standardization (ISO) in accordance with conditions determined by agreement between the two organizations. 2) The formal decisions or agreements of IEC on technical matters express, as nearly as possible, an international consensus of opinion

28、on the relevant subjects since each technical committee has representation from all interested IEC National Committees. 3) IEC Publications have the form of recommendations for international use and are accepted by IEC National Committees in that sense. While all reasonable efforts are made to ensur

29、e that the technical content of IEC Publications is accurate, IEC cannot be held responsible for the way in which they are used or for any misinterpretation by any end user. 4) In order to promote international uniformity, IEC National Committees undertake to apply IEC Publications transparently to

30、the maximum extent possible in their national and regional publications. Any divergence between any IEC Publication and the corresponding national or regional publication shall be clearly indicated in the latter. 5) IEC itself does not provide any attestation of conformity. Independent certification

31、 bodies provide conformity assessment services and, in some areas, access to IEC marks of conformity. IEC is not responsible for any services carried out by independent certification bodies. 6) All users should ensure that they have the latest edition of this publication. 7) No liability shall attac

32、h to IEC or its directors, employees, servants or agents including individual experts and members of its technical committees and IEC National Committees for any personal injury, property damage or other damage of any nature whatsoever, whether direct or indirect, or for costs (including legal fees)

33、 and expenses arising out of the publication, use of, or reliance upon, this IEC Publication or any other IEC Publications. 8) Attention is drawn to the Normative references cited in this publication. Use of the referenced publications is indispensable for the correct application of this publication

34、. 9) Attention is drawn to the possibility that some of the elements of this IEC Publication may be the subject of patent rights. IEC shall not be held responsible for identifying any or all such patent rights. This part of International Standard IEC 60335 has been prepared by IEC technical committe

35、e 61: Safety of household and similar electrical appliances. This sixth edition cancels and replaces the fifth edition published in 2002 including its Amendment 1 (2004) and its Amendment 2 (2008). It constitutes a technical revision. The principal changes in this edition as compared with the fifth

36、edition of IEC 60335-2-21 are as follows (minor changes are not listed): added requirements for immersion heater units (fixed immersion heaters); removed reference to ISO 13732-1 from Bibliography. 60335-2-21 IEC:2012 5 The text of this standard is based on the following documents: FDIS Report on vo

37、ting 61/4452/FDIS 61/4505/RVD Full information on the voting for the approval of this standard can be found in the report on voting indicated in the above table. This publication has been drafted in accordance with the ISO/IEC Directives, Part 2. This part 2 is to be used in conjunction with the lat

38、est edition of IEC 60335-1 and its amendments. It was established on the basis of the fifth edition (2010) of that standard. NOTE 1 When “Part 1” is mentioned in this standard, it refers to IEC 60335-1. This part 2 supplements or modifies the corresponding clauses in IEC 60335-1, so as to convert th

39、at publication into the IEC standard: Safety requirements for storage water heaters. When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies as far as is reasonable. When this standard states “addition”, “modification” or “replacement”, the relevant text in Part

40、 1 is to be adapted accordingly. NOTE 2 The following numbering system is used: subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1; unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including those i

41、n a replaced clause or subclause; additional annexes are lettered AA, BB, etc. NOTE 3 The following print types are used: requirements: in roman type; test specifications: in italic type; notes: in small roman type. Words in bold in the text are defined in Clause 3. When a definition concerns an adj

42、ective, the adjective and the associated noun are also in bold. The committee has decided that the contents of this publication will remain unchanged until the stability date indicated on the IEC web site under “http:/webstore.iec.ch“ in the data related to the specific publication. At this date, th

43、e publication will be reconfirmed, withdrawn, replaced by a revised edition, or amended. NOTE 4 The attention of National Committees is drawn to the fact that equipment manufacturers and testing organizations may need a transitional period following publication of a new, amended or revised IEC publi

44、cation in which to make products in accordance with the new requirements and to equip themselves for conducting new or revised tests. It is the recommendation of the committee that the content of this publication be adopted for implementation nationally not earlier than 12 months or later than 36 mo

45、nths from the date of publication. A list of all parts of the IEC 60335 series, under the general title: Household and similar electrical appliances Safety, can be found on the IEC website. The following differences exist in the countries indicated below. 6.1: Class 0I appliances are allowed (Japan)

46、. 6 60335-2-21 IEC:2012 6.2: IPX0 water heaters are allowed (France, United Kingdom and USA). 7.1: Additional markings are required (Australia, New Zealand and South Africa). 7.1: The rated pressure is to be marked in pounds per square inch (USA). 7.1: Open outlet water heaters are not required to b

47、e marked with rated pressure (USA). 7.12.1: Additional instructions are required (South Africa). 11.7: The test is different (USA). 13.2: An additional leakage current test is required (China). 19.1: Appliances incorporating sheathed heating elements are not required to have an outer enclosure of me

48、tal but their rated power input is limited to 12 kW (USA). 19.101: The test is different (USA). 22.47: The minimum pressure is 2,1 MPa. The test is not carried out on water heaters having a capacity less than 2 l or on appliances having containers open to the atmosphere (USA). 22.101: Pressure reduc

49、ing valves have to be designed for an inlet pressure of 2 MPa (South Africa). 22.102: The temperature limit is 95 C (South Africa). 22.102: The temperature limit is 85 C (USA). 22.101: The minimum rated pressure is 1,0 MPa (Denmark, Finland, Norway and Sweden). 22.103: Closed water heaters having a capacity exceeding 50 l or a rated power input exceeding 2 kW have to incorporate a