NAVY MIL-HDBK-2036-1999 PREPARATION OF ELECTRONIC EQUIPMENT SPECIFICATIONS《电子设备详细说明准备》.pdf

《NAVY MIL-HDBK-2036-1999 PREPARATION OF ELECTRONIC EQUIPMENT SPECIFICATIONS《电子设备详细说明准备》.pdf》由会员分享，可在线阅读，更多相关《NAVY MIL-HDBK-2036-1999 PREPARATION OF ELECTRONIC EQUIPMENT SPECIFICATIONS《电子设备详细说明准备》.pdf（157页珍藏版）》请在麦多课文档分享上搜索。

1、METRICMIL-HDBK-20361 November 1999SUPERSEDINGMIL-STD-2036A3 September 1993DEPARTMENT OF DEFENSEHANDBOOKPREPARATION OFELECTRONIC EQUIPMENT SPECIFICATIONSAMSC N/A AREA GDRQThis handbook is for guidance only. Do not cite this document as a requirement.DISTRIBUTION STATEMENT A. Approved for public relea

2、se; distribution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-2036iFOREWORD1. This handbook provides guidance to specifiers and the acquisition community for thedevelopment of requirements for end-item specifications and com

3、mercial itemdescriptions. This handbook also provides quidance for the evaluation of commercial-off-the-shelf (COTS) equipment and nondevelopmental items (NDI) as to their suitabilityfor use in military environments.2. This handbook is for guidance only. This handbook cannot be cited as arequirement

4、. If it is, the contractor does not have to comply.3. This document incorporates the guidelines of the Acquisition Reforms, as outlined inthe Process Action Team (PAT) on Military Specifications and Standards report,“Blueprint for Change,“ of April 94; SECDEF memorandum, “Specifications andStandards

5、 - a New Way of Doing Business,“ of 29 June 1994; and OASN (RD Hubble; mission critical equipmentClass II High Global positioning systems; permanent C4I systemsClass III Medium Temporary C4I systemsClass IV Low Academic experimentsRUGGEDIZED MILITARIZED- ACCEPTABLE FOR APPLICATIONTailorFULLYHARDENED

6、MINIMALACCEPTANCELOWESTAVAILABLECOMMERCIALOFF-THESHELF (COTS)ENVIRONMENTEQUIPMENTTOLERANCEProvided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-203631.7 System classification (mobile). Requirements should apply to electronic equipment mounted in/o

7、n vehicles, and equipment normally transported in/onvehicles for use at a remote site. Equipment should be classified as portable ornon-portable, mission critical or nonmission critical, mounted interior or exterior tothe vehicle, on-road or off-road, and nuclear hardened or non-nuclear hardened(see

8、 4.1.3.3). Mobile equipment which is mounted under canvas or other non-rigidmaterial should be considered to be exterior mounted.1.8 System classification (land-based). Equipment should be classified as mission critical or nonmission critical, sheltered or unsheltered, and nuclear hardened ornon-nuc

9、lear hardened (see 4.1.3.4).Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-203642. APPLICABLE DOCUMENTS.2.1 General. The documents listed below are not necessarily all of the documents referenced herein but are the ones that are needed in o

10、rder to fullyunderstand the information provided by this handbook.2.2 Government documents. 2.2.1 Specifications, standards, and handbooks. The following specifications,standards, and handbooks form a part of this document to the extent specified herein.Unless otherwise specified, the issues of thes

11、e documents are those listed in the latestissue of the Department of Defense Index of Specifications and Standards (DODISS),and supplement thereto.SPECIFICATIONSDEPARTMENT OF DEFENSEMIL-S-901 Shock Tests, H.I. (High-Impact) Shipboard Machinery,Equipment, and Systems, Requirements for.MIL-S-1222 Stud

12、s, Bolts, Hex Cap Screws, Socket Head Cap Screwsand Nuts.STANDARDSDEPARTMENT OF DEFENSEMIL-STD-167-1 Mechanical Vibrations of Shipboard Equipment(Type I - Environmental and Type II - InternallyExcited).MIL-STD-210 Climatic Information to Determine Design and TestRequirements for Military Systems and

13、 Equipment.MIL-STD-461 Requirements for the Control of ElectromagneticInterference Emissions and Susceptibility.MIL-STD-462 Measurement of Electromagnetic InterferenceCharacteristics.MIL-STD-464 Electromagnetic Environmental EffectsRequirements for Systems.MIL-STD-469 Radar Engineering Design Requir

14、ements,Electromagnetic Compatibility.MIL-STD-740-2 Structureborne Vibratory AccelerationMeasurements and Acceptance Criteria ofShipboard Equipment.MIL-STD-810 Environmental Test Methods and EngineeringGuidelines.Provided by IHSNot for ResaleNo reproduction or networking permitted without license fro

15、m IHS-,-,-MIL-HDBK-20365MIL-STD-961 Defense Specification Practices.MIL-STD-1275 Characteristics of 28 Volt DCElectrical Systems in Military Vehicles.DOD-STD-1399, Section 071 Interface Standard for ShipboardSystems, Mass/Size/Shape, ShipboardUnits. (Metric)MIL-STD-1399, Section 072.1 Interface Stan

16、dard for ShipboardSystems, Blast Environment, MissileExhaust.MIL-STD-1399, Section 072.2 Interface Standard for ShipboardSystems, Blast Environment, GunMuzzle.MIL-STD-1399, Section 102 Interface Standard for ShipboardSystems, Low Pressure Dry Air Servicefor Surface Ships.MIL-STD-1399, Section 105 In

17、terface Standard for ShipboardSystems, Sea Water Service forSurface Ships.MIL-STD-1399, Section 106 Interface Standard for ShipboardSystems, Compressed Air Service forSurface Ships.MIL-STD-1399, Section 300 Interface Standard for ShipboardSystems, Electric Power, AlternatingCurrent. (Metric)DOD-STD-

18、1399, Section 301 Interface Standard for ShipboardSystems, Ship Motion and Attitude.(Metric)MIL-STD-1399, Section 390 Interface Standard for ShipboardSystems, Electric Power, DirectCurrent, (Other Than Ships Battery)for Submarines. (Metric)DOD-STD-1399, Section 532 Interface Standard for ShipboardSy

19、stems, Cooling Water for Support ofElectronic Equipment. (Metric)MIL-STD-1425 Safety Design Requirements forMilitary Lasers and AssociatedSupport Equipment.MIL-STD-1539 Electrical Power, Direct Current, SpaceVehicle Design Requirements.MIL-STD-1540 Test Requirements for Space VehiclesMIL-STD-1541 El

20、ectromagnetic CompatibilityRequirements for Space Systems.MIL-STD-1809 Space Environment for USAFSpace Vehicles.Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-20366DOD-STD-2143 Magnetic Silencing Requirements for theConstruction of Nonmagne

21、tic Ships and Craft.(Metric)HANDBOOKSDEPARTMENT OF DEFENSEMIL-HDBK-235-1 Electromagnetic (Radiated) EnvironmentConsiderations for Design and Procurement ofElectrical and Electronic Equipment, Subsystemsand Systems.MIL-HDBK-235-2 Electromagnetic Radiation Environment FromFriendly or Own Force Emitter

22、s. (limiteddistribution)MIL-HDBK-235-3 Electromagnetic Radiation Environment FromHostile Force Emitters. (limited distribution)MIL-HDBK-235-4 Electromagnetic Radiation Environment, ArmyInstallations.(Unless otherwise indicated, copies of the above specifications, standards, andhandbooks are availabl

23、e from the Standardization Documents Order Desk, Building 4D,700 Robbins Avenue, Philadelphia, PA 19111-5094.)2.2.2 Other Government documents, drawings, and publications. The following other documents, drawings, and publications form a part of this document to the extentspecified herein. Unless oth

24、erwise specified, the issues of these documents should bethose listed in the issue of the DODISS, and supplement thereto, cited in the solicitation.Unless otherwise specified, the issues of documents not listed in the DODISS should bethose in effect on the date of the solicitation.PUBLICATIONSASSIST

25、ANT SECRETARY OF DEFENSESD-2 Nondevelopmental Item Program, Buying NDI.SD-14 Listings of Toxic Chemicals, Hazardous Substances,and Ozone Depleting Chemicals.(Application for copies should be addressed to Standardization Documents OrderDesk, Building 4D, 700 Robbins Avenue, Philadelphia, PA 19111-509

26、4.)Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-20367DEPARTMENT OF COMMERCE (DOC)NTIA Manual of Regulation Manual of Regulations and Proceduresfor Federal Radio FrequencyManagement.(Application for copies should be addressed to United Sta

27、tes Department ofCommerce, National Telecommunications and Information Administration, Washington,DC 20230.)FEDERAL REGULATIONS21 CFR 1040 Code of Federal Regulations, Title 21, Chapter I(Food and Drug Administration, Department ofHealth and Human Services), Part 1040.(Performance Standard for Light

28、 Emitting Products)29 CFR 1910 Code of Federal Regulations, Title 29, Chapter XVII(Occupational Safety and Health Administration,Department of Labor), Part 1910 (OccupationalSafety and Health Standards).47 CFR 15 Code of Federal Regulations, Title 47, Chapter I(Federal Communications Commission), Pa

29、rt 15(Radio Frequency Devices).40 CFR Chapter I Code of Federal Regulations, Title 40, Chapter I(Environmental Protection Agency).(The Code of Federal Regulations (CFR) and the Federal Register (FR) are forsale on a subscription basis by the Superintendent of Documents, U.S. GovernmentPrinting Offic

30、e, Washington, DC 20402. When indicated, reprints of certain regulationsmay be obtained from the Federal agency responsible for issuance thereof.)GENERAL SERVICES ADMINISTRATION (GSA)NAVSO P-6071 Best Practices.(Application for copies should be addressed to the Superintendent of Documents,U.S. Gover

31、nment Printing Office, Washington, DC 20402.)JOINT CHIEFS OF STAFF (JCS)Tri-Service Technical Brief 002-93-08 Environmental StressScreening.Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-20368(Application for copies should be addressed to T

32、he Office of the AssistantSecretary of the Navy (Research, Develop, and Acquisition), Product Integrity,Washington, DC 20360-5000.)NATIONAL AERONAUTICS AND SPACE ADMINISTRATION (NASA)NASA-STD-3000 Manned System Integration Standard.(Application for copies should be addressed to the StandardizationDo

33、cuments Order Desk, Building 4D, 700 Robbins Avenue, Philadelphia, PA1911-5094.)NAVAL SEA SYSTEMS COMMAND (NAVSEA)NAVSEA INST C3401.1 Nuclear Survivability Design Standards forSurface Ships of the U. S. Navy. (limiteddistribution)(Application for copies should be addressed to the Commander, Naval Se

34、aSystems Command (Code 09P21), Arlington, VA 22242-5160)(Unless otherwise indicated, copies of documents are available to Governmentagencies from the Standardization Documents Order Desk, Building 4D, 700 RobbinsAvenue, Philadelphia, PA 19111-5094. Copies of documents are available tonon-Government

35、agencies from the National Technical Information Service, 5285 PortRoyal Road, Springfield, VA 22151.)NAVAL SURFACE WARFARE CENTER DAHLGREN DIVISION (NSWCDD)NSWC TR 87-192 Suggested Electronic Equipment Standards forNuclear Weapons Environment.NSWC TR 90-22 Basic Nuclear Survivability Concepts for N

36、avyComputational Electronics.(Application for copies should be addressed to the Commanding Officer, NavalSurface Warfare Center Dahlgren Division, Dahlgren, VA 22448-5000.)2.3 Non-Government publications. The following documents form a part of this document to the extent specified herein. Unless oth

37、erwise specified, the issues of thesedocuments should be those listed in the issue of the DODISS, and supplement thereto,cited in the solicitation. Unless otherwise specified, the issues of documents not listed inthe DODISS should be those in effect on the date of the solicitation.Provided by IHSNot

38、 for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-20369AMERICAN NATIONAL STANDARDS INSTITUTE (ANSI)ANSI N2.1 Warning Symbols - Radiation Symbol.ANSI S2.15 Specification for the Design, Construction,and Operation of Class HI (High-Impact)Shock-Testing Machine fo

39、r LightweightEquipment.ANSI C62.41/IEEE 587 Recommended Practice on Surge Voltagesin Low-Voltage AC Power Circuits.ANSI/IEEE C63.16 American National Standard Guide forElectrostatic Discharge TestMethodologies and Criteria forElectronic Equipment.ANSI C84.1 Electric Power Systems and Equipment -Volt

40、age Ratings (60Hz).ANSI/IEEE C95.1 Safety Levels with Respect to HumanExposure to Radio FrequencyElectromagnetic Fields, 300 kHz to 100 GHz.ANSI C95.2 Radio Frequency Radiation Hazard WarningSymbolANSI Z136.1 Safe Use of Lasers.ANSI/NEMA Z535.1 Safety Color Code.ANSI/NEMA Z535.2 Environmental and Fa

41、cility Safety Signs.ANSI/NEMA Z535.3 Criteria for Safety Symbols.ANSI/NEMA Z535.4 Product Safety Signs and Labels.(Application for copies should be addressed to the American National StandardsInstitute, 11 West 42 Street, New York, NY 10036.)AMERICAN SOCIETY OF HEATING, REFRIGERATING, AND AIRCONDITI

42、ONING ENGINEERS (ASHRAE)ASHRAE Handbook HVAC Systems and Applications.(Application for copies should be addressed to the American Society of Heating,Refrigerating, and Air Conditioning Engineers, 1791 Tullie Circle, NE, Atlanta, GA30329.)AMERICAN SOCIETY FOR TESTING AND MATERIALS (ASTM)ASTM B 117 St

43、andard Test Method of Salt Spray(Fog) Testing.ASTM D 568 Standard Test Method for Rate of Burningand/or Extent and Time of Burning of FlexiblePlastics in a Vertical Position.Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-203610ASTM D 635 St

44、andard Test Method for Rate of Burningand/or Extent and Time of Burning ofSelf-Supporting Plastics in a HorizontalPosition.ASTM D 1000 Standard for Tests for Flammability of PlasticMaterials for Parts in Devices and Appliances.ASTM D 1654 Standard Test Method for Evaluation ofPainted or Coated Speci

45、mens Subjected toCorrosive Environments.ASTM D 3951 Standard Practice for Commercial Packaging.ASTM D 4169 Standard Practice for Performance Testing ofShipping Containers and Systems.ASTM G 7 Standard Practice for AtmosphericEnvironmental Exposure Testing ofNonmetallic Materials.ASTM G 31 Standard P

46、ractice for Laboratory ImmersionCorrosion Testing of Metals.ASTM G 50 Standard Practice for Conducting AtmosphericCorrosion Tests on Metals.ASTM G 52 Standard Practice for Exposing and EvaluatingMetals and Alloys in Surface Seawater.(Application for copies should be addressed to the American Society

47、 for Testingand Materials, 100 Bar Harbor Drive, West Conshohaken, PA 19428-29597.)ELECTRONIC INDUSTRIES ASSOCIATION (EIA)EIA RS-310 Cabinets, Racks, Panels, and Associated Equipment.EIA RS-471 Symbol and Label for Electrostatic Sensitive Devices.(Application for copies should be addressed to the El

48、ectronic IndustriesAssociation, 2500 Wilson Blvd., Arlington, VA 22201-3834.)INSTITUTE OF ENVIRONMENTAL SCIENCES (IES)ISBN 1-877862-02-9 Environmental Stress Screening Guidelinesfor Assemblies.(Application for copies should be addressed to the Institute of EnvironmentalSciences, 940 East Northwest H

49、ighway, Mount Prospect, Illinois, 60056.)Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-203611INTERNATIONAL ELECTROTECHNICAL COMMISSION (IEC)IEC 68-2-3 Basic Environmental Testing Procedures,Part 2: Tests, Test Ca: Damp Heat,Steady-state.IEC 68-2-6 Basic Environmental Testing Procedures,Part 2: Tests, Test FC: Vibration (Sinuso