DLA A-A-59263 B-2011 BATTERY DRY BA-53.pdf

《DLA A-A-59263 B-2011 BATTERY DRY BA-53.pdf》由会员分享，可在线阅读，更多相关《DLA A-A-59263 B-2011 BATTERY DRY BA-53.pdf（6页珍藏版）》请在麦多课文档分享上搜索。

1、Beneficial comments, recommendations, additions, deletions, clarifications, etc., and any data that may improve this document should be sent to: DLA Land and Maritime, Columbus, ATTN: VAT, P.O. Box 3990, Columbus, OH 43218-3990, or email mailto:CircuitProtectdscc.dla.mil. Since contact information c

2、an change you may want to verify the currency of the address information using the ASSIST Online database at https:/assist.daps.dla.mil. AMSC N/A FSC 6135 INCH-POUND A-A-59263B 15 October 2011 SUPERSEDING A-A-59263A 21 June 2006 COMMERCIAL ITEM DESCRIPTION BATTERY, DRY, BA-53 The General Services Ad

3、ministration has authorized the use of this commercial item description for all federal agencies. 1. SCOPE. This commercial item description (CID) covers the general requirements for a +22.5/45 V dc dry-cell battery. This battery is intended for use in test equipment, radio sets, and other portable

4、electronic, communication equipment powered by non-rechargeable dry cell batteries. 2. CLASSIFICATION/PART OR IDENTIFICATION NUMBER (PIN). This CID uses a classification system which is included in the Part or Identification Number (PIN). The PIN shall be AA59263 (see 7.1). 3. SALIENT CHARACTERISTIC

5、S. 3.1 Interface and physical dimensions. Batteries supplied to this CID shall be as specified herein and shall meet the requirements of NEMA C18.1M Part 1 (see figure 1). 3.2 Voltage. The battery shall provide a nominal voltage of +22.5 V dc and +45 V dc. 3.3 Weight. The battery weight shall not ex

6、ceed 1 pound 10 ounces. 3.4 Terminal type. The terminals for this battery shall be the stud and nut type consisting of a threaded stud and an insulated knurled nut with a brass insert. 3.5 Cell type. Cells shall meet the requirements of ANSI Number 15A, 15D, 15F or 15M of NEMA C18.1M, Part 1. 3.6 Di

7、mensions. The battery shall meet the dimensional requirements shown in figure 1. 3.7 Marking. Batteries supplied to this CID shall be marked with the manufacturers (MFRs) standard commercial PIN. (NOTE: The part number marked on the unit pack shall be the CID PIN.) 3.8 Recycled, recovered, or enviro

8、nmentally preferable materials. Recycled, recovered, or environmentally preferable materials should be used to the maximum extent possible provided that the material meets or exceeds the operational and maintenance requirements, and promotes economically advantageous life cycle costs. 3.9 Workmanshi

9、p. Batteries shall be processed in such a manner as to be uniform in quality and shall be free from other defects that will affect life, serviceability, or appearance. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-59263B 2 FIGURE 1. Interface a

10、nd physical dimensions. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-59263B 3 Ltr Inches mm Min Max Min Max A 4.500 4.626 114.30 117.49 B - 5.219 - 132.56 C 0.562 0.688 14.27 17.48 D 1.437 1.563 36.50 39.70 E 2.312 2.438 58.72 61.93 F 2.937 3.

11、063 74.60 77.80 G 0.687 0.813 17.45 20.65 H 1.812 1.938 46.02 49.23 NOTES: 1. Dimensions are in Inches. 2. Unless otherwise specified, tolerance is .063 inch (1.59 mm). FIGURE 1. Interface and physical dimensions - Continued. Provided by IHSNot for ResaleNo reproduction or networking permitted witho

12、ut license from IHS-,-,-A-A-59263B 4 4. REGULATORY REQUIREMENTS. The offeror/contractor is encouraged to use recovered materials to the maximum extent practicable, in accordance with 23.403 of the Federal Acquisition Regulation (FAR). 5. PRODUCT CONFORMANCE PROVISIONS. 5.1 Product conformance. The p

13、roducts provided shall meet the salient characteristics of this CID, conform to the producers own drawings, specifications, standards, and quality assurance practices, and be the same product offered for sale in the commercial market. The Government reserves the right to require proof of such confor

14、mance. 6. PACKAGING. Preservation, packing, and marking shall be as specified in the contract or order. 7. NOTES. 7.1 PIN. The PIN should be used for Government purposes to buy commercial products to this CID. See section 2 for PIN format example. 7.2 Environmentally preferable material. Environment

15、ally preferable materials should be used to the maximum extent possible to meet the requirements of this specification. As of the dating of this document, the U.S. Environmentally Protection Agency (EPA) is focusing efforts on reducing 31 priority chemicals. The list of chemicals and additional info

16、rmation is available on their website http:/www.epa.gov/osw/hazard/wastemin/priority.htm. Included in the EPA list of 31 priority chemicals are cadmium, lead, and mercury. Use of these materials on the list should be minimized or eliminated unless needed to meet the requirements specified herein (se

17、e Section 3). 7.3 Commercial and Government Entity (CAGE) code. For ordering purposes, inventory control, and submission of these batteries to DLA Land and Maritime under the Military Parts Control Advisory Group (MPCAG) evaluation program, CAGE code 58536 should be used. 7.4 Source of documents. FE

18、DERAL REGULATIONS FAR - Federal Acquisition Regulations (FAR). (Copies of this document are available online at http:/www.acquisition.gov/comp/far/index.html from the U.S. Government Printing Office, 732 North Capital Street, NW, Washington D.C. 20401-0001.) Other Publications NATIONAL ELECTRICAL MA

19、NUFACTURERS ASSOCIATION (NEMA) NEMA C18.1M PART 1 - Portable Primary Cells and Batteries with Aqueous Electrolyte. (Copies of this document are available online at http:/www.nema.org/ or from the National Electrical Manufacturers Association, 1300 North 17thStreet, Rosslyn, Virginia 22209-3811). (In

20、dustry association specifications and standards are generally available for reference from libraries. They are also distributed among technical groups and using Federal agencies.) 7.5 Ordering data. The contract or order should specify the following: a. CID document number, revision, and CID PIN. b.

21、 Product conformance provisions. c. Packaging requirements. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-59263B 5 7.6 Commercial products. As part of the market analysis and research effort, this CID was coordinated with the following manufact

22、urers of commercial products. At the time of CID preparation and coordination, these manufacturers were known to have commercial products that would meet the requirements of this CID. (NOTE: This information should not be considered as a list of approved manufacturers or be used to restrict acquisit

23、ion to only the manufacturers shown.) MFRs CAGE MFRs name and address 51828 Bren-Tronics Incorporated 10 Brayton Court Commack, NY 11725-3197 Phone number: (631) 499-5155 Facsimile number (631) 499-5504 E-mail: mailto: Uniform Resource Locator (URL): 7.7 Part number (P/N) supersession data. These C

24、ID PINs supersede the following MFRs P/Ns as shown. This information is being provided to assist in reducing proliferation in the Government inventory system. TABLE II. P/N supersession data. CID PIN MFRs P/N 1/ CAGE 51828 AA59263 BT-70653 1/ The manufacturers P/N shall not be used for acquisition t

25、o the requirements of this CID. At the time of preparation of this CID, the aforementioned commercial products were reviewed and could be replaced by the CID PIN shown. For actual part marking requirements see 3.7. 7.8 Government users. To acquire information on obtaining these batteries from the Go

26、vernment inventory system, contact DLA Land and Maritime, ATTN: FLC, Post Office Box 3990, Columbus, OH 43218-3990, or telephone (614) 692-3342. 7.8.1 National stock number (NSN). The following is a list of NSNs assigned which correspond to this CID. The list is for information only and may not be i

27、ndicative of all possible NSNs associated with the CID. For up to date information on assigned NSNs, please contact the aforementioned DLA Land and Maritime office (see 7.7). TABLE III. NSNs. CID PIN (see section 2) NSN AA59263 6135-00-120-1004 7.9 Changes from previous issue. Marginal notations are

28、 not used in this revision to identify changes with respect to the previous issue due to the extensiveness of the changes. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-59263B 6 MILITARY INTERESTS: CIVIL AGENCY COORDINATING ACTIVITY: GSA - FAS

29、Custodians: Army - CR Preparing activity: Navy - SH Air Force - 99 DLA - CC DLA - CC Project 6135-2011-006 Review Activities: Navy - MC NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.daps.dla.mil. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-