DIN EN 16004-2012 Chemicals used for treatment of water intended for human consumption - Magnesium oxide German version EN 16004 2011《用于供人类食用的水处理化学品 氧化镁 德文版本EN 16004-2011》.pdf

《DIN EN 16004-2012 Chemicals used for treatment of water intended for human consumption - Magnesium oxide German version EN 16004 2011《用于供人类食用的水处理化学品 氧化镁 德文版本EN 16004-2011》.pdf》由会员分享，可在线阅读，更多相关《DIN EN 16004-2012 Chemicals used for treatment of water intended for human consumption - Magnesium oxide German version EN 16004 2011《用于供人类食用的水处理化学品 氧化镁 德文版本EN 16004-2011》.pdf（15页珍藏版）》请在麦多课文档分享上搜索。

1、February 2012 Translation by DIN-Sprachendienst.English price group 10No part of this translation may be reproduced without prior permission ofDIN Deutsches Institut fr Normung e. V., Berlin. Beuth Verlag GmbH, 10772 Berlin, Germany,has the exclusive right of sale for German Standards (DIN-Normen).I

2、CS 71.100.80!$y“1866191www.din.deDDIN EN 16004Chemicals used for treatment of water intended for humanconsumption Magnesium oxideEnglish translation of DIN EN 16004:2012-02Produkte zur Aufbereitung von Wasser fr den menschlichen Gebrauch MagnesiumoxidEnglische bersetzung von DIN EN 16004:2012-02Prod

3、uits chimiques utiliss pour le traitement de leau destine la consommationhumaine Oxyde de magnsiumTraduction anglaise de DIN EN 16004:2012-02www.beuth.deDocument comprises pagesIn case of doubt, the German-language original shall be considered authoritative.1501.12 DIN EN 16004:2012-02 2 A comma is

4、used as the decimal marker. National foreword This standard has been prepared by Technical Committee CEN/TC 164 “Water supply” (Secretariat: AFNOR, France). The responsible German body involved in its preparation was the Normenausschuss Wasserwesen (Water Practice Standards Committee), Working Commi

5、ttee NA 119-04-02 AA Wasseraufbereitung. Users of this standard are advised of the reservations stated in the Introduction of the European Standard and should note that national regulations exist in Germany dealing with water for human consumption, in particular the Trinkwasserverordnung (TrinkwV200

6、1) (German Drinking Water Ordinance). National Annex NA (informative) Bibliography Verordnung zur Novellierung der Trinkwasserverordnung (German Regulation amending the German Drinking Water Ordinance), as of 21 May 2001, Bundesgesetzblatt (German Federal Law Gazette) Part 1, No. 24, pp. 959-980)Ers

7、te Verordnung zur nderung der Trinkwasserverordnung (First Ordinance amending the German Drinking Water Ordinance) as of 3 May 2011, Bundesgesetzblatt (German Federal Law Gazette) Part 1 (2011), No. 21, pp. 748 774)Recorded in the DITR database of DIN Software GmbH, obtainable from Beuth Verlag GmbH

8、, 10772 Berlin, Germany. EUROPEAN STANDARD NORME EUROPENNE EUROPISCHE NORM EN 16004 November 2011 ICS 71.100.80 English Version Chemicals used for treatment of water intended for human consumption - Magnesium oxide Produits chimiques utiliss pour le traitement de leau destine la consommation humaine

9、 - Oxyde de magnsium Produkte zur Aufbereitung von Wasser fr den menschlichen Gebrauch - Magnesiumoxid This European Standard was approved by CEN on 8 October 2011. CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European Stand

10、ard the status of a national standard without any alteration. Up-to-date lists and bibliographical references concerning such national standards may be obtained on application to the CEN-CENELEC Management Centre or to any CEN member. This European Standard exists in three official versions (English

11、, French, German). A version in any other language made by translation under the responsibility of a CEN member into its own language and notified to the CEN-CENELEC Management Centre has the same status as the official versions. CEN members are the national standards bodies of Austria, Belgium, Bul

12、garia, Croatia, Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland and United Kingdom. EUROPEAN COMMITTEE FO

13、R STANDARDIZATION COMIT EUROPEN DE NORMALISATION EUROPISCHES KOMITEE FR NORMUNG Management Centre: Avenue Marnix 17, B-1000 Brussels 2011 CEN All rights of exploitation in any form and by any means reserved worldwide for CEN national Members. Ref. No. EN 16004:2011: EEN 16004:2011 (E) 2 Contents Pag

14、e Foreword 4Introduction .51 Scope 62 Normative references 63 Description .63.1 Identification .63.1.1 Chemical name .63.1.2 Synonym or common name 63.1.3 Relative molecular mass .63.1.4 Empirical formula.63.1.5 Chemical formula .63.1.6 CAS Registry Number 63.1.7 EINECS reference . 73.2 Commercial f

15、orms .73.3 Physical properties 73.3.1 Appearance 73.3.2 Density 73.3.3 Solubility in water 73.3.4 Particle size 73.4 Chemical properties 74 Purity criteria 74.1 General 74.2 Composition of commercial product .84.3 Impurities and main by-product .84.4 Chemical parameters 85 Test methods 95.1 Sampling

16、 .95.2 Analyses .96 Labelling - Transportation - Storage 96.1 Means of delivery .96.2 Risk and safety labelling according to the EU directives .96.3 Transportation regulations and labelling . 106.4 Marking 106.5 Storage . 106.5.1 Long term stability 106.5.2 Storage incompatibilities . 10Annex A (inf

17、ormative) General information on magnesium oxide 11A.1 Origin . 11A.1.1 Raw materials 11A.1.2 Manufacturing process 11A.2 Use . 11A.2.1 Function . 11A.2.2 Other properties 11A.2.3 Form in which it is used . 11A.2.4 Treatment dose . 11DIN EN 16004:2012-02 EN 16004:2011 (E) 3 A.2.5 Means of applicatio

18、n . 11A.2.6 Secondary effects 12A.2.7 Removal of excess product 12A.3 Rules for safe handling and use 12A.4 Emergency procedures . 12A.4.1 First aid . 12A.4.2 Spillage . 12A.4.3 Fire 12Bibliography 13DIN EN 16004:2012-02 EN 16004:2011 (E) 4 Foreword This document (EN 16004:2011) has been prepared by

19、 Technical Committee CEN/TC 164 “Water supply”, the secretariat of which is held by AFNOR. This European Standard shall be given the status of a national standard, either by publication of an identical text or by endorsement, at the latest by May 2012, and conflicting national standards shall be wit

20、hdrawn at the latest by May 2012. Attention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. CEN and/or CENELEC shall not be held responsible for identifying any or all such patent rights. According to the CEN/CENELEC Internal Regulations, t

21、he national standards organizations of the following countries are bound to implement this European Standard: Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Nethe

22、rlands, Norway, Poland, Portugal, Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland and the United Kingdom. DIN EN 16004:2012-02 EN 16004:2011 (E) 5 Introduction In respect of potential adverse effects on the quality of water intended for human consumption, caused by the product covered by thi

23、s Standard: this Standard provides no information as to whether the product may be used without restriction in any of the Member States of the EU or EFTA; it should be noted that, while awaiting the adoption of verifiable European criteria, existing national regulations concerning the use and/or the

24、 characteristics of this product remain in force. NOTE Conformity with the standard does not confer or imply acceptance or approval of the product in any of the Member States of the EU or EFTA. The use of the product covered by this European Standard is subject to regulation or control by National A

25、uthorities. DIN EN 16004:2012-02 EN 16004:2011 (E) 6 1 Scope This European Standard is applicable to magnesium oxide used for treatment of water intended for human consumption. It describes the characteristics of magnesium oxide and specifies the requirements and the corresponding test methods for m

26、agnesium oxide. It gives information on its use in water treatment. 2 Normative references The following referenced documents are indispensable for the application of this document. For dated references, only the edition cited applies. For undated references, the latest edition of the referenced doc

27、ument (including any amendments) applies. EN 12485, Chemicals used for treatment of water intended for human consumption Calcium carbonate, high-calcium lime, half-burnt dolomite, magnesium oxide and calcium magnesium carbonate Test methods ISO 3165, Sampling of chemical products for industrial use

28、Safety in sampling ISO 6206, Chemical products for industrial use Sampling Vocabulary 3 Description 3.1 Identification 3.1.1 Chemical name Magnesium oxide. 3.1.2 Synonym or common name Periklas/magnesia. 3.1.3 Relative molecular mass 40,31. 3.1.4 Empirical formula MgO. 3.1.5 Chemical formula MgO. 3.

29、1.6 CAS Registry Number 1)MgO: 1309-48-4. 1) Chemical Abstracts Service Registry Number. DIN EN 16004:2012-02 EN 16004:2011 (E) 7 3.1.7 EINECS reference 2). MgO: 215-171-9. 3.2 Commercial forms Magnesium oxide is available in granular form of various particle size ranges. 3.3 Physical properties 3.3

30、.1 Appearance The product is a grey material in round granular form. 3.3.2 Density The density is 3,6 g/cm3at 20 C. The bulk density is from 1,1 g/cm3to 1,3 g/cm3. 3.3.3 Solubility in water The solubility of product is equal to 0,0062 g/l at 20 C. 3.3.4 Particle size It varies depending on the appli

31、cation (see A.2.3). 3.4 Chemical properties Magnesium oxide product reacts as an alkali when dissolved in water. With carbon dioxide and water it hydrolyses and reacts to form magnesium hydrogen carbonate. 4 Purity criteria 4.1 General This European Standard specifies the minimum purity requirements

32、 for calcium magnesium oxide used for the treatment of water intended for human consumption. Limits are given for impurities commonly present in the product. Depending on the raw material and the manufacturing process other impurities may be present and, if so, this shall be notified to the user and

33、 when necessary to the relevant authorities. NOTE Users of this product should check the national regulations in order to clarify whether it is of appropriate purity for treatment of water intended for human consumption, taking into account raw water quality, required dosage, contents of other impur

34、ities and additives used in the product not stated in this product standard. Limits have been given for impurities and toxic substances where these are likely to be present in significant quantities from the current production process and raw materials. If a change in the production process or raw m

35、aterials leads to significant quantities of other impurities or by-products being present, this shall be notified to the user. 2) European Inventory of Existing Commercial Chemical Substances. DIN EN 16004:2012-02 EN 16004:2011 (E) 8 4.2 Composition of commercial product The product shall conform to

36、 the requirements specified in Table 1: Table 1 Composition of commercial product Parameter in mass fraction in % Content of magnesium oxide (MgO), in dry substance 70 Loss of ignition (CO2and H2O) 254.3 Impurities and main by-product The product shall conform to the requirements specified in Table

37、2. Table 2 Impurities Impurity Limit in commercial product, in mass fraction in % Content of free calcium oxide and calcium hydroxide, expressed as CaO max. 5 Content of silicon dioxide, expressed as SiO2max. 2 Content of aluminium oxide, expressed as Al2O3max. 1 Content of iron oxide expressed as F

38、e2O3max. 2 4.4 Chemical parameters The content of chemical parameters shall conform to the requirements specified in Table 3. DIN EN 16004:2012-02 EN 16004:2011 (E) 9 Table 3 Chemical parameters Parameter Limit of product mg/kg, in dry substance Antimony (Sb) max. 3 Arsenic (As) max. 3 Cadmium (Cd)

39、max. 2 Chromium (Cr) max. 10 Lead (Pb) max. 10 Mercury (Hg) max. 0,5 Nickel (Ni) max. 10 Selenium (Se) max. 3 NOTE Other chemical parameters and indicator parameters are not relevant in magnesium oxide because the raw materials used in the manufacturing process are free of them. For parametric value

40、s of magnesium oxide on trace metal content in drinking water, see 1. 5 Test methods 5.1 Sampling Observe the general recommendations of ISO 3165 and take account of ISO 6206. Prepare the laboratory sample(s) required by the relevant procedure described in EN 12485. 5.2 Analyses Use the relevant met

41、hods for analysis described in EN 12485. 6 Labelling - Transportation - Storage 6.1 Means of delivery Magnesium oxide can be delivered in bags, containers and as a bulk material. In order that the purity of the products is not affected, the means of delivery shall not have been used previously for a

42、ny different product or it shall have been specially cleaned and prepared before use. 6.2 Risk and safety labelling according to the EU directives 3)At the date of publication of this standard, no labelling is required. NOTE Regulation (EC) No 1907/2006 of the European Parliament and of the Council

43、of 18 December 2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), establishing a European Chemicals Agency, amending Directive 1999/45/EC and repealing Council Regulation (EEC) No 793/93 and Commission Regulation (EC) No 1488/94 as well as Council Direc

44、tive 76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, 93/105/EC and 2000/21/EC contains a list of substances classified by the EU. Substances not listed in this 3) See 2 and 4. DIN EN 16004:2012-02 EN 16004:2011 (E) 10 regulation should be classified on the basis of their intrinsic proper

45、ties according to the criteria in the Regulation by the person responsible for placing the product on the market. 6.3 Transportation regulations and labelling At the date of publication of this standard, Magnesium oxide products are not classified as dangerous goods. 6.4 Marking The marking shall in

46、clude the following: “magnesium oxide“, trade name and grade; net mass; name and address of supplier and/or manufacturer; the statement “this product conforms to EN 16004.“ 6.5 Storage 6.5.1 Long term stability Product can be stored for unlimited period of time if kept dry. 6.5.2 Storage incompatibi

47、lities Product shall be kept away from acids. DIN EN 16004:2012-02 EN 16004:2011 (E) 11 Annex A (informative) General information on magnesium oxide A.1 Origin A.1.1 Raw materials Natural periklas or industrially produced magnesium oxide. A.1.2 Manufacturing process Magnesium oxide is manufactured by crushing and granulating. A.2 Use A.2.1 Function Magnesium oxide is used to adjust pH value and hardness in water. A.2.2 Other properties Magnesium oxide can also be used for neutralizing mineral acids. A.2.3 Form in which it is used Magnesium oxide is used in the form of granular material.