BS ISO 18168-2015 Textile floor coverings Colour fastness to shampooing《纺织地板覆盖物 耐香波色牢度》.pdf

《BS ISO 18168-2015 Textile floor coverings Colour fastness to shampooing《纺织地板覆盖物 耐香波色牢度》.pdf》由会员分享，可在线阅读，更多相关《BS ISO 18168-2015 Textile floor coverings Colour fastness to shampooing《纺织地板覆盖物 耐香波色牢度》.pdf（14页珍藏版）》请在麦多课文档分享上搜索。

1、BSI Standards PublicationBS ISO 18168:2015Textile floor coverings Colour fastness to shampooingBS ISO 18168:2015 BRITISH STANDARDNational forewordThis British Standard is the UK implementation of ISO 18168:2015.The UK participation in its preparation was entrusted to TechnicalCommittee PRI/3, Textil

2、e floor coverings.A list of organizations represented on this committee can beobtained on request to its secretary.This publication does not purport to include all the necessaryprovisions of a contract. Users are responsible for its correctapplication. The British Standards Institution 2015.Publishe

3、d by BSI Standards Limited 2015ISBN 978 0 580 83148 5ICS 59.080.60Compliance with a British Standard cannot confer immunity fromlegal obligations.This British Standard was published under the authority of theStandards Policy and Strategy Committee on 31 December 2015.Amendments/corrigenda issued sin

4、ce publicationDate T e x t a f f e c t e dBS ISO 18168:2015 ISO 2015Textile floor coverings Colour fastness to shampooingRevtements de sol textiles Solidit des coloris au shampooingINTERNATIONAL STANDARDISO18168First edition2015-12-15Reference numberISO 18168:2015(E)BS ISO 18168:2015ISO 18168:2015(E

5、)ii ISO 2015 All rights reservedCOPYRIGHT PROTECTED DOCUMENT ISO 2015, Published in SwitzerlandAll rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized otherwise in any form or by any means, electronic or mechanical, including photocopying, or postin

6、g on the internet or an intranet, without prior written permission. Permission can be requested from either ISO at the address below or ISOs member body in the country of the requester.ISO copyright officeCh. de Blandonnet 8 CP 401CH-1214 Vernier, Geneva, SwitzerlandTel. +41 22 749 01 11Fax +41 22 7

7、49 09 47copyrightiso.orgwww.iso.orgBS ISO 18168:2015ISO 18168:2015(E)Foreword iv1 Scope . 12 Normative references 13 Terms and definitions . 14 Principle 15 Apparatus and reagents 15.1 Testing frame 15.2 Auxiliary equipment . 15.3 Shampoo solution . 25.4 Adjacent fabrics 25.4.1 Textile floor coverin

8、gs . 25.4.2 Yarns or loose fibres . 25.4.3 Tufts 25.5 Grey scales 26 Preparation of test specimens 36.1 General . 36.2 Textile floor covering . 36.3 Yarns 36.4 Loose fibres and tufts 37 Procedure. 38 Test report . 4Bibliography 5 ISO 2015 All rights reserved iiiContents PageBS ISO 18168:2015ISO 1816

9、8:2015(E)ForewordISO (the International Organization for Standardization) is a worldwide federation of national standards bodies (ISO member bodies). The work of preparing International Standards is normally carried out through ISO technical committees. Each member body interested in a subject for w

10、hich a technical committee has been established has the right to be represented on that committee. International organizations, governmental and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the International Electrotechnical Commission (IEC) on all

11、 matters of electrotechnical standardization.The procedures used to develop this document and those intended for its further maintenance are described in the ISO/IEC Directives, Part 1. In particular the different approval criteria needed for the different types of ISO documents should be noted. Thi

12、s document was drafted in accordance with the editorial rules of the ISO/IEC Directives, Part 2. www.iso.org/directivesAttention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. ISO shall not be held responsible for identifying any or all su

13、ch patent rights. Details of any patent rights identified during the development of the document will be in the Introduction and/or on the ISO list of patent declarations received. www.iso.org/patentsAny trade name used in this document is information given for the convenience of users and does not

14、constitute an endorsement.For an explanation on the meaning of ISO specific terms and expressions related to conformity assessment, as well as information about ISOs adherence to the WTO principles in the Technical Barriers to Trade (TBT) see the following URL: Foreword - Supplementary informationTh

15、e committee responsible for this document is ISO/TC 219, Floor coverings.iv ISO 2015 All rights reservedBS ISO 18168:2015INTERNATIONAL STANDARD ISO 18168:2015(E)Textile floor coverings Colour fastness to shampooing1 ScopeThis International Standard describes a method for determining the colour fastn

16、ess of textile floor coverings and yarns, loose fibres and tufts extracted from textile floor coverings, to the action of a reference shampoo solution.2 Normative referencesThe following documents, in whole or in part, are normatively referenced in this document and are indispensable for its applica

17、tion. For dated references, only the edition cited applies. For undated references, the latest edition of the referenced document (including any amendments) applies.ISO 2424, Textile floor coverings Vocabulary3 Terms and definitionsFor the purposes of this document, the terms and definitions given i

18、n ISO 2424 apply.4 PrincipleA specimen of a textile floor covering, yarn, loose fibre or tuft, in contact with specified adjacent fabrics, is immersed under pressure in a shampoo solution buffered to a pH of (7,5 0,2). The specimen and the adjacent fabric are dried separately. The change in colour o

19、f the specimen and the staining of the adjacent fabrics are assessed using the grey scales.5 Apparatus and reagents5.1 Testing frameThe device consists of a stainless steel frame into which a mass of 5 kg with a base of 60 mm 115 mm fits closely so that a pressure of 12,5 kPa can be applied on test

20、specimens (40 mm 100 mm), placed between glass or acrylic resin plates. If the mass is removed during the test, the testing device shall be constructed so that the pressure of 12,5 kPa remains unchanged.Other devices may be used provided that the same results are obtained as with the apparatus descr

21、ibed in Clause 5.5.2 Auxiliary equipment5.2.1 Flat-bottomed dish, approximately 150 mm 150 mm 50 mm.5.2.2 Mass, 5 kg with a base of 60 mm 115 mm.5.2.3 pH meter, with an accuracy of 0,02 units.5.2.4 Oven, maintained at (40 2) C. ISO 2015 All rights reserved 1BS ISO 18168:2015ISO 18168:2015(E)5.3 Sham

22、poo solutionThis solution is prepared by dissolving 1 g dodecyl sodium sulfate (CAS-number 15-121-3) and 0,2 g lauric mono-isopropanolamide (CAS-number 142-54-1) or 0,2 g coconut diethanolamide (CAS-number 68603-42-9) in 500 ml of deionized or distilled water. If necessary the solution is heated to

23、ensure dissolution of the surfactant. Cool to a temperature of about 30 C.Prepare a buffer solution by adding 14 ml of citric acid 0,5 mol/l (CAS-number 77-92-9) to 372 ml of a disodium hydrogen phosphate 0,5 mol/l (CAS-number 7558-79-4) solution.Add the buffer solution to the surfactant solution an

24、d dilute to 1 l. If required; adjust the pH to (7,5 0,2) using citric acid or sodium hydroxide (CAS-number 1310-73-2), as appropriate.5.4 Adjacent fabrics5.4.1 Textile floor coveringsWhen the test specimen is a textile floor covering, two adjacent fabrics (50 mm 40 mm) shall be used, one made of the

25、 same fibre as in the specimen (or the predominant fibre in the case of blends) and the other one made of the fibre as indicated in the second column of Table 1. If the staining of further fibres is of interest, two or more specimens shall be tested separately.5.4.2 Yarns or loose fibresWhen the tes

26、t specimen is in the form of a yarn or loose fibre, two adjacent fabrics (100 mm 40 mm) shall be used, one made of the same fibre as in the specimen (or the predominant fibre in the case of blends) and the other one made of the fibre as indicated in in the second column of Table 1. If the staining o

27、f further fibres is of interest, two or more specimens shall be tested separately.5.4.3 TuftsWhen the test specimen is in the form of tufts extracted from a textile floor covering, two adjacent fabrics (50 mm 40 mm) shall be used, one made of cotton, to act solely as a support for the tufts, and the

28、 other one made of the same fibre as in the specimen (or the predominant fibre) in the case of blends, or any other fibre. If the staining of two or more fibres is of interest, two or more specimens shall be tested separately.Table 1 Adjacent fabricsFirst piece Second pieceCotton WoolWool CottonSilk

29、 CottonLinen CottonViscose WoolAcetate ViscosePolyamide Wool or viscosePolyester Wool or cottonAcrylic Wool or cotton5.5 Grey scalesStandardized grey scales for assessing change in colour and staining shall be used.2 ISO 2015 All rights reservedBS ISO 18168:2015ISO 18168:2015(E)6 Preparation of test

30、 specimens6.1 GeneralA test specimen is prepared in accordance with 6.2 to 6.4. A further original specimen is cut, kept and used as reference for comparison with the tested specimen.6.2 Textile floor coveringCut a specimen 100 mm 40 mm from which any integral foam underlay has been removed, and cov

31、er the use-surface with two pieces of adjacent fabric to form a composite specimen.6.3 YarnsSew a uniform layer of 0,4 g yarn in parallel 100 mm lengths to a side of one of the adjacent fabrics. Cover with the other piece and sew along the same edge to form a composite specimen.6.4 Loose fibres and

32、tuftsComb and compress 0,4 g of the loose fibre or tufts into a uniform layer of 100 mm 40 mm. Place this between the two pieces of adjacent and sew along two opposite sides to form a composite specimen.7 ProcedurePlace the composite specimen in the flat-bottomed dish. In the case of a tuft composit

33、e specimen, the composite specimen should be placed in the dish with the cotton fabric side facing downward on the inside bottom surface.Pour sufficient shampoo solution at a temperature of (37 2) C over the composite specimen to give a liquor-to-goods ratio of at least 10:1 ensuring thorough wettin

34、g of the composite specimen. Cover the composite specimen with a smooth glass or clear acrylic resin plate. Press the plate with the fingers to remove air bubbles and place the 5 kg mass on top of the plate.Allow the dish to stand in an oven at (37 2) C for 15 min. Remove the mass and pour off the s

35、hampoo solution, leaving the plate on the composite specimen intact in the dish.Proceed by eithera) placing an assembly consisting of the composite specimen between two glass or clear acrylic resin plates under a pressure of 12,5 kPa in the testing frame preheated to (37 2) C, and placing the appara

36、tus containing the assembly horizontally in the oven at (37 2) C for 1,5 h, orb) replacing the weight-piece and allow the dish to stand at (37 2) C for a further 1,5 h.Separate the specimen from the adjacent fabrics, hydro-extract them to remove excess liquor and dry them apart in air at a temperatu

37、re not exceeding 60 C.Assess the change in colour of the specimen and the staining of the adjacent fabrics with reference to the original specimen and the original adjacent fabrics, respectively, by comparison with the grey scale. When tufts are tested, the staining of the cotton support shall not b

38、e assessed.Before assessing the test specimen for change in colour, it is recommended that pile lay orientation of the test specimen be restored so that it resembles exactly that of the original specimen. ISO 2015 All rights reserved 3BS ISO 18168:2015ISO 18168:2015(E)8 Test reportThe test report sh

39、all contain the following information:a) a reference to this International Standard, i.e. ISO 18168;b) all details necessary for the identification of the sample tested;c) the numerical ratings for the change in colour of the test specimen and for the staining of each kind of adjacent fabric used;d)

40、 any deviation, by agreement or otherwise, from the procedure specified.4 ISO 2015 All rights reservedBS ISO 18168:2015ISO 18168:2015(E)Bibliography1 ISO 105-A01, Textiles Tests for colour fastness Part A01: General principles of testing2 ISO 105-A02, Textiles Tests for colour fastness Part A02: Gre

41、y scale for assessing change in colour3 ISO 105-A03, Textiles Tests for colour fastness Part A03: Grey scale for assessing staining4 ISO 105-F01, Textiles Tests for colour fastness Part F01: Specification for wool adjacent fabric5 ISO 105-F02, Textiles Tests for colour fastness Part F02: Specificati

42、on for cotton and viscose adjacent fabrics6 ISO 105-F03, Textiles Tests for colour fastness Part F03: Specification for polyamide adjacent fabric7 ISO 105-F04, Textiles Tests for colour fastness Part F04: Specification for polyester adjacent fabric8 ISO 105-F05, Textiles Tests for colour fastness Pa

43、rt F05: Specification for acrylic adjacent fabric9 ISO 105-F06, Textiles Tests for colour fastness Part F06: Specification for silk adjacent fabric10 ISO 105-F07, Textiles Tests for colour fastness Part F07: Specification for secondary acetate adjacent fabric11 AS/NZS 2111.19.2:1996Textile floor cov

44、erings test and measurements method 19.2: colour fastness test-Shampoo solution12 BS 1006:1990UK-TB. Colour fastness to shampooing of textile floor coverings ISO 2015 All rights reserved 5BS ISO 18168:2015ISO 18168:2015(E) ISO 2015 All rights reservedICS 59.080.60Price based on 5 pagesThis page deli

45、berately left blankBSI is the national body responsible for preparing British Standards and other standards-related publications, information and services.BSI is incorporated by Royal Charter. British Standards and other standardization products are published by BSI Standards Limited.British Standar

46、ds Institution (BSI)BSI Group Headquarters389 Chiswick High Road London W4 4AL UKAbout usWe bring together business, industry, government, consumers, innovators and others to shape their combined experience and expertise into standards -based solutions.The knowledge embodied in our standards has bee

47、n carefully assembled in a dependable format and refined through our open consultation process. Organizations of all sizes and across all sectors choose standards to help them achieve their goals.Information on standardsWe can provide you with the knowledge that your organization needs to succeed. F

48、ind out more about British Standards by visiting our website at or contacting our Customer Services team or Knowledge Centre.Buying standardsYou can buy and download PDF versions of BSI publications, including British and adopted European and international standards, through our website at where h

49、ard copies can also be purchased. If you need international and foreign standards from other Standards Development Organizations, hard copies can be ordered from our Customer Services team.SubscriptionsOur range of subscription services are designed to make using standards easier for you. For further information on our subscription products go to British Standards