ARMY PPP-B-676 E-1992 BOXES SETUP《组合箱》.pdf

《ARMY PPP-B-676 E-1992 BOXES SETUP《组合箱》.pdf》由会员分享，可在线阅读，更多相关《ARMY PPP-B-676 E-1992 BOXES SETUP《组合箱》.pdf（33页珍藏版）》请在麦多课文档分享上搜索。

1、PPP-B-b7bE m 9999974 0143944 701 m Ppp-B-67 6E Drxemkr 31, 1992 SwEXsED PPP-B-6 7 6D Novemkr 2, 1974 Almmmm-2 August 10, 1977, and INr. -3 April 20, 1989 FERERAL SPECIFICATION The Gmeral Senrices Achnistration has authorized the use of this federal specification, for all federal agencies. 1.1 ScoDe.

2、 This specification covers the mquimmnts for new paperboard setup boxes ami for closuce of filled boxes (see 6.1). 1.2 Classification. Setup pprbard boxes shall be of the following types, varieties, classes, and styles, as specified (see 6.2 and 6.3). Type1 - Ful1telescope Typen - Slide boxes Type 1

3、1 - Partial telescope or shallow lid Type III - Neckorshuuler Variety 1 - Plain Variety2 - Waterresistant Variety3 - Greaseresistant Variety4 - Waterandgreaseresistant Beneficial camients (recamiendations, additions, deletions) and any pertinent data which niay be uced in inproving this documnt shou

4、ld be addressed to: Center, Natick, MA 01760-5018 by using the stardardi zation bcumnt Improvement Pmposal (m Fom 1426) appearing at the erd of this document or by letter. U.S. Army Natick Research, Developnent, and Engineering 1 - AiBC N/A FSC 8115 DISITUBLTTION STATEMENT A. a Apprwed for public re

5、lease; distribution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-67bE m 9999974 0143945 648 m PPP-B-676E variety5 - Plainfireretardant Variety 6 - Water resistant and fire retardant variety7 - GreaseResistantardfireretardant Va

6、riety 8 - Water and grease riesistant-fire retardant Class A - Blank, corner s+avwi (see figure 5) Class D - Blank, erd set (see figure 7) Class B Class c Class E - Blank, bottarn set (see figure 8) - Blank, corners stitched or glued (see figure 5) Blank, corners cut without stays (see figure 5) - S

7、tyle 1 - Baneed or strip stayed (see figure 9) Style 3 - Stripwvered (see figure 11) Style 4 - Tight wrapped (see figure 6) Style 2 - TriMEd (see figure 10) 2.1 Goverrmient dommnts. !the follawing docuanents, of the issues in effect on the date of invitation for bids or reguest for proposal, farm a

8、part of this specification to the extent specified herein. Federal SDec if ications UJ-P-268 - Paper, Kraft, Wrapping PPP-B-601 - Boxes, wood, Cleated-Plm FJPP-B-621 - Boxes, wood, Nailed ard Lack-Corner PPP-B-636 - Boxes, Shim-, Fikrboad Federal Standards FE-STFlOl - Wt procedurec far Packaging Mat

9、erials FED-123 - Marking for chiprient (Civil Agencies) (Activities outside the federal Goverrnient may obtain copies of federal specifications, standards, and -id item descriptions as outlined under General Informtion in the Index of Federal Specifications, stanlards and carniercial Itan Descriptio

10、n. mnthly supplements as issued, is for sale on a sukscription basis by the Superintemient of Documents, U.S. Govenatient Printing Office, Washington, DC nbe Index, which includes dative bi- 20402-0001.) t (Single copies of this specification and other federal specifications axxi romnercial item des

11、criptions required by activities outside the Federal # Goverrment for biddirag pirposes are available without charge from the General Services Administration Business Service Centers, Regional Offices in (r -ton, MA; -York, NY; Washington, DC; Atlanta, GA; Chicago, IL; Kansas City, M3; Fort Worth, T

12、X; Denver, CO; San kancisco, CA; Lros Angeles, CA; and b Seattle, WA.) - 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-b7bE m 9999974 0343946 584 FPP-B-676E (Federal Gmemwnt activities may obtain copies of federal standardization . documen-

13、 and the Index of Federal Specifications, ctandards and Camrercial Item Descriptions frun established distribution points in their agencies.) * Military Standards MIL-SID-105 - Sapling procedures and Tables for Inspection ML-SID-129 - =king for Shipnent and Storage by Attrhm (Copies of military spec

14、ifications and staridards required by contractom in connection with specific pmcummnt functions should be abtained fran the procuring activity or as direct ami Boxbaards Staridards, National Papertx#rd Association. - 2/ A tolerance of f 0.001 inch will be permitted in thickness fmn 0.026 thraigh 0.0

15、32 inch and f 0.0015 inch for greater thicknesses. O- - 3/ See 3.1.1.2 for lines, strip banded or tight wrapped boxes. Basis weight tolerance shall be f 5 percent. - 4/ see 3.1.1.1 for lined, strip banded or tight wrappe boxes. 3.1.1.1 Wirstina strenuth of the canbined tamo nents of style 3 ami styl

16、e 4 boxes. niaterial of tight wrapped boxes designed for contents of 3/4 pourd or less in table I. For boxes designed for contents greater than 3/4 pound, the bursting strength of canbhed material shall be 24 points greater than the bursting strength rquinmnts of table I. In addition to the bursting

17、 strength requirements in table i, the bursting strength of the barded area of strip banded boxes, and the cantlined weight shall be 14 points greater than the airsting strength rquinmn ts of 3.1.1.2 Basis weiuht of the canbined tamo nents of boxes. nie canbined basis weight of strip band and tight

18、wrap boxes shall be 13.5 pounds per 1000 square feet greater than the basis weight requirerrients specified in table II for boxes designed for contents of 3/4 pound or less in weight, and 16.0 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-6

19、7bE 9999974 0343949 293 PPP-B-676E pounds per 100 square feet for boxes designed for content weight greater than 3/4 pound. shall be 12.0 pcxuds per 1000 square feet greater than the vaues specified in table I. The basis eight of glassine or gmasepmf lined paprbxd e 3.1.2 Varietv 2, 3, 4, 5, 6, 7 an

20、d 8; water resistant, areas e resistant, water and areas e resistant, fire retardant, water resistant and fire retardant, areas e resistant and fire mtaniant and water resistant, areas e resistant and fire retardant. Papertxiard may be treated chemically to o$tain the water or grease resistance, wat

21、er or grease resistant and fire re-t and water and grease resistance with fire retardant characteristics mquire, or niay be carbineci with a sheet of lining paper or film, with an applicable ahesive to provide the resistance rquimmnt. coating shall sow no rupture along the score lines after the box

22、is foimed. The resistant sick of the shall form the inside surfaces of the box. Varieties 2, 3, 4, 5, 6, 7 and 8 papertxrard shall show no tendency to block when tested as specified in table III at 120 degrees 5 5 degrees F and at 75 f 3.5 percent relative humidity. When boxes are used for packaging

23、 food pruducts, the materials used shall conform with the Federal Food, Drug, and cocrrietic Act and regulations prumlgated thmuder. which boxes will be fabricated shall lie flat to the extent that the ege curl shall not exceed 3/16 inch when tested as specified in 4.5.1. paperboard shall contain re

24、covered materials as specified in 3.1.1. 3.1.2.1 Varietv 2, water resistant and varietv 6, water resistant and fire retardant boxes. resistant and fire retardant boxes shall conform to the requhamts in table I, and shall have the inner surface of the box treated, coated, or laminated with a plastic

25、sheet, to vide the resistant feature required. Weatherproof papabard is not continuously bonded to the pa-. the extent that there shall be no discoloration of the dye after not less than 2 hours when tested as specified in table III. Variety 6 boxes treated for fire retardant shall also meet the tes

26、t of 4.2.2. The adhesive shall not penetrate through the lining niaterial. Materials used in laminating or The pperbad fran Rie Paperbmd used to fabricate water resistant and water Linings and coatings shall reniain The boxes shall be water resistant to 3.1.2.2 Varietv 3, qreas e resistant and varie

27、tv 7, areas e resistant and fire retardant boxes. grease resistant and fire retardant boxes shall conform to the requirements in table I, and shall be txeated or processed for grease resistance to the extent that the average tinie of penetration of turpentine is not less than 24 hours when tested as

28、 specified in table III. Variety 7 shail meet the fire retardant test of 4.2.2. Paperboard used to fabricate grease resistant and 3.1.2.3 Varietv 4, water and areas e resistant and varietv 8 water, areas e resistant and fire retardant boxes. Paperboard used to fabricate grease and water resistant an

29、d grease and water ami grease resistant and fire retardant boxes shall conform to the requirements in table I, ami shall be treated or 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-67bE 9999974 0343950 TO5 PPP-B-676E processed for grease an

30、d water resistance to the extent that the penetration of turpentine from the barrier side of the pap old -; old magazines; mixed waste paper; tabulating cards; and used codage. All paper, m, and fibmus waste that enter and are collected frun numicipal solid waste. Also cut scrap pap wrong side out.

31、Tape closure underclosure - failure to hill close box prior to taping or other fastening operation. of box causing poor stacking and fit in overpack. overlapping - with bending, distortion, creating us of narxaer width tape than specified. verlap less than specified. mrn, curling or loose on contain

32、er. Incorrect placement of tape. 20 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-676E W 9999974 0343964 5TT PPP-B-67 6E i t FIGURE I-TYPE I, nalt TELESCOPE 21 Provided by IHSNot for ResaleNo reproduction or networking permitted without licen

33、se from IHS-,-,-PPP-B-b7bE 9999974 0343965 436 = PPP-B-676E I I : i I I I i =- I I -7 FI- 2-TYPE II, PARTIAL -E OR LID 22 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-67bE . W 9999974 0343966 372 1; I I !i I ! PPP-B-676E I t i NECK WRAP ONE

34、P/CE NECK MAY BE FORMED BY MEANS OF A SCORED, ONE PIECE EIANK AS S“ OR BY I“TIIG (XMFLEE ONE PIKE BASE (OR CDVER) EL?NK AS S“ ABOVE. SLIM A BzAMc WHEN USED FOR THIS PURPOSE IS CALTXD A TRAY AND MAY BE STRIP BANDED OF ONE PIECE TIQIT WRAPPED FIGURE 3mE III, NECK OR SHOUIDER 23 Provided by IHSNot for

35、ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B- 6 7 6E f I I I I I 1 ! ! I I II L y- / i I i, - I I i I I - . FIGURE 4, TYPE IV, SLIDE KXES 24 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-676E W 9999974 0343

36、968 345 PPP-E-676E 25 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-67bE 9999974 01143969 081 W PPP-B-676E FIGURE 7,-caAsS D, END SFT NE PIECE BIAM( Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS

37、-,-,-PPP-B-67bE = 9999974 0143970 8T3 PPP-B-676E FIGURE 8-CLASS E, EKYFICM SFT NE PIECE BLANK 27 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-b7bE 9999974 0143971 73T PFP-B-6 7 6E 28 Provided by IHSNot for ResaleNo reproduction or networking

38、 permitted without license from IHS-,-,-PPP-B-67bE 74 0343972 b7b PPP-B-676E FI- 1O-sryLE 2, TRIMMED 29 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-PPP-B-67bE 9999974 0343973 502 PPP-B-67 6E FIGURE 11, SrYLE 3, STRIP (XrJERING 30 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-