ARMY MIL-PRF-32271 8-2008 BATTERY NON-RECHARGEABLE LITHIUM《不可充电锂电池》.pdf

《ARMY MIL-PRF-32271 8-2008 BATTERY NON-RECHARGEABLE LITHIUM《不可充电锂电池》.pdf》由会员分享，可在线阅读，更多相关《ARMY MIL-PRF-32271 8-2008 BATTERY NON-RECHARGEABLE LITHIUM《不可充电锂电池》.pdf（5页珍藏版）》请在麦多课文档分享上搜索。

1、AMSC N/A Page 1 of 5 FSC 6135 DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited INCH-POUND MIL-PRF-32271/8 30 October 2008 PERFORMANCE SPECIFICATION SHEET BATTERY, NON-RECHARGEABLE, LITHIUM This specification is approved for use by all Departments and Agencies of the D

2、epartment of Defense. The requirements for acquiring the product herein shall consist of this specification and MIL-PRF-32271. Figure 1 General View, M32271/8 Battery Shape REQUIREMENTS (see 1.2 for Type, Class, and Features descriptions): Type I Class 1 Features A PIN M32271/8-11A Approved chemistr

3、y: Lithium manganese dioxide (Li/MnO2) Specification requirements: The following requirements of MIL-PRF-32271, identified therein as “when specified”, are applicable as indicated below: Requirement Specification Reference Applicability Parallel cell arrangements 3.4 No Connectors 3.4.5 No Battery c

4、harger connection 3.4.5.1 No Connection integrity 3.4.5.2 No Terminal integrity 3.4.6 Yes Socket strength 3.4.6.1 No Terminal strength 3.4.6.2 Yes Complete discharge device 3.4.7 No State of charge device 3.4.8 No State of charge data output 3.4.8e No Cell charging 3.5.3 No Continued next pageSee NO

5、TES for nominal dimensions; see applicable drawing for dimensional requirements. Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-32271/8 2 Requirement Specification Refere

6、nce Applicability Nail penetration 3.5.4 No Cell series string short circuit 3.5.6 No Parallel string charge protection 3.5.6.1 No Charge protection 3.5.11 No Over-current protection 3.5.13.1 No Over-temperature protection 3.5.14 No Surface temperature 3.6h No Capacity tests LR and LRT No Immersion

7、3.7.8 Yes Watertight integrity 3.7.9 No DO NOT CHARGE! Marking 3.8.1.2b No Complete discharge device 3.8.4 No marking/label State of charge marking 3.8.5 No Dimensions, marking and configuration Battery - Drawing A3315885 Battery Connector Not Applicable Mating Connector Not Applicable Battery Charg

8、er Connector Not Applicable Battery voltages (3.4.4 now it is subject to the test requirements therein beginning in October 2009. Class 9 shipping labels typically wont be needed; consult with 49 CFR 173.185 for package quantity/size limitations. It contains less than 0.5 of lithium per cell and les

9、s than 1.0 gram of lithium per battery. It should be noted that all non-rechargeable lithium batteries are restricted from shipment as cargo aboard passenger aircraft within, entering, or leaving the US. This battery does not have a complete discharge device. It is considered Non-Hazardous Solid Was

10、te per the Resource Conservation and Recovery Act (RCRA). However, it is considered Hazardous Waste in states using Bioassay rules. Check with your local disposal office for rules that apply. Navy safety tests of NAVSEA S9310-AQ-SAF-010 are required for this battery during first article testing. The

11、 test data provided from the testing will be used to evaluate applications for specific using devices and Navy platforms. Devices using this battery may require US Navy Safety Approval prior to use by Department of Navy users unless such approval has already been granted. Please consult with NAVSEA

12、Instruction 9310.1 for further information. Custodians: Preparing activity: Army CR Army CR Navy NW (Project Number 6135-2006-011) Air Force 99 DLA GS Review activities: Navy SH, AS, MC Air Force 71 NOTE: The activities listed above were interested in this document as of the date of this document. S

13、ince organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at http:/assist.daps.dla.mil or http:/assist.daps.dla.mil/quicksearch/. Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license from IHS-,-,-