ARMY MIL-D-10254 C-1975 DECORATION NETHERLANDS ORANGE LANYARD《荷兰橘色系索 装饰品》.pdf

《ARMY MIL-D-10254 C-1975 DECORATION NETHERLANDS ORANGE LANYARD《荷兰橘色系索 装饰品》.pdf》由会员分享，可在线阅读，更多相关《ARMY MIL-D-10254 C-1975 DECORATION NETHERLANDS ORANGE LANYARD《荷兰橘色系索 装饰品》.pdf（9页珍藏版）》请在麦多课文档分享上搜索。

1、. . . . -. . . . A a -.-.,.- c . I MIL-D-10254B- I .- -.-.I. . * - -_ . ,_. . - 29 June -1968 _- -.-+., . MILITARY SPECIFICATION . . . _.-_.- .*.I. . . . . . NET“U.ANDS ORANGE . . . pecification is approved for use by all Deparfments, -, and Agencies of the Department of Defense. _.a._-1 - 1. SCOPE

2、This specification Overs the . .- _- 11.-1-1. Orange hnyard -Decoration -: “ . - . . . Onsisting Of a braided cord with Self bound loops at -end. and .a swivel :. . snap attached to one of the loops, -=. . . . -._-_-.-. , .- “.-.- . I- . -._ “._ . ._ - . - , . 20 APPLICABLE DOCUMENTS 2*1 me followin

3、g documents of the issue in effect on the invitation for bids or request for proposai form a part of this extent specified herein. - . .- -.* SPECIFICATIONS FEDERAL :-:L:.:z.x !.:.x: L.:.: : : : : V-T-276 - Thread, Cotton , -. PPP-B-636 - Box, Shipping, Fiberboard PPP-B-676 - Boxes, Set-up c.:.:.-.

4、STANDARDS , . MILITARY . Procedures and Tables for Inspection p.:r=-. - ;.* DRAWINGS . . INSTITUTE OF HERALDRY EI:;: * . . ._._C-.-.- . L_I._ . . . . . . . . - ,._ i I_I_._. I . . FEDERAL Fed* Test Method Std. NO. 191 - Textile Test Methods , -._. M1L-STD-105 - _ _ by Attributes -_- - . . _ III-. d.

5、-.-. ,-*.-.I-. -_-.i_._._ .-. . -.- * .- -.,_ llll-.-.l-l- .- “.-._ _-_.- - . -. ._-.-. I-., ,._ - - . mL-STD-129 Marking for Shipment . -.f.-.- . . . . -.-. , . ,er. . -. .- - ._-_- _.-.- - .-. ,_._-_,.-.y I- - . ri-.-r -. . -._ _.- . -.-_I C1-.-“ . -. ._ _-. - . -f. -I “ _-. -.-._ . . ,._I .-. I.

6、. _. . _. -.-.- c. . .-.- - . E:.:.:.! . , - - I . - . B-10-12 - Decoration, Netherlands Orage unyard . /FSC 455/ . -4 TlB _j-. _ _= - . d. .I.-*. . ._ _. . _. . I.-. s, 1:. :.: .:.*.:.:.: i ; i . - . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-.

7、 :.:* MIL-D-10254C (Copies of specifications, standards and drawings required by the contractor in. connection with a specific procurement function should be obtained from the- procuring activity or as directed by the contracting officer.) (Figure 1 is a miniature reproduction of drawing B-10-12 and

8、 is attached for informatiom prposes.) 2.2 Other publications,- The following document forms a part of this spec- ification to the extent specified herein. effect on date of invitation for bids or request for proposal shall apply. Unless otherwise indicated, the issue in DOD Standard Color Card of O

9、fficial Standardized Shades for Heraldic Yarns for Embroidery and Ribbons, 1974 document should be addressed to The Color (Application for copies of the aforementioned Association of the United States, Inc., 200 Madison Avenue, New York, New York 10016.) 3. REQUIREMENTS 3.1 Samples. - 3.1.1 Guide sa

10、mple.- Unless otherwise specified (see 6.2), a guide s.ample of the finished lanyard shall be furnished for guidance and information only. yariation occurs between the guide sample and this specification, the requirements of this specification shall govern. When . * ji: : : : . . - . . . #.- -. , .

11、-._ -._ . _.- ._ -_ -.-._-. . “ . . . - . “ - .:.- .-.-, sulfur or compounds capable of oxidization to sulfuric acid is prohibited. When .I . .-.-_.- I . - -_, -_-_- _ . -. .- - -. ._.-. .- ._-._ _l_ . .- .-.- .I. - . - . . . - r- . . .- I . ._ . .- . ._. . .- - ._ - - -.-I- - . .-.- . . .-. . . . -

12、. . -.-.- . -u- I- I-.I -_ .- . - .u- . .- . -. I.- . .I “. . - . . - .- . . . . 2 . . .:- . . . . . . I . - . - . . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-. . . + - :;: L . . MIL-D-1025 4C 3.3.1.1.1 Matching.- natural daylight (North Sky) o

13、r artificial daylight having a color temperature of 7500 degrees Kelvin and shall be a good apprgximation to the standard under incandescent lamplight at 2800 degrees Kelvin. combined bleaching and laundering, we t-dry cleaning and light The color shall be matched to the standard under , 3.3.1.1.2 C

14、olorfastness,- The dyed yams shall show good coloafastness to e. 3.3.2 Thread.- Tne tiiread for binding the loops shall be.cotton,*un- bleached conforming to type IA1, 3 ply, ticket No. 30 of V-T-276. 3.4 .De tails of components. - 3.4.1 Cord.- The finished cord shall consist of a braided cotton cov

15、er over sufficient cotton stuffer yarns to insure a diameter of 3/16 inch Pius or minus 1/32 inch. The cotton cover shall be braided on a-16 carriermachine.three ends per carrier of yarn specified in 3.3.1 with not less than 24 picks per inch in a two over two under plain braid. 3.4.2 Wrappiw Cord,-

16、 The finished wrappinq.gxd Shall-cLx-ist of a tubu- lar braided cover over sufficient qtuffer yam to insure a diametex of 3/32 inch plus or minus 1/32 inch. The cott%GYve?-shall be-braided on an 8 carrfer machine, ftro ends per carrier from yarn specified-i 3.3.1,with not less than 14 picks per inch

17、 in a one over, one under, basket braid, - _ - - . . . . . . . - . * 3.4.3 Swivel snap,- The swivel snap shall be made from any type brass and shall conform to the details and dimensions of drawing B-10-12. snap shall be 24 karat gold plated and completely lacquered. The swivel 3.5 Construction.- Th

18、e lanyard shall be constructed in accordance with the details and dimensions shown on drawing B-10-12, identified as figure 1 and the requirements specified herein. The loops shall have an inside measurement of 1 inch plus or minus 1/8 inch and the swivel snap shall be attached to one of the loops.

19、by folding the cord on itself and binding it with not less than 4 turns or more than 6 turns of thread specified in 3.3.2. fastened. After the loops have been formed, the ends shall be wrapped with not less than seven or more than nine turns of wrapping cord specified in 3.4.2 with the loose ende-tu

20、cked and securely fa-ened under the turns of the wrapping cord. The finished ovsraJ1 length of the lanyard, excluding the swivel snap shall be 34 inches plus or minus 1/2 inch, The lanyard shall have a loop at each end. The loops shall be formed The ends of the thread shall be securely 3 3.6 6orlana

21、nship.- The lanyard shall be clean, well made and shall meet the quality levels established by this specification. 4. QUALITY ASSURANCE PROVISIONS 4.1 Responsibility for inspection.? Unless otherwise specified in the contract or purchase arder, the supplier is responsible for the performance inspect

22、ion requirements as specified herein. Ex.cept es otherwise specified in the contract or purchase order, the supplier mg-use his own or any other facilities suitable for the performance of the inspection requirements specified herein, unless disapproved by the Government. of all The Government reserv

23、es the right to perfom 3 . . . . . . , . . - I. I Il?- I . I- ,. -. . .-. . . - , . , _ _ -. . i.:;. . LI* - _,-.a. Li .I . . . “ . . . c-l_.-. . .- . “dC i . -. _ . , . . * . . - -_-_.- - . . .:.:.:,:i . - -.-.-u_ _._ .- ,_ c_. _.-.- -.- _-.-. . “ . . - . _ _.- . , -. . .-i. .-. .-.-. _.I. . . . .

24、. . /.- -.- I p I-. L-“ . .-e “-“- I:“: , . ) tt:-:c:“:.*: ,*.I . )._ . I . I . . i . . . . . . . . . . . . -._ . a 1.-.- . . . . . -. . . . - . r . _._- ._. _ C.-r . -.“. . . . . .1._.1._.-.-_.*-(:.-.-.*T . .*. . i ?.I . . . . .r . A.? . . . ,. _ ._._-. “ . -.e. - i -. _I. _ .“ _- . ,_ -.- _ ._* .

25、Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-D-10254C any of the inspections set forth in the specification where such inspections are deemed necessary to assure supplies and services conform to the prescribed requirements. . 4.2 First article

26、 inspection.- Inspection and testing of .the first article shall be made on a completely finished lanyard for all provisions of this specification applicable to end product examination and test. 4.3 Inspection for acceptance.- Inspection shall be in accordance with provisions set forth in MIL-STD-10

27、5, except when otherwise specified hereafter; *i 4.3.1 Testing of components.- In addition to the quality assurance -_ provicions of the subsidiary specifications and drawings, components shall te tested as specified in table I. a“ test method specifed in Fed-Std-191. sample. unit requirements shall

28、 be 6.5 defects per hunderd units. tests shall be one cone, sDool or tube. . When data in the “#detem per s/u“ and “Results reported columns are not specified in table I, they shall be as required by the individual The inspection level shall be S-1 and the acceptable quality level for sample All req

29、uirements are applicable for the individual The sample unit for these 4 /.;:.y . . . - f - . . . . * . _ . - 1.- 1: ,: . L - . JX:.: L . px.zzXx;:;: I: . .- ,. . -.- . . . _- -._-.- -_. -.-.- . ._ . “ i ., . . - -_ _.- ,.-.-.-.- -.- I _ .- CI . . _. I I _ . . . . . . . . . . :.:.=.:-.:-.:. . . . . .

30、 . . . :. 1 I :. . “. -. . .-ri-i-rr.rLii.-i-. r-*-.I-.-.-.-.I- . _L.l-. -.L_ -_ _.-_ .-.I1 I .-I - . . .-. . - - - . . “ . . . . _-_ . _. . ._.-. . - .: . .lIII.I_l.-. . . “._A I . .- . . _I.r. , , . ,. . . . . i.: I . ii.7.1r.i- i . - .-. -_-_. - . -.-.-.- _. . .a . . . . ). . .- . I . . -: . .- .

31、 -.-. . . .-* . -.-_. . - _-_ I -.-.- - . , -.- _.- .-._ . -_. . _ -.- . -.-_ _._ ,. - “ b . . -.-.-.- . . . . i . . - . . . . . . * . . ,-. *.-,- . . . . . . - . . * . . I: .-. . i . . . . . . . ._ . . -._ C._ . .- . -. b. .-. . u . %- ,-,., .- -.- .-. . . - . . I _- . . . -I-L -.- -_.- 1 .-. I-.-

32、- . .- . -._.- ._ . _. . . - . L. -.- . I. . . - . . . -. . . . I _._.- . . . . . -qi . . - . . . -.:;:i: . ( . . e: . ,. ,: . , . . . “ . . . . . . . . . -, . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-. - . . .- - . . I. . . . I . . i . _-. .

33、I.- _I. ,._. - . , . . . . c _, - . I - . - . . . . . -.-.-. -. -. .-. . . ._ “_-_-I. ,-.- L. .-,.- ._- _.u- .-. I-.*“ _-&-.I. . -._ I . . . .-.- -. - i . . - -. ,- . -.“ 1:. .- K*E.E.-. I. “. . I .- + . ds NI: _ II. _III_._ ._._._ * . -_ _-. , -.* .- s.- .-.u .- .-. . i . ,. t . , -_ - .- . :.,. .

34、-.-:-.- . .- . . .-.-. . .- . -.- -.-. - -. . . . . “. -._.-a I._ - . . _ -. - . . .- .-_. I -I-.-. _ c- II.- I. -. - . . p- .- - . . I -.-. - . -. . . . , . . i . .-. “.I -.- . ._-.,- . . 1. . “ . . . . . -._.- “. . , .- ._-_-_._A . _-. “ -_. _- - . . *_ . _-. -1 - -.-.-. . -._. r-_.If.- . .-_ -. .

35、 . . -.-.-. . .- . I . ._-. . -.- ,. ! . . , . . . . . . . . $ .- h! . hh$ $hag . b, 8 e 8 i I.-.-.- .-._ .-.l._._F ,- -.-.-.- ._ -.- L_-.- _I- .- I -.U-.- . p-.- . I_ ._ ,_-I-. I. . -_- -._-_.- -.-_ . _I_c - -.- .- . - - . ._ . . CI-9 _-.-.-.- ell- .- -_- c -.-. - .-.- . - - - .- . I -. . . .-. -_._“I .- . .- . . ,.-.-. - .-. - .- - -_ -.-_._. ._ -. _ .-. . - ,-I.- -. _ - . . . .-. . . . . .-. F ._.I . “.i - Q . -.-_-II- . . . . . FIGURE 1 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-