ARMY MIL-B-63094 B-1978 BLASTING MACHINE 50 CAP M34《10 CAP容量爆破机》.pdf

《ARMY MIL-B-63094 B-1978 BLASTING MACHINE 50 CAP M34《10 CAP容量爆破机》.pdf》由会员分享，可在线阅读，更多相关《ARMY MIL-B-63094 B-1978 BLASTING MACHINE 50 CAP M34《10 CAP容量爆破机》.pdf（63页珍藏版）》请在麦多课文档分享上搜索。

1、MILIB-63094B (AR) 24 July 1978 S UEERSEDING MIL-B- 63094A (AR) 30 November 1977 MILITARY SPECIFICATION BLASTING MACHINE, 50 CAP, M34 , This specification is approved for use by the U.S. Army Armament Research and Development Command, and is available for use by all Departments and Agencies of the De

2、partment of Defense. I 1. SCOPE 1.1 This specification contains requirements not nor- mally covered by the drawings and provides quality assurance provisions for the fabrication inspection, test and packing for a generator blasting machine designated as the Blasting Machfne, M34. 2. APPLICABLE DOCUM

3、ENTS 2.1 Issues of documents. - The following documents of the issue mct on date of invitation for bids or request for proposals, form a part of this specification to the extent specified herein. SPECIFICATIONS FEDERAL PPP-T-45 - Tape, Gummed, Paper, Reinforced and PPP-B-621 - Boxes, Wood, Nailed an

4、d Lock-corner PPP-B-636 - Box, Fiberboard Plain, for Sealing and Securing . MILITARY MIL-P-116 - Preservation, Methods of MIL-B-117 Packaging MIL-S-4473 - Shieldin Magnetron Tubes and - Bag, Sleeve and Tubing - Interior Magnets B or Air Shipment FSC: 1375 Beneficial comments (recommendations, additi

5、ons, deletions) and any pertinent data which may be of use in improving thin document ahould be addressed to: Commander, US Army Armament Research and Development Command, Attn. DRDARQA, Dover, New Jersey 07801 by using the self-addressed Standardization Document Improvement Proposal (DD Form 1426)

6、appearing at the end of this document or by letter. UhEiUT CONTAINS PA45OC -5OC to 52OC +SOC) and in accordance with 4.5.6. 3.7 Service life cycle. - The blasting machine shall 3.8 Extreme temperature performance. - The blasting 3.9 Temperature storage, - The blasting machine shall be capable ot fun

7、ctioning and complying with the requre- ments of 3.3 after seventy two (72) hours of storage and testing as specified in 4.5.7. 3.10 Insulation resistance, - The blasting machine shall conipxy with the requirements of 3.3 after having five hundred volts alternating current (500 VAC) applied between

8、case and each output terminal. for a minimum of ten (10) seconds and. there shall be no evidence of current leakage in excess of ten (10) micro- amperes, The voltage shall be applied Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-B-63094B 13 = 7

9、777906 0343620 7 W - _ MIL-B-63094B (AR) 3.11 Humidit . - The blasting machine shall operate within the requiremd 3.3 after exposure to twenty (20) hours of relative humidity between ninety .two (92) and ninety seven (97) percent at air temperatures from twenty seven degrees Centigrade plus five deg

10、rees Centigrade (27 % + 5 Q) followed by four (4) hours plus one (1) hour of one hundred (100) percent relative humidity with condensation at twenty five degrees Centigrade plus five degrees Centigrade (25 Q + 5%). 3.12 Unactivated voltage. - The output voltage across the output terminals shall be o

11、ne tenth (0.1) volt or less within ten (-10) seconds after the device has complied with the requirements of 3.3 and it is tested in accordance with 45.10. I 3.13 Test temerature. - All testing shall be performed at a temperature of twenty five degrees centi rade plus or otherwise. minus five degrees

12、 centigrade (25% +, 5Q) un f ess specified 3.14 Data requirements. - Data as required by test method paragraphs 4.5 shall be retained as specified in - - 4.5.16. 3.15 Workmanshi * - All parts and assemblies shall be fabricate First article inspection. b. Quality conformance inspections. 4.3 First ar

13、ticle inspection I 4.3.1 Submission. - The contractor shall submit a first article sample as designated by the Contracting Officer for evaluation in accordance with provisions of 4.3.2. The first article sample shall consist of twenty five (25) sets of ail components, sub-assemblies and assemblies.

14、4.3.2 Inspections to be performed. - See MIL-A-48078 and Table I specitied herein. 4.3.3 Rejection, - See MIL-A-48078. 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-n l% 4: U MIL-B-63074B 13 = 7777706 0343622 O N 07 ck m h! M N M cn N Ln N Ln N L

15、n N v) + u aJ U c v) + u Q: L -0 icc I 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-B-b3094B 13 m 9977906 0343623 2 mi C c“. 5 a ? c: 3 J k -0 Fw $ ar 7 Provided by IHSNot for ResaleNo reproduction or networking permitted without license fro

16、m IHS-,-,-MIL-B-b3074B 13 W 777770b 0343b24 4 W f ;f m c & id 0 O in n n al fi 4 J= o id c M fi -4 c, v1 id rl a 2 3% U fa k na m o Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-B-b309i.1B 13 9737906 03i.13625 b C “3 IC ac LO !a a i L B rt o c

17、4 rd U O In n al F: -4 c c) rd c M fi .rl ci rA rd rl PI n I I In e4 3% 3% 3% 9 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-r Y I- MIL-B-63079B 13 7779906 03V362b (u v d c n Q) = m c I I 10 Provided by IHSNot for ResaleNo reproduction or networki

18、ng permitted without license from IHS-,-,-IML-B-b3074B 13 777770b 0343b27 T m v) QI Cu e . . I *be x O00 O ebb O O00 F .o. . n .I- r ul K lu E Y L O I L O O 4- O aJ u K aJ W w n *I- 24 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- O U U W 0- j v)

19、lL U * U -I 3 - MIL-B-63094B 13 W 9999906 0343641 4 9 LD o N“ “NI- mmmmm mmmm beaQMbetR Ha-ebeM 00000 u)LDu)O *e* mDlD-0 00000 oool- o,. U W E cc W U QI E O TL- .I- L W w W E cec U W L UL O *F cec L L C Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,

20、- O H + V w n v, U w V z 2 O LL zz O o * I- e U L =I P v, rn L P 7 . N * * . . rn NNNN 7 mmmm m beaebeae O000 *e- O000 M O O b F- U QI E W E O L LVI O0 LP LE so U LaJ n *r I: v) E lu E Y L O 3 L O O P ic O W u E al U *r w 26 Provided by IHSNot for ResaleNo reproduction or networking permitted withou

21、t license from IHS-,-,-MIL-B-63094B 13 7999906 0343643 m I- B c B h n E al v) v) P Y U Q cr: L Q al a Ln “ cul- mmmm mm .a bpbpbpbp bpbe O000 v)O *e*+ -0 O000 OI- I U al E cc al U W E: O z v- cc O L aJ cc al E Y a U r L a u WL o, n I- c v) E a E Y L O 3 L CO co al ccc O Y- ow U LE alal E *f- a SLW a

22、n n-a i! O =. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-B-63094B 13 m 9999906 03113644 T m rl 8 rl k E c: O .rl (o (o Q) u U.? mmmm n cb C FI v k (o 28 c m W t aJ e $ O ai t c PI E *I- V) O c E s Y i! t lu c w lu w c lu al c r u Q aJ E ce t

23、 aJ c u ai aJ V) e P c Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-E Y Y Y n 8 Z i U ln N“ c mmm 0 . . =behe he O00 O u-+* O O00 I- . xx mia E n a? mm J= wln v) uu E mia aJaJ LL ZJ= .Po w .I- I 3 2 29 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-E W Y Y n 8 Z O 5 f 3 9 u - MIL-B-6309B 13 9799906 0393646 3 W 8 14 d C I d ! 8 d $2 d pi 6i O 30 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-