UL 484-1999 Room Air Conditioners.pdf

《UL 484-1999 Room Air Conditioners.pdf》由会员分享，可在线阅读，更多相关《UL 484-1999 Room Air Conditioners.pdf（138页珍藏版）》请在麦多课文档分享上搜索。

1、UL 484ISBN 1-55989-302-8Room Air ConditionersFebruary 24, 1999 UL 484 tr1Underwriters Laboratories Inc. (UL)333 Pfingsten RoadNorthbrook, IL 60062-2096UL Standard for SafetyforRoom Air Conditioners, UL 484Seventh Edition, Dated April 27, 1993Revisions: This Standard contains revisions through and in

2、cluding February 24, 1999.The revisions dated February 24, 1999 include a reprinted title page (page 1) for this Standard.The revisions dated February 24, 1999 were issued to correct editorial errors.As indicated on the title page (page 1), this UL Standard for Safety is an American National Standar

3、d. Attention isdirected to the note on the title page of this Standard outlining the procedures to be followed to retain the approved textof this ANSI/UL Standard.As indicated on the title page (page 1), this UL Standard for Safety has been adopted by the Department of Defense.The master for this St

4、andard at ULs Northbrook Office is the official document insofar as it relates to a UL service andthe compliance of a product with respect to the requirements for that product and service, or if there are questionsregarding the accuracy of this Standard.ULs Standards for Safety are copyrighted by UL

5、. Neither a printed copy of a Standard, nor the distribution diskette fora Standard-on-Diskette and the file for the Standard on the distribution diskette should be altered in any way. All of ULsStandards and all copyrights, ownerships, and rights regarding those Standards shall remain the sole and

6、exclusiveproperty of UL.All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any formby any means, electronic, mechanical photocopying, recording, or otherwise without prior permission of UL.Revisions of UL Standards for Safety are issue

7、d from time to time. A UL Standard for Safety is current only if itincorporates the most recently adopted revisions.UL provides this Standard as is without warranty of any kind, either expressed or implied, including but not limited to,the implied warranties of merchantability or fitness for any pur

8、pose.In no event will UL be liable for any special, incidental, consequential, indirect or similar damages, including loss ofprofits, lost savings, loss of data, or any other damages arising out of the use of or the inability to use this Standard, evenif UL or an authorized UL representative has bee

9、n advised of the possibility of such damage. In no event shall ULsliability for any damage ever exceed the price paid for this Standard, regardless of the form of the claim.tr2 February 24, 1999 UL 484UL will attempt to answer support requests concerning WordPerfect, Envoy, and Standards-on-Diskette

10、. However, thissupport service is offered on a reasonable efforts basis only, and UL may not be able to resolve every support request.UL supports a Standards-on-Diskette only if it is used under the conditions and operating systems for which it isintended. ULs support policies may change from time-t

11、o-time without notification.UL reserves the right to change the format, presentation, file types and formats, delivery methods and formats, and thelike of both its printed and electronic Standards without prior notice.Standards-on-Diskette purchasers agree to defend, indemnify, and hold UL harmless

12、from and against any loss,expense, liability, damage, claim, or judgement (including reasonable attorneys fees) resulting from any error ordeviation introduced while purchaser is storing a Standard-on-Diskette on the purchasers computer system.If a single-user version Standards-on-Diskette was purch

13、ased, one copy of this Standard may be stored on the harddisk of a single personal computer, or on a single LAN file-server or the permanent storage device of a multiple-usercomputer in such a manner that this Standard may only be accessed by one user at a time and for which there is nopossibility o

14、f multiple concurrent access. The original distribution diskette should be stored in a safe place.If a multiple-user version Standards-on-Diskette was purchased, one copy of the Standard may be stored on a singleLAN file-server, or on the permanent storage device of a multiple-user computer. The num

15、ber of concurrent users shallnot exceed the number of users authorized for the Standards-on-Diskette version. The original distribution disketteshould be stored in a safe place.Standards-on-Diskette are intended for on-line use, such as for viewing the requirements of a Standard, conducting aword se

16、arch, and the like. Only one copy of the Standard may be printed from each single-user version of a Standards-on-Diskette. Only one copy of the Standard may be printed for each authorized user of a multiple-user version of aStandards-on-Diskette. An employee of an organization purchasing a Standard-

17、on-Diskette can make a copy of thepage or pages being viewed for their own fair and/or practical internal use. Because of differences in thecomputer/software/printer setup used by UL and those of Standards-on-Diskette purchasers, the printed copy obtainedby a purchaser may not look exactly like the

18、on-line screen view or the printed Standard.The requirements in this Standard are now in effect, except for those paragraphs, sections, tables, figures, and/or otherelements of the Standard having future effective dates as indicated in the note following the affected item. The priortext for requirem

19、ents that have been revised and that have a future effective date are located after the Standard, andare preceded by a SUPERSEDED REQUIREMENTS notice.New product submittals made prior to a specified future effective date will be judged under all of the requirements inthis Standard including those re

20、quirements with a specified future effective date, unless the applicant specificallyrequests that the product be judged under the current requirements. However, if the applicant elects this option, it shouldbe noted that compliance with all the requirements in this Standard will be required as a con

21、dition of continued Listing,and Follow-Up Services after the effective date, and understanding of this should be signified in writing.Copyright 1999 Underwriters Laboratories Inc.February 24, 1999 UL 484 tr3This Standard consists of pages dated as shown in the following checklist:Page Datetr1 tr4 .

22、February 24, 19991 . April 27, 1993 (Reprinted: February 24, 1999)2 . October 28, 19983 . April 27, 19934 . October 28, 19985 . February 5, 19986 . October 28, 19987 19 . April 27, 199320 . August 6, 199621 . April 27, 199322 24, 24A, 24B, 25 . October 28, 199826 29 . April 27, 199330 . November 12,

23、 199331 40 . April 27, 199341 . October 28, 199842 . April 27, 199343, 44, 44A, 44B . October 28, 199845 50 . April 27, 199351, 52, 52A, 52B . May 2, 199653 . February 5, 199854 . April 27, 199355 58 . June 24, 199759, 60 . April 27, 199361, 62, 62A, 62B . October 28, 199863 . April 27, 199364 66, 6

24、6A, 66B . October 28, 199867 72 . April 27, 199373 . May 2, 199674, 74A, 74B . June 24, 199775 83 . April 27, 199384 . August 6, 199685 . April 27, 199386 . August 6, 199687 . June 24, 199788 . April 27, 199389 . June 24, 199790 . October 28, 199891 . April 27, 199392, 92A, 92B, 93 96 . October 28,

25、199897, 98 . April 27, 199399, 100, 100A, 100B, 101 . May 2, 1996102 110 . April 27, 1993A1, A2 . October 28, 1998CRG1 . February 5, 1998CRG2, CRG3 . February 24, 1999CRG4 . February 5, 1998tr4 February 24, 1999 UL 484No Text on This PageAPRIL 27, 1993 ANSI/UL 484-1995 (Title Page Reprinted: Februar

26、y 24, 1999)1UL 484Standard forRoom Air ConditionersFirst Edition August, 1954Second Edition September, 1957Third Edition December, 1961Fourth Edition January, 1972Fifth Edition March, 1973Sixth Edition March, 1982Seventh EditionApril 27, 1993Approval as an American National Standard (ANSI) covers th

27、e numbered paragraphson pages dated April 27, 1993 and November 12, 1993. These pages should not bediscarded when revised or additional pages are issued if it is desired to retain theANSI approved text.An effective date included as a note immediately following certain requirements is oneestablished

28、by Underwriters Laboratories Inc.Approved as ANSI/UL C33.14 1972, October 27, 1972Approved as ANSI/UL 484 1986, February 12, 1986Approved as ANSI/UL 484 1995, April 17, 1995The Department of Defense (DoD) has adopted UL 484 on February 5, 1993. Thepublication of revised pages or a new edition of thi

29、s standard will not invalidate theDoD adoption.Revisions of this standard will be made by issuing revised or additional pages bearingtheir date of issue. A UL Standard is current only if it incorporates the most recentlyadopted revisions, all of which are itemized on the transmittal notice thataccom

30、panies the latest set of revised requirements.ISBN 1-55989-302-8COPYRIGHT 1973, 1999 UNDERWRITERS LABORATORIES INC.2 ROOM AIR CONDITIONERS UL 484 OCTOBER 28, 1998No Text on This PageAPRIL 27, 1993 ROOM AIR CONDITIONERS UL 484 3CONTENTSFOREWORDINTRODUCTION1 Scope . 72 General . 73 Glossary . 84 Insta

31、llation and Operating Instructions . 9CONSTRUCTION5 General . 106 Assembly . 107 Accessories . 158 Enclosures . 169 Polymeric Materials . 2110 Mounting Hardware . 2511 Field Supply Connections . 2512 Internal Wiring . 3013 Separation of Circuits . 3414 Bonding for Grounding . 35ELECTRICAL COMPONENTS

32、15 Capacitors . 3816 Current-Carrying Parts . 3917 Electric Air Heaters . 3918 Fuseholders and Circuit Breakers . 4019 Insulating Material . 4120 Motors and Motor Overload Protection . 4121 Switches and Controllers . 4522 Transformer Protection . 4723 High-Voltage Control Circuit Conductor Overcurrent Protection . 49ELECTRICAL SPACINGS24 High-Voltage Circuits . 5125 Low-Voltage Circuits . 53REFRIGERATION SYSTEM26 Refrigerant . 5327 Pump-Down Capacity .