NAVY A-A-50427-1996 CLEANING COMPOUND SOLVENT 1 1-DICHLORO-1- FLUOROETHANE HCFC-141B FOR OXYGEN SYSTEMS《HCFC-141B型氧气系统的1-DICHLORO-1 氟石1溶解洗涤剂》.pdf

《NAVY A-A-50427-1996 CLEANING COMPOUND SOLVENT 1 1-DICHLORO-1- FLUOROETHANE HCFC-141B FOR OXYGEN SYSTEMS《HCFC-141B型氧气系统的1-DICHLORO-1 氟石1溶解洗涤剂》.pdf》由会员分享，可在线阅读，更多相关《NAVY A-A-50427-1996 CLEANING COMPOUND SOLVENT 1 1-DICHLORO-1- FLUOROETHANE HCFC-141B FOR OXYGEN SYSTEMS《HCFC-141B型氧气系统的1-DICHLORO-1 氟石1溶解洗涤剂》.pdf（7页珍藏版）》请在麦多课文档分享上搜索。

1、c A-A-50427 = 9999974 0171423 392 b i NOT MEASUREMENT SENSITIVE June 26, 1996 A-A-5 0427 COMMERCIAL ITEM DESCRIPTION CLEANING COMPOUND, SOLVENT, 1,l-DICHLORO-1 -FLUOROET“E, HCFC-l41B, FOR OXYGEN SYSTEMS The General Services Administration has authorized the use of this commercial item description by

2、 all federal agencies. I. SCOPE. This commercial item description (CID) covers the requirements for 1,1 -dichloro- 1 -fluoroethane cleaning compound solvent for use in oxygen system cleaning. 2. SALIENT CHARACTERISTICS. 2.1 Material. The cleaning compound shall be a solvent of 1,l-dichloro-1-fluoroe

3、thane (Chemical Abstract Service CAS Registry Number 17 17-00-6, hydrochlorofluorocarbon, HCFC- 14 1 b). 2.2 Chemical and phvsical properties. The solvent cleaning compound shall conform to the requirements of table I. 2.3 Material safetv data sheets. A material safety data sheet shall be prepared a

4、nd submitted in accordance with FED-STD-3 13, meeting the requirements of Code of Federal Regulation 29 CFR 1910.1200. Questions pertinent to the effect of the cleaner on the health of personnel when used for its intended purpose shall be referred by the acquiring activity to the appropriate medical

5、 service who shall act as adviser to the acquiring activity. 2.4 Shelf life. The 1,1-dichloro-1-fluoroethane shall meet the specified requirements in table I after storage in unopened containers for not less than one year. 2.5 Product appearance. The solvent shall be a clear, colorless liquid (water

6、 white) with no evidence of particles. The appearance shall be determined by visually examining 500 mT, of solvent for clarity, color, and solids in a clear container against a white and black background. The inspection shall be performed by a person with normal visual acuity, natural or corrected,

7、Beneficial comments, recommendations, additions, deletions, clarifications and any other data which may improve this document should be sent to: Commander, Naval Air Warfare r Center Aircraft Division, Code 414100B120-3, Highway 547, Lakehurst, NJ 08733-5100. Provided by IHSNot for ResaleNo reproduc

8、tion or networking permitted without license from IHS-,-,- A-A-50427 9999974 0373424 229 M i A-A-SO427 under bright light of not less than 1 O0 foot-candles. A general purpose flashlight with 2 fresh batteries and a fresh lamp, positioned 18 inches perpendicular to a surface will illuminate that sur

9、face with an intensity of not less than 100 foot-candles. TABLE I. Chemical and phvsical properties. Property Boiling point 760 mm barometric pressure Chemical purity, % min by weight Impurities Moisture content, pp4 may by wt. Chloride ion, ppm, max, by wt. Nonvolatile residue, ppm, may by wt. Acid

10、 number, mg KOWgm sampl, max Particle matter, number of particles greater than 50 microns - 1/ Contractor test procedures equivalent to Requirement 32.0 rtO.2 C (89.6 k0.4 F) 99.9 Other halogenated solvents 10 o. 1 5 0.003 None Test Procedure l/ ASTM D 1078 ASTM D3447 ASTM D3447 ASTM D3401 ASTM D344

11、3 ASTM D2 1 O9 or ASTM F33 1 ASTM D3444 See 2.5 lose specified may be substituted. 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-50427 I 9999974 OLL425 Lb5 I A-A-50427 2.6 Safetv warning labels. Containers shall be marked with warning labels

12、as follows: DICHLOROFLUOROETHANE HCFC- 14 1 b Eye contact with vapor causes irritation. Contact with liquid can cause chemical bums. Prolongedkepeated skin contact may cause dryness/irritation. Exposure can also result in freezing of skin tissue (frost bite). Over-exposure to vapor may cause respira

13、tory system irritation, headache, dizziness and central nervous system (CNS) depression. Exposure to higher levels may also result in increasing sensitivity of the heart to adrenaline. Cardiac arrhythmia could result. Exposure to very high levels could result in death due to dilutioddisplacement of

14、available oxygen, resulting in death by asphyxiation. Low areas are especially susceptible to oxygen displacement. Taste/odor do not provide adequate warning of high vapor levels. Do not use in the general vicinity of welding, open flames or hot surfaces. This could result in the decomposition of th

15、is material to irritating and toxic gases and carbonyl halides. In case of spills/significant release to work space, warn others and leave immediately. Use smallest quantity possible to properly perform the operation. Use only with adequate ventilation. Refer to Material Safety Data Sheet for additi

16、onal information and required precautions for use. Consult medical department authority for guidance in control and proper use of this material, and specific requirements and methods for monitoring vapor levels in the workspace. Have an emergency escape breathing device (EEBD) immediately available

17、for any operation where overexposure to product could occur unless immediate escape to a vapor-free area is possible. Be sure you are trained in the proper care, inspection, and use of this device. Ensure storage areas that contain this product are properly ventilated prior to entry. 3 Provided by I

18、HSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- A-A-50427 9999974 OL7L426 OTL A-A-5 0427 FIRST AID Inhalation: Immediately remove person to fresh air. If breathing has stopped, give artificial respiration. In cases of excessive exposure, pay particular attention

19、 to the potential for cardiac arrhythmia. Oxygen may be used in treating such cases if administered by medical department personnel. Use of vaso-pressor drugs, for example epinephrine (adrenaline), is inadvisable because these drugs may induce cardiac arrhythmia. If high temperature decomposition pr

20、oducts may have been inhaled, observe the patient for immediate or delayed signs of pulmonary edema. In any of these cases, obtain prompt medical attention. NOTE TO PHYSICIANS: Overexposure to dichlorofluoroethane has caused cardiac sensitization to epinephrine. Cardiac arrhythmia, including ventric

21、ular fibrillation could occur if epinephrine or one of its congeners is administered to patients exposed to high concentrations of dichlorofluoroethane. Medical use of epinephrine or any of its congeners is contra-indicated except for patients with no arterial profusion. Skin contact: If pain or fre

22、ezing of tissue occurs, seek prompt medical attention. If no freezing of the skin is apparent, wash areas with wann water. If material soaks through clothing, remove clothing and wash skin with soap or mild detergent and water. If irritation persists after washing, obtain medical attention. Do not r

23、e-use contaminated clothing until it is thoroughly cleaned to remove the material. Eye contact: Immediately wash with large amounts of potable water for a minimum of 15 minutes. Avoid use of any other agents such as oil or saline solutions in the eye. Use of any other agent or dressing should only b

24、e administered by the cognizant medical department representative. Contact lens should not be worn when using this chemical. Ingestion: Do not induce vomiting. Seek medical attention. 2.7 Delivery options. The 1,1-dichloro-1-fluoroethane may be delivered in 5 or 55 gallon drums, or in bulk container

25、s (tank truck, tank railroad car). that have been precleaned. Precleaning includes all caps for the containers. 4 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-c A-A-50427 9999974 0373427 T38 = A-A-50427 3. REGULATORY REQUIREMENTS. 3.1 Environmenta

26、l considerations. The product delivered under this CID shall be in accordance with the environmental requirements of Code of Federal Regulation 40CFR. 3.2 Transportation. The transportation of the product delivered under this CID shall be in accordance with Code of Federal Regulations 49 CFR 17 1- 1

27、90. 4. QUALITY ASSURANCE PROVISIONS. 4.1 Contractor certification. The contractor shall certiQ and maintain substantiating evidence that the product offered meets the salient characteristics of this commercial item description, and that the product conforms to the producers own drawings, specificati

28、ons, standards, and quality assurance practices, and is the same product offered for sale in the commercial marketplace. The government reserves the right to require proof of such conformance prior to first delivery and thereafter as may be otherwise provided for under the provisions of the contract

29、. 4.1.1 Derivation of substantiating evidence of corndiance. The contractor is requested to derive substantiating evidence of compliance using the following sampling: a. Sampling 5 and 55 gallon containers:, Remove a 1-liter sample for testing in accordance with table I. b. Sampling bulk containers

30、for testing in accordance with table I: (1) When the container is equipped with a pumping system that will completely recirculate its contents within one hour, take samples at intervals of one and two hours after initiation of recirculation. When the contents of the container cannot be thoroughly ci

31、rculated, take three samples in accordance with ASTM-E300 representing the top, middle, and bottom sections. (2) 4.2 Market acceptability. The following market acceptability criteria are necessq to document the quality of the product to be provided under this commercial item description: a. The comp

32、any furnishing the solvent cleaning compound must have been producing a product meeting the requirements of this commercial item description for at least 6 months. b. The company must have offered the solvent cleaner to a government laboratory for inspection. 5 Provided by IHSNot for ResaleNo reprod

33、uction or networking permitted without license from IHS-,-,-A-A-50427 5. PACKAGING. 5.1 Preservation. packing and marking. Preservation, packing, and marking shall be as specified in the contract or order. 6. NOTES. 6.1 Source of documents. 6.1.1 Copies of the Code of Federal Regulations (CFR) may b

34、e obtained from the Superintendent of Documents, US Government Printing Office, Washington DC 20402. 6.1.2 Federal Government activities may obtain copies of Federal Standard Nos. 3 13 and 709 from established distribution points within their agencies. Other activities may obtain the standards for b

35、idding purposes from the General Services Administration, Federal Supply Service Bureau, Specification section, Suite 8 100,479 LEnfant Plaza, SW, Washington, DC 20407. 6.1.3 The following test methods are available from the American Society for Testing and Materials, 100 Barr Harbor Drive, West Con

36、shohocken, PA 19103: ASTM-D 1078 ASTM-D2 1 O9 ASTM-D340 1 ASTM-D3443 ASTM-D3444 ASTM-D3447 ASTM-E300 ASTM-F33 1 Test Method for Distillation Range of Volatile Organic Liquids Test Method for Nonvolatile Matter in Halogenated Organic Solvents and their Admixtures Test Method for Water in Halogenated

37、Organic Solvents and their Admixtures Test Method for Chloride in Trichlorotrifluoroethane, Test Method for Total Acid Number of Trichlorotrifluoroethane Test Method for Purity of Trichlorotrifiuoroethane Practice for Sampling Industrial Chemicals Test Method for Nonvolatile Residue of Halogenated S

38、olvent Extract from Aerospace Components (Using Rotary Flash Evaporator) 6.2 Government laboratory. Manufacturers wanting to have their cleaning compound solvent inspected may do so by contacting the Naval Air Warfare Center Aircraft Division, Mail Stop 3, Bldg 2188, Code 4.3.4.1,48066 Shaw Road, Pa

39、tuxent River, MD 20670-5304. 4 6.3 m. The use of this compound for cleaning oxygen systems should be accomplished only with approved procedures. 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-c MILITARY INTERESTS: A-A-50427 E 9999974 0171429 800 Custodians: Army - EA Navy - AS Air Force - 68 A-A-50427 Preparing Activity: Navy - AS DoD Project 6850-1 173 7 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-