GMKOREA EDS-T-9002-1998 WHEEL ARTICULATION TEST.pdf

《GMKOREA EDS-T-9002-1998 WHEEL ARTICULATION TEST.pdf》由会员分享，可在线阅读，更多相关《GMKOREA EDS-T-9002-1998 WHEEL ARTICULATION TEST.pdf（5页珍藏版）》请在麦多课文档分享上搜索。

1、DAEWOO MOTOR CO., LTD. EDS Engineering, Daewoo motor co., ltd. Standards WHEEL ARTICULATION TEST EDS-T-9002 ISSUED DATE: 1998. 01. 15 REVISED DATE: - VERSION: 1 Copyright Daewoo Motor Co., Ltd. All rights reserved PUBLISHED BY ENGINEERING STANDARD SECRETARIAT TECHNICAL CENTER (PUPYONG) WHEEL ARTICUL

2、ATION TEST EDS-T-9002PAGE: 1/4ISSUED DATE: 1998. 01. 15 REVISED DATE: - VERSION: 1 DAEWOO MOTOR CO., LTD. 1. PURPOSE This standard aims at checking presence of interference between tires and chassis and body parts. 2. SCOPE This standard applies to all passenger cars and MPV. 3. TEST EQUIPMENT 3.1.

3、Steel ruler 3.2. Inside diameter gage 3.3. Vehicle lift 3.4. Portable lift 4. TEST PLACE DWMC Bupyong plant garage 5. TEST PREPARATION 5.1. Set vehicle weight to curb weight. 5.2. Test driver to be in drivers seat. 6. TEST PROCEDURES 6.1. Front tire (LH) wheel articulation measuring 6.1.1. Move the

4、vehicle to the lift. 6.1.2. Lift the test vehicle with the lift. 6.1.3. After removing all tires from the test vehicle, remove all springs. 6.1.4. After removal of springs, install only tires. WHEEL ARTICULATION TEST EDS-T-9002PAGE: 2/4ISSUED DATE: 1998. 01. 15 REVISED DATE: - VERSION: 1 DAEWOO MOTO

5、R CO., LTD. 6.1.5. Adjust the steering wheel accurately so that front tires will face forward (to be conducted by test engineer inside the vehicle). 6.1.6. Using the portable lift, lift tires to the top (to the point the test vehicle moves slightly). 6.1.7. Check presence of interference between the

6、 brake hose, stabilizer and other parts. 6.1.8. After checking, enter the status on the sheet. 6.1.9. After lowering the portable lift, adjust the steering wheel so that front tires will turn left to the full. 6.1.10. Using the portable lift, lift tires to the top again. 6.1.11. Check presence of in

7、terference between the brake hose, stabilizer and other parts. 6.1.12. After checking, enter the status on the sheet. 6.1.13. After lowering the portable lift, adjust the steering wheel so that front tires will turn right to the full. 6.1.14. Using the portable lift, lift tires to the top again. 6.1

8、.15. Check presence of interference between the brake hose, stabilizer and other parts. 6.1.16. After checking, enter the status on the sheet. 6.2. Front tire (RH) wheel articulation measuring 6.2.1. Repeat the above 6.1.5 to 6.1.16. 6.3. Rear tire wheel articulation measuring 6.3.1. Repeat the abov

9、e 6.1.5 to 6.1.8. 7. EVALUATION No interference between parts, such as the brake hose, stabilizer and control arm, or between tires and parts. 8. LEGAL REGULATIONS None WHEEL ARTICULATION TEST EDS-T-9002PAGE: 3/4ISSUED DATE: 1998. 01. 15 REVISED DATE: - VERSION: 1 DAEWOO MOTOR CO., LTD. 9. NOTES Non

10、e 10. ATTACHMENT Wheel articulation data sheet WHEEL ARTICULATION TEST EDS-T-9002PAGE: 4/4ISSUED DATE: 1998. 01. 15 REVISED DATE: - VERSION: 1 DAEWOO MOTOR CO., LTD. Appendix) : Wheel articulation data sheet Test vehicle : Test date : Test place : Tester : Body style : Results of the wheel articulation measuring ON CENTER LH FULL TURN RH FULL TURN Front tire (LH) FULL UP FULL DOWN Front tire (RH) FULL UP FULL DOWN Rear tire (LH) FULL UP FULL DOWN Rear tire (RH) FULL UP FULL DOWN