DLA MIL-S-22885 8 J-2010 SWITCH PUSH BUTTON ILLUMINATED MOMENTARY AND PUSH-PULL 2-CIRCUIT 5 AMPERES.pdf

《DLA MIL-S-22885 8 J-2010 SWITCH PUSH BUTTON ILLUMINATED MOMENTARY AND PUSH-PULL 2-CIRCUIT 5 AMPERES.pdf》由会员分享，可在线阅读，更多相关《DLA MIL-S-22885 8 J-2010 SWITCH PUSH BUTTON ILLUMINATED MOMENTARY AND PUSH-PULL 2-CIRCUIT 5 AMPERES.pdf（4页珍藏版）》请在麦多课文档分享上搜索。

1、AMSC N/A FSC 5930 INCH-POUND MIL-S-22885/8J 11 May 2010 SUPERSEDING MIL-S-22885/8H 16 May 2003 MILITARY SPECIFICATION SHEET SWITCH, PUSH BUTTON, ILLUMINATED MOMENTARY AND PUSH-PULL, 2-CIRCUIT, 5 AMPERES Inactive for new design after 21 July 1997, except for replacement purposes. This specification i

2、s approved for use by all Departments and Agencies of the Department of Defense. The requirements for acquiring the switches described herein shall consist of this specification sheet and MIL-PRF-22885. NOTES: 1. Dimensions are in inches. Metric equivalents are given for general information only. 2.

3、 Unless otherwise specified, tolerance is .03 (0.8 mm). 3. Alternative base metals and protective finishes, as approved by the qualifying activity, may be utilized for hexagon nut, lock washer, and key washer material. Dimensions shall be in accordance with the referenced hardware specifications. FI

4、GURE 1. Dimensions and configuration. Inches mm .003 0.08 .005 0.13 .015 0.38 .125 3.18 .25 6.4 .28 7.1 .38 9.7 .39 9.9 .44 11.2 .48 12.2 .500 12.70 .625 15.88 .94 23.9 2.27 57.7 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-S-22885/8J 2 REQUIR

5、EMENTS: Dimensions and configuration: See figure 1. Switch housings accept screw-in pushbuttons in accordance with MIL-S-22885/1. Pushbutton accommodates one midget flange base T-1-3/4 incandescent lamp. Enclosure design: 2 (dripproof). Temperature characteristic: -40C to +55C. Vibration grade: 2 (1

6、0 to 500 Hz, 10 g peak). Operation: A (momentary) or C (push-pull). Display type: C (colored background) Material: Case: Aluminum, clear anodized. Weight: 1.43 ounces maximum. Operating characteristics: Operating force: Momentary action switches: Initial: 4 1 pounds. After endurance testing: 2.5 pou

7、nds minimum. Push-pull switches: 1.5 pounds, approximately. Plunger travel: .080 .020 inch. Shock: Method I: Applicable, except maximum allowable contact opening is 500 microseconds. Method II (high impact): Applicable. Electrical ratings: See table I. Qualification: Table II applies when both momen

8、tary and push-pull action switches are submitted for qualification at the same time. Part or Identifying Number (PIN): M22885/8- (dash number from table III). Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-S-22885/8J 3 TABLE I. Electrical rating

9、s. Load 28 V dc (amperes) 115 V ac (amperes) Resistive 5 5 Inductive 3 3 TABLE II. Extent of qualification. Switch sample Tests of MIL-PRF-22885 qualification inspection table Extent of approval M22885/8-03 Groups I through VII ALL PINs M22885/8-52 Groups I, II, VI 2/, and VII M22885/1-01 through -0

10、5 1/(2 each color) Group VIII 1/ Pushbuttons may be installed on housings submitted to the tests of groups II through VII. 2/ Inductive dc load only. TABLE III. Dash numbers. Dash number Pushbutton M22885/1- Operation 01 None 1/Push-pull 02 None 1/Push-pull 03 01 (yellow, .81 round) Push-pull 04 02

11、(white, .81 round) Push-pull 05 03 (red, .81 round) Push-pull 06 04 (green, .81 round) Push-pull 07 05 (blue, .81 round) Push-pull 08 06 (yellow, .75 round) Push-pull 09 07 (white, .75 round) Push-pull 10 08 (red, .75 round) Push-pull 11 09 (green, .75 round) Push-pull 12 10 (blue, .75 round) Push-p

12、ull 13 11 (yellow, .67 round) Push-pull 14 12 (white, .67 round) Push-pull 15 13 (red, .67 round) Push-pull 16 14 (green, .67 round) Push-pull 17 15 (blue, .67 round) Push-pull 18 16 (yellow, .62 round) Push-pull 19 17 (white, .62 round) Push-pull 20 18 (red, .62 round) Push-pull 21 19 (green, .62 r

13、ound) Push-pull 22 20 (blue, .62 round) Push-pull 23 21 (yellow, .88 square) Push-pull 24 22 (white, .88 square) Push-pull 25 23 (red, .88 square) Push-pull 26 24 (green, .88 square) Push-pull 27 25 (blue, .88 square) Push-pull See footnote at end of table. Provided by IHSNot for ResaleNo reproducti

14、on or networking permitted without license from IHS-,-,-MIL-S-22885/8J 4 TABLE III. Dash numbers - Continued. Dash number Pushbutton M22885/1- Operation 28 01 (yellow, .81 round) Momentary 29 02 (white, .81 round) Push-pull 30 03 (red, .81 round) Momentary 31 04 (green, .81 round) Momentary 32 05 (b

15、lue, .81 round) Momentary 33 06 (yellow, .75 round) Momentary 34 07 (white, .75 round) Momentary 35 08 (red, .75 round) Momentary 36 09 (green, .75 round) Momentary 37 10 (blue, .75 round) Momentary 38 11 (yellow, .67 round) Momentary 39 12 (white, .67 round) Momentary 40 13 (red, .67 round) Momenta

16、ry 41 14 (green, .67 round) Momentary 42 15 (blue, .67 round) Momentary 43 16 (yellow, .62 round) Momentary 44 17 (white, .62 round) Momentary 45 18 (red, .62 round) Momentary 46 19 (green, .62 round) Momentary 47 20 (blue, .62 round) Momentary 48 21 (yellow, .88 square) Momentary 49 22 (white, .88

17、square) Momentary 50 23 (red, .88 square) Momentary 51 24 (white, .88 square) Momentary 52 25 (red, .88 square) Momentary 1/ These are switch housings that do not include pushbutton. The margins of this specification are marked with vertical lines to indicate where modifications from this revision w

18、ere made. This was done as a convenience only and the Government assumes no liability whatsoever for any inaccuracies in these notations. Bidders and contractors are cautioned to evaluate the requirements of this document based on the entire content irrespective of the marginal notations. Reference

19、documents: MIL-PRF-22885 MIL-S-22885/1 Custodians: Preparing activity: Army - CR DLA - CC Navy - EC Air Force - 85 (Project 5930-2008-052) DLA - CC Review activities: Army - AR, AT, AV, CR4, MI Navy - AS, MC, SH Air Force - 19, 99 NOTE: The activities listed above were interested in this document as

20、 of the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.daps.dla.mil/ . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-