DLA A-A-55564 3 C-2012 RESISTOR VOLTAGE SENSITIVE (VARISTOR) METAL OXIDE RADIAL LEAD.pdf

《DLA A-A-55564 3 C-2012 RESISTOR VOLTAGE SENSITIVE (VARISTOR) METAL OXIDE RADIAL LEAD.pdf》由会员分享，可在线阅读，更多相关《DLA A-A-55564 3 C-2012 RESISTOR VOLTAGE SENSITIVE (VARISTOR) METAL OXIDE RADIAL LEAD.pdf（7页珍藏版）》请在麦多课文档分享上搜索。

1、Comments, suggestions, or questions on this document should be addressed to: DLA Land and Maritime, ATTN: VAT, Post Office Box 3990, Columbus, Ohio 43218-3990 or by email Resistordla.mil. Since contact information can change, you may want to verify the currency of this address information using the

2、ASSIST Online database at https:/assist.dla.mil/. AMSC N/A FSC 5905 INCH-POUND A-A-55564/3C 30 August 2012 SUPERSEDING A-A-55564/3B 6 February 2004 COMMERCIAL ITEM DESCRIPTION RESISTOR, VOLTAGE SENSITIVE (VARISTOR), METAL OXIDE, RADIAL LEAD The General Services Administration has authorized the use

3、of this Commercial item description (CID) for all agencies. Inactive for new design after 30 March 2008 Parts manufactured prior to the above date may only be used for replacement purposes. Parts manufactured after above date shall not be supplied to this CID. This complete requirements for procurin

4、g the radial leaded, transient voltage suppression device described herein shall consist of this document and the issue in effect of CID A-A-55564. CLASSIFICATION. This CID uses a classification system which is included in the Part Identification Number (PIN) as shown in the following example (see n

5、otes). AA55564 03 - 001 Abbreviated CID number Applicable CID sheet (two digits) Dash number (see applicable CID sheet) SALIENT CHARACTERISTICS Interface and physical dimensions. The varistors supplied to this CID shall meet the interface and physical dimensions as specified herein (see figure 1). P

6、ower rating. The power rating for the varistor shall be 0.20 watt, 0.25 watt, 0.40 watt, 0.60 watt, and 1.0 watt for cases 1, 2, 3, 4, and 5 respectively Voltage rating. The voltage rating shall be as specified in table I. Energy rating. The energy rating shall be as specified in table I. Provided b

7、y IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55564/3C 2 Peak current. The peak current shall be as specified in table I. Clamping voltage. The clamping voltage shall be as specified in table I. Capacitance. The capacitance shall be as specified in table

8、 I. Operating ambient temperature. The operating ambient temperature range shall be -55OC to +85OC. Storage temperature. The storage temperature shall be -55OC to +125OC. Marking. Varistors supplied to this CID shall be marked with the manufacturers standard commercial PIN. Case code Dimensions A D

9、S B E (max) (max) 0.039 (max) (max) 1 0.394 0.296 0.199 0.227 0.220 2 0.472 0.354 3 0.630 0.492 0.296 0.034 4 0.787 0.689 5 1.043 0.906 Inches mm Inches mm Inches mm Inches mm 0.034 0.86 0.227 5.79 0.472 11.99 0.787 19.99 0.039 0.99 0.296 7.52 0.492 12.50 0.906 23.01 0.199 5.05 0.354 8.99 0.630 16.0

10、0 1.043 26.49 0.220 5.59 0.394 10.01 0.689 17.50 NOTES: 1. All dimensions are in inches. 2. Metric equivalents are given for general information. FIGURE 1. Case dimension and configuration. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55564/3C

11、 3 TABLE I. Rating and characteristics. Dash number Case code Voltage rating (max) Energy in Joules (max) (J) Peak current (amperes) Varistor voltage with 1mA dc test current Max clamping voltage at test current Typical capacitance (picofarads) (rms) (dc) (min) (max) (V) (I) 01 1 14 18 0.20 35 18.7

12、26 51 2 800 02 2 14 18 0.90 150 18.7 26 47 5 1600 03 3 14 18 2.00 350 18.7 26 43 5 4000 04 4 14 18 4.00 750 18.7 26 43 10 9000 05 5 14 18 6.50 1500 19.2 26 43 20 18000 06 1 17 22 0.25 35 23 31.1 59 2 600 07 2 17 22 1.00 150 23 31.1 57 5 1300 08 3 17 22 2.50 350 23 31.1 53 5 3000 09 4 17 22 5.00 750

13、23 31.1 53 10 7000 10 5 17 22 8.00 1500 23 31.1 50 20 13000 11 1 20 26 0.30 35 29.5 38 67 2 500 12 2 20 26 1.20 150 29.5 36.5 68 5 1100 13 3 20 26 3.00 350 29.5 36.5 64 5 2700 14 4 20 26 6.00 750 29.5 36.5 64 10 6000 15 5 21 27 9.00 1500 29.5 36.5 58 20 13000 16 5 23 31 10.00 1500 32 40 63 20 12000

14、17 1 25 31 0.35 35 35 46 79 2 220 18 2 25 31 1.50 150 35 43 79 5 500 19 3 25 31 3.50 350 35 43 76 5 1100 20 4 25 31 7.20 750 35 43 76 10 2700 21 1 30 38 0.40 35 42 55 90 2 6000 22 2 30 38 1.80 150 42 52 92 5 400 23 3 30 38 4.50 350 42 52 89 5 2000 24 4 30 38 8.80 750 42 52 89 10 4500 25 1 35 45 0.50

15、 35 50 66 108 2 360 26 2 35 45 2.30 150 50 62 107 5 700 27 3 35 45 5.50 350 50 62 103 5 1800 28 4 35 45 10.00 750 50 62 103 10 3900 29 1 40 56 0.60 35 61 80 127 2 300 30 2 40 56 3.00 150 61 75 127 5 600 31 3 40 56 6.50 350 61 75 123 5 1500 32 4 40 56 13.00 750 61 75 123 10 3300 33 1 50 66 1.20 150 7

16、3 97 145 2 240 34 2 50 66 3.50 500 73 91 135 10 500 35 3 50 66 7.30 1000 73 91 135 25 1100 36 4 50 66 13.00 2000 73 91 145 50 2500 37 1 60 81 1.50 150 90 117 175 2 180 38 2 60 81 4.30 500 90 110 165 10 400 39 3 60 81 8.90 1000 90 110 165 25 900 40 4 60 81 16.00 2000 90 110 175 50 2000 41 1 75 102 1.

17、80 150 108 138 205 2 140 42 2 75 102 5.30 500 108 132 205 10 300 43 3 75 102 11.00 1000 108 132 200 25 750 44 4 75 102 19.00 2000 108 132 210 50 1700 45 1 92 127 2.30 200 135 173 240 2 120 46 2 95 127 6.50 750 135 165 250 10 250 47 3 95 127 13.00 1500 135 165 250 25 600 48 4 95 127 23.00 3000 135 16

18、5 255 50 1400 49 1 115 153 2.70 200 162 207 290 2 100 TABLE I. Rating and characteristics. Continued Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55564/3C 4 Dash number Case code Voltage rating (max) Energy in Joules (max) (J) Peak current (am

19、peres) Varistor voltage with 1mA dc test current Max clamping voltage at test current Typical capacitance (picofarads) (rms) (dc) (min) (max) (V) (I) 50 2 115 153 7.70 750 162 198 295 10 200 51 3 115 153 16.00 1500 162 198 300 25 500 52 4 115 153 27.00 3000 162 198 300 50 1100 53 1 4 5.5 0.10 50 6 1

20、1 30 1 1400 54 2 4 5.5 0.40 100 6 11 22 2.5 3000 55 3 4 5.5 0.80 250 6 11 20 5 7500 56 1 6 8 0.14 50 9 16 37 1 1200 57 2 6 8 0.60 100 9 16 34 2.5 2500 58 3 6 8 1.20 250 9 16 30 5 6000 59 1 10 14 0.17 100 14.4 21.6 36 1 1000 60 2 10 14 0.80 250 14.4 21.6 36 2.5 2000 61 3 10 14 1.50 500 14.4 21.6 36 5

21、 5000 62 4 10 14 3.50 1000 14.4 21.6 36 10 11000 63 5 10 14 80.00 2000 14.4 21.6 37 20 22000 NOTES. PIN. The PIN should be used for Government purposes to buy commercial products to this CID. See classification information for PIN format example. Commercial and Government Entity (CAGE) code. For ord

22、ering purposes, inventory control, and submission of these resistors to DSCC under the Military Parts Control Advisory Group (MPCAG) evaluation program, CAGE code 58536 should be used. Source of documents. Commercial Item Description A-A-55564 - Resistor, Voltage Sensitive (Varistor). (Copies of the

23、se documents are available online at https:/assist.dla.mil/quicksearch/ or from the Standardization Document Order Desk, 700 Robbins Avenue, Building 4D, Philadelphia, PA 19111-5094). Ordering data. Ordering data is as specified in A-A-55564. Commercial products. As part of the market analysis and r

24、esearch effort, this CID was coordinated with the following manufacturers of commercial products. At the time of CID preparation and coordination, these manufacturers were known to have commercial products that would meet the requirements of this CID. (NOTE: This information should not be considered

25、 as a list of approved manufacturers or be used to restrict procurement to only the manufacturers shown). Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55564/3C 5 TABLE II. Commercial products. MFRs CAGE MFRs name and address S6019 1/ Sales: Li

26、ttelfuse, Inc. 8755 West Higgins Road Suite 500 Chicago, IL 60631 Phone: (773) 628.1000 Website: http:/ Plant: Littelfuse, Inc. The Demesne Dundalk, County Louth Republic of Ireland 1/ Parts manufactured prior to 30 March 2008 may only be used for replacement purposes Parts manufactured after 30 Mar

27、ch 2008 shall not be supplied to this CID. Part number (P/N) supersession data. These CID part numbers supersede the following MFRs P/Ns as shown. This information is being provided to assist in reducing proliferation in the Government inventory system. Provided by IHSNot for ResaleNo reproduction o

28、r networking permitted without license from IHS-,-,-A-A-55564/3C 6 TABLE III. P/N supersession data. Dash number AA5556403- MFRs P/N 1/ 2/ Dash number AA5556403- MFRs P/N 1/ 2/ Dash number AA5556403- MFRs P/N 1/ 2/ MFRs CAGE 001 V22ZA05 022 V47ZA1 043 V120ZA4 S6019 002 V22ZA1 023 V47ZA3 044 V120ZA6

29、003 V22ZA2 024 V47ZA7 045 V150ZA05 004 V22ZA3 025 V56ZA05 046 V150ZA1 005 V24ZA50 026 V56ZA2 047 V150ZA4 006 V27ZA05 027 V56ZA3 048 V150ZA8 007 V27ZA1 028 V56ZA8 049 V180ZA05 008 V27ZA2 029 V68ZA05 050 V180ZA1 009 V27ZA4 030 V68ZA2 051 V180ZA5 010 V27ZA60 031 V68ZA3 052 V180ZA10 011 V33ZA05 032 V68Z

30、A10 053 V8ZA05 012 V33ZA1 033 V82ZA05 054 V8ZA1 013 V33ZA2 034 V82ZA2 055 V8ZA2 014 V33ZA5 035 V82ZA4 056 V12ZA05 015 V33ZA70 036 V82ZA12 057 V12ZA1 016 V36ZA80 037 V100ZA05 058 V12ZA2 017 V39ZA05 038 V100ZA3 059 V18ZA05 018 V39ZA1 039 V100ZA4 060 V18ZA1 019 V39ZA3 040 V100ZA15 061 V18ZA2 020 V39ZA6

31、 041 V120ZA05 062 V18ZA3 021 V47ZA05 042 V120ZA1 063 V18ZA40 1/ The manufacturers P/N shall not be used for procurement to the requirements of this CID. At the time of preparation of this CID, the aforementioned commercial products were reviewed and could be replaced by the CID PIN shown. For actual

32、 part marking requirements, see the marking paragraph. 2/ Parts manufactured prior to 30 March 2008 may only be used for replacement purposes Parts manufactured after 30 March 2008 shall not be supplied to this CID. National stock number (NSN). The following is a list of NSNs assigned which correspo

33、nd to this CID specification sheet. The list is for information only and may not be indicative of all possible NSNs associated with the CID specification sheet. For up to date information on assigned NSNs, please contact the aforementioned DLA Land and Maritime office listed in A-A-55564. TABLE IV.

34、NSNs. Dash number (see table I) AA5556403 NSN -016 5905-01-530-2075 -044 5905-01-571-0997 Government users. To acquire information on obtaining these resistors from the Government inventory system, contact DLA Land and Maritime, ATTN: FMX, Post Office Box 3990, Columbus, OH 43216-5000, or telephone

35、(614) 692-3677. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55564/3C 7 Changes from previous issue. The margins of this CID are marked with vertical lines to indicate where changes from the previous issue were made. This was done as a conveni

36、ence only and the Government assumes no liability whatsoever for any inaccuracies in these notations. Bidders and contractors are cautioned to evaluate the requirements of this document based on the entire content irrespective of the marginal notations and relationship to the last previous issue. MI

37、LITARY INTERESTS: CIVIL AGENCY COORDINATING ACTIVITY: GSA - FAS Custodians: Navy - EC Preparing Activity: DLA - CC DLA - CC Project 5905-2012-052 NOTE: The activities listed above were interested in this document as the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.dla.mil. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-