ARMY MIL-PRF-53136-1996 GUN LAYING AND POSITIONING (GLPS)《火炮落点定位系统(GLPS)》.pdf

《ARMY MIL-PRF-53136-1996 GUN LAYING AND POSITIONING (GLPS)《火炮落点定位系统(GLPS)》.pdf》由会员分享，可在线阅读，更多相关《ARMY MIL-PRF-53136-1996 GUN LAYING AND POSITIONING (GLPS)《火炮落点定位系统(GLPS)》.pdf（26页珍藏版）》请在麦多课文档分享上搜索。

1、 MIL-PRF-53L36 9Ob 2023604 Ob9 MIL-PRF-53136 5 Auaust 1996 PERFORMANCE SPECIFICATION GUN LAYING AND POSITIONING SYSTEM (GLPS) This specification is approved for use by all Departments and Agencies of the Department of Defense 1. SCOPE 1.1 Scoie. This specification covers an automated Gun Laying and

2、Positioning System (GLPS). 2. APPLICABLE DOCUMENTS 2.1 Genea. The documents listed in this section are specified in sections 3 and 4 of this specification. This section does not include documentation cited in other sections of this specification or recommended for additional information or as exampl

3、es. While effort has been made to ensure completeness of this list, document users are cautioned that they must meet all specified requirements documents cited in sections 3 and 4 of this specification, whether or not they are listed. 2.2 Government documents 2.2.1 Snecification s, standards. an d h

4、andbook s. The following specifica- tions, standards, and handbooks form a part of this document to the extent specified herein. Unless otherwise specified, the issues of these documents are those listed in the issue of the Department of Defense Index of Specifi- cations and Standards (DODISS) and s

5、upplement thereto, cited in the solicitation (see 6.2). ICD-GPS-153 - GPS User Equipment Interface Control Document for the RS-232/RS-422 Interface of DoD Standard GPS UE Radio Receivers (Unless otherwise indicated, copies of federal and military specifications, standards, and handbooks are availabl

6、e from the Standardization Document Order Desk, Building 4D, 700 Robbins Avenue, Philadelphia, PA 19111-5094.) I i Beneficial comments, recommendations, additions, deletions, clarifications etc., and any other data which may improve this document should be sent to: U.S. ARMY TOPOGRAPHIC ENGINEERING

7、CENTER, ATTN CETEC-PD-TE, 7701 TELEGRAPH ROAD, ALEXANDRIA, VA 22315-3864. I J AMSC N/A FSC 6675 DISTRIB UTION STATE MENT A. Approved for public release; distribution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- MIL-PRF-53136 9999906

8、 2021605 TT5 W MIL- PRF- 5 3 13 6 2.3 Fon-Government Dublications . The following documents form a part of this specification to the extent specified herein. Unless otherwise specified, the issues of the documents which are DoD adopted are those listed in the issue of the DODISS cited in the solicit

9、ation. Unless otherwise specified, the issues of documents not listed in the DoDISS are the issues of the documents cited in the solicitation. American National Standards Institute, ANSI 2136.1 2.4 Order of txecedence. In the event of a conflict between the text of this document and the references c

10、ited herein, the text of this document takes precedence. Nothing in this document, however, supersedes applicable laws and regulations unless a specific exemption has been obtained. 3. REQUIREMENTS Svstem descriDtion 3.1 . The Gun Laying and Positioning System, herein- after referred to as “GLPS“, s

11、hall consist of the major components in 3.1.1 and additional components in 3.1.2. The azimuth gyroscope, electronic digital optical instrument, and laser rangefinder shall be fully integrated with an embedded microprocessor and control and display system for computation and display of gun laying and

12、 positioning data. Optics shall be integrated to the maximum extent possible. The Precision Lightweight Global Positioning System Receiver, hereafter referred to as “PLGR“, shall be provided by the Government tripod, and integrated both physically and electronically without the use of external wires

13、 or cables (except for the PLGR, see 3.1.1.4). When assembled, the GLPS shall be capable of being precisely centered over a survey control point. (see 3.1.1.41. The assembled GLPS shall be battery powered, mounted on a Uaior comDonent list and characteristics 3.1.1 3.1.1.1 Azimuth. The azimuth gyros

14、cope shall be capable of automatically determining grid azimuths with respect to true north. It shall be integrated with the electronic digital optical instrument, laser range- finder, battery/battery pack, illuminating target rod, and microprocessing, data control and display system without the use

15、 of external wires or cables. Electronic Diutal OPtical bstrum 3.1.1.2 ent. The optical instrument shall be an electronic digital horizontal and vertical angle measuring instrument. It shall be integrated with the azimuth gyroscope, laser range- finder, battery/battery pack, illuminating target rod,

16、 and microprocessing, data control and display system without the use of external wires or cables. The reticleshall be capable of being illuminated with an adjustable intensity. The reticle pattern shall be a cross, similar to that used in other U.S. field artillery reticles. 3.1.1.3 aef-. The laser

17、 rangefinder shall be eye safe (see 3.8). It shall be integrated with the azimuth gyroscope, electronic digital optical instrument, battery/battery pack, illuminating target rod, and microprocessing, data control and display system without the use of external wires or cables. Laser and optical instr

18、ument optics shall be integrated to the maximum extent possible. Prec 3.1.1.4 ision JO iahtweiaht Global Positionina Svstem Re ceiver (PLGR). The PLGR will be provided by the Government to military units using the GLPS. . 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without

19、 license from IHS-,-,-MIL-PRF-53136 E 9999906 2023606 931 = MIL-PRF-53136 It shall be powered by its own internal battery and mounted separately on the tripod with a mounting bracket provided by the contractor. An RS-232/ RS-422 interface cable shall be provided by the contractor to connect the PLGR

20、 to the GLPS (see 3.4.1). The PLGR shall be capable of being detached from the tripod for use elsewhere without affecting the GLPS performance. 3.1.1.5 Trinod. The tripod shall be a collapsable telescopic leg type with provisions for mounting the assembled GLPS and the separate PLGR. It shall have a

21、n adjustable height range from 35 12 to 53 +2 inches and be as lightweight as possible, consistent with the needed stability and overall weight requirements of the GLPS. Tripod feet shall be pointed to prevent slipping on sloped and muddy surfaces. A shoulder sling shall be provided for carrying the

22、 tripod. 3.1.1.6 Dansrort caselsl. The transport case(s) shall be capable of stowing all components, parts, materials, supplies, tools, and other items that are required for the GLPS to perform as specified herein (with exception of the PLGR and tripod). Each case shall be provided with a pressure r

23、elief valve and equipped with a carrying handle(s) for a one or two person lift, as appropriate (see 3.9.d). Case(s) shall be seamless or welded seam construction and capable of being decontaminated using military standard decontaminating procedures and materials. The case(s) shall protect the GLPS

24、from the environmental and transportability conditions described in 3.5 and 3.6. The use of military standard cases is preferred. 3.1.1.7 Batterv/batterv Dack. A single rechargeable battery or battery pack shall be used to power the GLPS (except the PLGR, see 3.1.1.4). A DoD approved battery/battery

25、 pack with a National Stock Number (NSN) is preferred. An additional battery/battery pack shall be provided as a spare. Battery enclosures shall be constructed so that battery venting or leakage will not damage other GLPS components. Batteries shall be attached to the GLPS without the use of externa

26、l wires or cables. Batteries shall be easily removable when being stored or exchanged for a newly charged battery/battery pack. To remove and replace the battery/battery pack shall not take longer than one minute. 3.1.1.8 Jlluminatina taraet r od. The illuminating target rod shall be adapted to the

27、GLPS without the use of external wires or cables. The target rod shall use a standard light bulb with a NSN. The bulb shall be easily accessible for replacement. 3.1.2 Additional CO mDonent list and character ictics 3.1.2.1 Batten ch arclez . A battery charger shall be supplied with each GLPS for th

28、e recharging of its batteries/battery packs. Cables with appro- priate clips and/or plugs shall be provided with the battery charger (see 3.1.2.5). Power conditionex 3.1.2.2 . If a separate power conditioner is needed for operation of the GLPS from the military vehicle battery, one shall be provided

29、 with each GLPS (see 3.4.6). 3.1.2.3 protective cover, A protective cover shall be provided with each GLPS. The cover shall fit over the electrical components when set up for operation and protect them from wind driven rain, ice, sand, and dust when not being operztod. The cover shall be constructed

30、 of a lightweight material capable of i.= in high and low temperatures (see 3.5.1). 3 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-53136 H 9799706 2023607 878 MIL-PRF-53136 3.1.2.4 Winteation kit . If a separate winterization kit is needed

31、 for operation at low temperatures (see 3.5.1), one shall be provided when specified (see 6.2). 3.1.2.5 Uectrical cables. receDtacles. and fuses. Electrical cables required for the GLPS operation from a back-up power source (see 3.4.6), for the battery charger (see 3.1.2.11, for the winterization ki

32、t (when provided, see 3.1.2.41, and for interface between GLPS and the PLGR (see 3.1.1.4) shall be provided with the GLPS. Cables shall be sized correctly to carry the power, be insulated with material that will withstand cold temperature to -46 C without breaking or cracking, and be provided with a

33、ppropriate connecting clamps and plugs. Cables to the vehicle battery shall be provided with the NATO plug adapter. Electrical receptacles on GLPS components (including cables) shall be provided with protective covers when not in use. The protective covers shall be captive retained. Fuses shall be s

34、tandard with NSNs and easily accessible for replacement. 3.1.2.6 TriDod base. When specified (see 6.2), a tripod base shall be supplied to securely position the tripod on hard surfaces, such as floors, and prevent damage to the surface. The tripod base is for use in training environ- ments for demon

35、stration and instructional purposes. 3.1.2.7 Tools. niaterMc. su and accurate to 0.67 mil (PE) between 65“ and 75“ North and South latitudes. 3.4.2.4 Banue. The laser rangefinder shall determine ranges between 30 meters and 2000 meters with an accuracy of +3 meters without the use of reflectors or p

36、risms. 3.4.3 SetuD time. The GLPS shall not require pre-alignment. It shall be capable of being set up for operation in 5 minutes or less, and in 7 minutes when in mission-oriented protective posture (MOPP) IV (Setup is defined in 6.4.2). When a means to level the GLPS is provided, the time required

37、 for leveling shall be included in the setup time. When a winterization kit is used at low temperatures (see 3.1.2.41, the installation and warmup period shall not be included in the setup time. 3.4.4 ission times. The GLPS shall be capable of deriving position and deflection to the first howitzer w

38、ithin 4 minutes after setup and power is applied to the gyroscope, and shall require not more than 1 additional minute to derive position and deflection for each subsequent howitzer. When a winter- 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MI

39、L-PRF-53L36 m 999990b 2023609 640 m MIL-PRF-53136 ization kit is used at low temperatures (see 3.1.2.4), the warmup period shall not be included in the mission time. 3.4.5 MicroDrocessina. data control and d isDlav . The GLPS shall collect, compute, and display all required data (i.e., slope distanc

40、e, vertical angle, grid azimuth, deflection angle, GLPS coordinates and elevation, and howitzer coordinates and elevations). The microprocessor shall have a non-volatile memory of adequate capacity to store all GLPS constants and operating para- meters including at least eight data blocks for refere

41、nce points, howitzer positions, position of the orientating station and other targets; and random access memory with enough capacity to perform required computations. The microprocessor shall provide initiation and control of a system self-test. The self-test shall display possible errors in operati

42、on and failures of components including but not limited to power source, gyroscope, rangefinder and optical instrument; and shall include a battery low charge warning to alert the operator when the battery/battery pack needs to be replaced. The low charge warning shall be displayed before the batter

43、y fails and the operator shall be able to complete a mission (see 6.4.3) before replacing the battery. The GLPS shall not lose data while any of the power sources are being correctly removed or replaced. If a memory battery is used, it must be rechargeable, or easily accessible for replacement with

44、a NSN battery. Visual displays shall be as simple as possible and they shall be designed to: a. provide only task essential information to operators and maintainers; b. cue appropriate actions; c. preclude ambiguities; d. provide logical-intuitive steps to task accomplishment; e. communicate directl

45、y; and f. make comprehension easy. The data control and display system shall conform to good human factors design (see 3.9.f). When specified (see 6.2), the contractor shall propose menu driven prompts and visual displays to the Government for approval prior to putting them into effect. 3.4.6 Pvstem

46、 Powey. The battery/battery pack used to power the GLPS shall have sufficient ampere-hour capacity for the GLPS to conduct not less than 20 missions (see 6.4.3). The GLPS shall be capable of being operated using power supplied directly from a military vehicle 24 volt dc battery, using the NATO recep

47、tacle, as a back-up power source. Cables provided for this purpose, shall not be less than five meters long. The battery charger (see 3.1.2.1) shall be capable of charging a single GLPC battery, as well as simultaneously charging all batteries provided with the GLPS, from both 110 and 220 volt ac 50

48、 and 60 hertz utility power sources, and also directly from a 24 volt dc military vehicle battery. The battery charger shall be capable of recharging the batteries with minimal degradation to their operational life span. 3.4.7 tina taraet rod. The illuminating target rod shall be centered on the ver

49、tical axis of the optics and capable of being seen 360“ through a howitzers panoramic telescope at distances up to 400 meters during 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-flTL-PRF-53L36 E b 202LbLO 362 O MIL-PRF- 53 13 6 darkness, under clear visibility. The illumination shall be a red light adjustable from off to high intensity. 3.5 ironmental remire- 3.5.1 and low temDeratures. The GLPS shall perform as